Low thermal budget Hf/Al/Ta ohmic contacts for InAlN/GaN-on-Si HEMTs with enhanced breakdown voltage

The authors have studied the electrical characteristics of Hf/Al/Ta ohmic contacts on In0.18Al0.82N/GaN heterostructure grown on Si (111) substrate. With annealing at 600 °C in vacuum (which is ∼200 °C lower than that for traditional Ti/Al/Ni/Au contacts), a minimum ohmic contact resistance of ∼0.58 Ω·mm and specific contact resistivity of ∼6.75 × 10−6 Ω·cm2 are obtained. The minimum contact resistance of Hf/Al/Ta contacts is comparable to that of Ti/Al/Ni/Au contacts. Owing to the lower annealing temperature, Hf/Al/Ta contacts exhibit better surface morphology and edge acuity. More importantly, Hf/Al/Ta contacts show a smooth interface with In0.18Al0.82N/GaN, whereas spike structures that penetrate the In0.18Al0.82N layer are observed for Ti/Al/Ni/Au contacts. As a result, the source–carrier-injection induced breakdown mechanism is reduced in the In0.18Al0.82N/GaN-on-Si high electron mobility transistors (HEMTs) with Hf/Al/Ta ohmic contacts, thereby leading to an improved three-terminal off-state breakdo...

[1]  F. Ren,et al.  Annealing temperature dependence of Ohmic contact resistance and morphology on InAlN/GaN high electron mobility transistor structures , 2011 .

[2]  J. Kwak,et al.  Low resistance Al/Ti/n-GaN ohmic contacts with improved surface morphology and thermal stability , 2000 .

[3]  S. Keller,et al.  Effect of ohmic contacts on buffer leakage of GaN transistors , 2006, IEEE Electron Device Letters.

[4]  A. Crespo,et al.  RF Power Measurements of InAlN/GaN Unstrained HEMTs on SiC Substrates at 10 GHz , 2007, IEEE Electron Device Letters.

[5]  Marc Porti,et al.  Micro and nano analysis of 0.2 Ω mm Ti/Al/Ni/Au ohmic contact to AlGaN/GaN , 2011 .

[6]  S. Mohammad.  Contact mechanisms and design principles for alloyed ohmic contacts to n-GaN , 2004 .

[7]  Yasuhito Gotoh,et al.  Measurement of work function of transition metal nitride and carbide thin films , 2003 .

[8]  Bo Zhang,et al.  Schottky-Contact Technology in InAlN/GaN HEMTs for Breakdown Voltage Improvement , 2013, IEEE Transactions on Electron Devices.

[9]  Xiang Gao,et al.  InAlN/GaN HEMTs With AlGaN Back Barriers , 2011, IEEE Electron Device Letters.

[10]  I. Petrov,et al.  Growth and physical properties of epitaxial metastable Hf1 − xAlxN alloys deposited on MgO(001) by ultrahigh vacuum reactive magnetron sputtering , 2007 .

[11]  G. Bahir,et al.  Characteristics of In/sub x/Al/sub 1-x/N-GaN high-electron mobility field-effect transistor , 2005, IEEE Transactions on Electron Devices.

[12]  O. P. Kulik,et al.  Kinetics of hafnium nitride formation in nitrogen and ammonia streams , 1974 .

[13]  Yilong Hao,et al.  High temperature induced failure in Ti/Al/Ni/Au Ohmic contacts on AlGaN/GaN heterostructure , 2012, Microelectron. Reliab..

[14]  J. Kuzmik,et al.  Power electronics on InAlN/(In)GaN: Prospect for a record performance , 2001, IEEE Electron Device Letters.

[15]  Stephen J. Pearton,et al.  Fabrication and performance of GaN electronic devices , 2000 .

[16]  J. Fraser,et al.  Comparison of two different Ti/Al/Ti/Au ohmic metallization schemes for AlGaN/GaN , 2002 .

[17]  Hiroshi Tsuji,et al.  Work function measurement of transition metal nitride and carbide thin films , 2006 .

[18]  Hadis Morkoç,et al.  Ti/Al/Ni/Au Ohmic contacts for AlInN/AlN/GaN-based heterojunction field-effect transistors , 2010 .

[19]  G. Van Tendeloo,et al.  The role of Al on Ohmic contact formation on n-type GaN and AlGaN∕GaN , 2005 .

[20]  K. Sasaki,et al.  Influence of Sputtering Parameters on the Formation Process of High-Quality and Low-Resistivity HfN Thin Film , 1999 .

[21]  Umesh K. Mishra,et al.  GaN-Based RF Power Devices and Amplifiers , 2008, Proceedings of the IEEE.

[22]  B. Lu,et al.  Schottky-Drain Technology for AlGaN/GaN High-Electron Mobility Transistors , 2010, IEEE Electron Device Letters.

[23]  A. Mah,et al.  Heats of Formation of Niobium Nitride, Tantalum Nitride and Zirconium Nitride from Combustion Calorimetry , 1956 .

[24]  Low resistance Mo/Al/Mo/Au ohmic contact scheme to InAlN/AlN/GaN heterostructure , 2011 .

[25]  Russell D. Dupuis,et al.  Carrier transport mechanism of low resistance Ti/Al/Au ohmic contacts to AlInN/GaN heterostructures , 2013 .

[26]  Baoshun Zhang,et al.  Analysis of surface roughness in Ti/Al/Ni/Au Ohmic contact to AlGaN/GaN high electron mobility transistors , 2010 .

[27]  D. N. Bose,et al.  Laser annealing of phosphorus-implanted CdTe , 1990 .

[28]  Jan Kuzmik,et al.  InAlN/(In)GaN high electron mobility transistors: some aspects of the quantum well heterostructure proposal , 2002 .

[29]  Haifeng Sun,et al.  Fully Passivated AlInN/GaN HEMTs With $f_{\rm T}/f_{\rm MAX}$ of 205/220 GHz , 2011, IEEE Electron Device Letters.