Improved passivation effect at the amorphous/crystalline silicon interface due to ultrathin SiOx layers pre-formed in chemical solutions

To improve the passivation effect at a-Si:H/c-Si interface in heterojunction (HJ) solar cells, ultrathin SiOx layers with a thickness of approximately 2 nm were pre-formed on c-Si surfaces in chemical solutions. It was demonstrated that the SiOx layers pre-formed in hot de-ionized water and hydrochloric acid solutions improve effective carrier lifetime, and it is further enhanced through a post annealing process. When the thin SiOx layers were applied to HJ solar cells, increase in both Voc and Jsc was achieved, implying the improved interface quality for these HJ solar cells, as compared with the reference without the SiOx layer.

[1]  Wilhelm Warta,et al.  Solar cell efficiency tables (version 42) , 2013 .

[2]  U. Rau,et al.  Optimized amorphous silicon oxide buffer layers for silicon heterojunction solar cells with microcrystalline silicon oxide contact layers , 2013 .

[3]  L. Korte,et al.  Hydrogen plasma treatments for passivation of amorphous-crystalline silicon-heterojunctions on surfaces promoting epitaxy , 2013 .

[4]  C. Klimm,et al.  Detailed investigation of the structural and passivation properties of silicon oxynitrides for silicon solar cells , 2012 .

[5]  U. Rau,et al.  Analysis of sub-stoichiometric hydrogenated silicon oxide films for surface passivation of crystalline silicon solar cells , 2012 .

[6]  V. Mihailetchi,et al.  Nitric acid pretreatment for the passivation of boron emitters for n-type base silicon solar cells , 2008 .

[7]  H. Fujiwara,et al.  Application of hydrogenated amorphous silicon oxide layers to c-Si heterojunction solar cells , 2007 .

[8]  Yanfa Yan,et al.  Atomic structure and electronic properties of c-Si∕a-Si:H heterointerfaces , 2006 .

[9]  P. Besson,et al.  Non uniformities of silicon oxide films grown in peroxide mixtures , 2005 .

[10]  H. Angermann,et al.  Wet-chemical preparation and spectroscopic characterization of Si interfaces , 2004 .

[11]  C. Clerc,et al.  Structure and hydrogen content of polymorphous silicon thin films studied by spectroscopic ellipsometry and nuclear measurements , 2004 .

[12]  Takuya Kobayashi,et al.  Ultrathin silicon dioxide layers with a low leakage current density formed by chemical oxidation of Si , 2002 .

[13]  A. Cuevas,et al.  General parameterization of Auger recombination in crystalline silicon , 2002 .

[14]  H. Ogawa,et al.  Effects of Dissolved Oxygen in HF Solution on Silicon Surface Morphology , 1995 .

[15]  M. Green,et al.  Surface recombination velocity measurements at the silicon–silicon dioxide interface by microwave‐detected photoconductance decay , 1994 .

[16]  T. Ohmi,et al.  Growth of native oxide on a silicon surface , 1990 .

[17]  D. Aspnes.  Studies of surface, thin film and interface properties by automatic spectroscopic ellipsometry , 1981 .

[18]  H. Fujiwara,et al.  Understanding of passivation mechanism in heterojunction c-Si solar cells , 2008 .