Preparation of activated carbons from bio-waste: effect of surface functional groups on methylene blue adsorption

Low-cost activated carbons were prepared by physical activation of bio-waste rice husk. Various physicochemical characterization techniques confirmed the high surface area and oxygen functional groups on the surface. It has been confirmed that activation under humidified carbon dioxide followed by ozonation resulted the highest number of surface functional groups on activated carbon. Nitrogen adsorption–desorption isotherms confirmed the highest surface area (417 m2/g), whereas elemental analysis ensured the increasing oxygen content after activation. Temperature-programmed decomposition quantified these surface oxygen functional groups, and it was concluded that ozonation increased both acidic and basic groups. The developed activated carbons were tested during the removal of a model dye methylene blue from aqueous medium in the concentration range 10–30 mg/L. Typical results indicated that adsorption studies are consistent with the Langmuir isotherm model with maximum monolayer adsorption capacity of 28.5 mg/g, and the dimensionless separation factor (RL) values between 0.006 and 0.030 confirmed a favorable adsorption. Methylene blue adsorption followed pseudo-second order kinetics indicating MB was adsorbed onto the surface via chemical interaction.

[1]  B. Phanikumar,et al.  Adsorption of reactive dyes from aqueous solutions by tannery sludge developed activated carbon: Kinetic and equilibrium studies , 2011 .

[2]  Vinod K. Gupta,et al.  Photo-catalytic degradation of toxic dye amaranth on TiO(2)/UV in aqueous suspensions. , 2012, Materials science & engineering. C, Materials for biological applications.

[3]  A. Mittal,et al.  Adsorption of Safranin-T from wastewater using waste materials- activated carbon and activated rice husks. , 2006, Journal of colloid and interface science.

[4]  Shubhi Jain,et al.  Removal of chlorophenols using industrial wastes. , 2004, Environmental science & technology.

[5]  S. K. Srivastava,et al.  Kinetics of mercury adsorption from wastewater using activated carbon derived from fertilizer waste , 2001 .

[6]  Peng Wang,et al.  Modification of bamboo-based activated carbon using microwave radiation and its effects on the adsorption of methylene blue , 2010 .

[7]  Xinhua Xu,et al.  Removal of Cu(II) from aqueous solution using the rice husk carbons prepared by the physical activation process , 2011 .

[8]  C. Zaror,et al.  Effect of Ozone Treatment on Surface Properties of Activated Carbon , 2002 .

[9]  Evan Diamadopoulos,et al.  Production of activated carbon from bagasse and rice husk by a single-stage chemical activation method at low retention times. , 2008, Bioresource technology.

[10]  Maneesh Kumar Singh,et al.  Colour Removal from Synthetic Dye Wastewater Using a Bioadsorbent , 2000 .

[11]  B. Girgis,et al.  Removal of methylene blue by carbons derived from peach stones by H3PO4 activation: Batch and column studies , 2008 .

[12]  B. Hameed,et al.  Degradation of malachite green in aqueous solution by Fenton process. , 2009, Journal of hazardous materials.

[13]  S. Ucar,et al.  Activated carbons from waste biomass by sulfuric acid activation and their use on methylene blue adsorption. , 2008, Bioresource technology.

[14]  Feng-Chin Wu,et al.  The Ability of Activated Clay for the Adsorption of Dyes from Aqueous Solutions , 1997 .

[15]  A. Mittal,et al.  Adsorption of hazardous dye crystal violet from wastewater by waste materials. , 2010, Journal of colloid and interface science.

[16]  A. Sivasamy,et al.  Adsorption isotherms, kinetics and mechanism for the adsorption of cationic and anionic dyes onto carbonaceous particles prepared from Juglans regia shell biomass , 2013, International Journal of Environmental Science and Technology.

[17]  M. Lillo-Ródenas,et al.  High surface area materials prepared from sewage sludge-based precursors. , 2006, Chemosphere.

[18]  A. Mittal,et al.  Decoloration treatment of a hazardous triarylmethane dye, Light Green SF (Yellowish) by waste material adsorbents. , 2010, Journal of colloid and interface science.

[19]  N. Kannan,et al.  Kinetics and mechanism of removal of methylene blue by adsorption on various carbons—a comparative study , 2001 .

[20]  Dinesh Mohan,et al.  Removal of Basic Dyes (Rhodamine B and Methylene Blue) from Aqueous Solutions Using Bagasse Fly Ash , 2000 .

[21]  A. Mittal,et al.  Adsorption and desorption studies of a water soluble dye, Quinoline Yellow, using waste materials. , 2005, Journal of colloid and interface science.

[22]  B. Hameed,et al.  Batch adsorption of methylene blue from aqueous solution by garlic peel, an agricultural waste biomass. , 2009, Journal of hazardous materials.

[23]  C. Subrahmanyam,et al.  Low cost adsorbents from agricultural waste for removal of dyes , 2014 .

[24]  S. Allen,et al.  Effect of carbon surface chemistry on the removal of reactive dyes from textile effluent , 2000 .

[25]  J. Basu,et al.  Adsorption of Reactive Dyes from a Textile Effluent Using Sawdust as the Adsorbent , 2006 .

[26]  C. Saka,et al.  Preparation and characterization of activated carbon from cotton stalks in a two-stage process , 2011 .

[27]  Farid Nasir Ani,et al.  Preparing activated carbon from various nutshells by chemical activation with K2CO3 , 2002 .

[28]  A. Sivasamy,et al.  Preparation of char from lotus seed biomass and the exploration of its dye removal capacity through batch and column adsorption studies , 2013, Environmental Science and Pollution Research.

[29]  Suhas,et al.  A Comparative Study of Adsorbents Prepared from Industrial Wastes for Removal of Dyes , 2003 .

[30]  José L. Figueiredo,et al.  Adsorption of dyes on activated carbons: influence of surface chemical groups , 2003 .

[31]  James A. Schwarz,et al.  Effect of HNO3 treatment on the surface acidity of activated carbons , 1990 .

[32]  K. Nath,et al.  Preparation of activated carbon from dried pods of Prosopis cineraria with zinc chloride activation for the removal of phenol , 2013, Environmental Science and Pollution Research.

[33]  C. Subrahmanyam,et al.  Degradation and mineralization of methylene blue by dielectric barrier discharge non-thermal plasma reactor , 2013 .

[34]  C. Subrahmanyam,et al.  Catalytic nonthermal plasma reactor for the abatement of low concentrations of benzene , 2014, International Journal of Environmental Science and Technology.

[35]  L. Chekir‐Ghedira,et al.  Alteration of in vitro and acute in vivo toxicity of textile dyeing wastewater after chemical and biological remediation , 2012, Environmental Science and Pollution Research.

[36]  Mohammad Danish,et al.  The use of date palm as a potential adsorbent for wastewater treatment: a review , 2012, Environmental Science and Pollution Research.

[37]  V. Gupta,et al.  Biosorption of hexavalent chromium by raw and acid-treated green alga Oedogonium hatei from aqueous solutions. , 2009, Journal of hazardous materials.

[38]  B. Sreedhar,et al.  Low-cost adsorbents from bio-waste for the removal of dyes from aqueous solution , 2013, Environmental Science and Pollution Research.

[39]  J. Figueiredo,et al.  Modification of the surface chemistry of activated carbons , 1999 .

[40]  A. Mittal,et al.  Process development for the batch and bulk removal and recovery of a hazardous, water-soluble azo dye (Metanil Yellow) by adsorption over waste materials (Bottom Ash and De-Oiled Soya). , 2008, Journal of hazardous materials.

[41]  Leandro S. Oliveira,et al.  Kinetics and equilibrium studies of methylene blue adsorption by spent coffee grounds. , 2009 .

[42]  François Béguin,et al.  Surface functionality and porosity of activated carbons obtained from chemical activation of wood , 2000 .

[43]  Shamik Chowdhury,et al.  Adsorption thermodynamics, kinetics and isosteric heat of adsorption of malachite green onto chemically modified rice husk , 2011 .

[44]  C. Subrahmanyam,et al.  Green Approach for Wastewater Treatment—Degradation and Mineralization of Aqueous Organic Pollutants by Discharge Plasma , 2012 .

[45]  W. Tsai,et al.  Adsorption kinetics of herbicide paraquat in aqueous solution onto a low-cost adsorbent, swine-manure-derived biochar , 2013, International Journal of Environmental Science and Technology.