Performance evaluation of photovoltaic thermal greenhouse dryer and development of characteristic curve

In the present communication, a newly designed single slope photovoltaic thermal (PVT) roof type greenhouse dryer was studied. The numbers of fans have been optimized for the drying purpose in force mode. In order to optimize the number of fans for PVT roof type greenhouse dryer, experiments have been performed with varying the number of fans in operation. The thermal modeling and experimental validation for the PVT greenhouse dryer has been carried out. The energy matrices have been estimated for the present system and the characteristic curves for thermal energy and exergy have been developed. The optimum number of fan with rated capacity was found to be three in number. However, this condition is not feasible with load condition; therefore, experiments were carried out with single fan in operation. There is a good agreement between the modelled values and experimental results. The energy payback time on overall thermal energy basis for load condition is found to be 3.74 years, whereas it is 12.40 years...

[1]  Seyfi Şevik,et al.  Experimental investigation of a new design solar-heat pump dryer under the different climatic conditions and drying behavior of selected products , 2014 .

[2]  W. Mühlbauer,et al.  Solar drying - an effective means of food preservation , 1998 .

[3]  Rajka Budin,et al.  Application of solar energy in drying processes , 1994 .

[4]  Sujata Nayak,et al.  Theoretical performance assessment of an integrated photovoltaic and earth air heat exchanger greenhouse using energy and exergy analysis methods , 2009 .

[5]  Turhan Koyuncu.  An Investigation on the performance Improvement of greenhouse-type agricultural dryers , 2006 .

[6]  José Pérez-Alonso,et al.  Performance analysis and neural modelling of a greenhouse integrated photovoltaic system , 2012 .

[7]  Alan S. Fung,et al.  Solar systems and their integration with heat pumps: A review , 2015 .

[8]  Dilip Jain,et al.  Effect of greenhouse on crop drying under natural and forced convection I: Evaluation of convective mass transfer coefficient , 2004 .

[9]  Bin-Juine Huang,et al.  PERFORMANCE EVALUATION OF SOLAR PHOTOVOLTAIC / THERMAL SYSTEMS , 2001 .

[10]  Ram Chandra,et al.  Solar drying systems and their testing procedures: A review , 1994 .

[11]  O. V. Ekechukwu,et al.  Experimental studies of integral-type natural-circulation solar-energy tropical crop dryers , 1997 .

[12]  Saad Mekhilef,et al.  The application of solar technologies for sustainable development of agricultural sector , 2013 .

[13]  Marcus Nagle,et al.  Experimental and simulated performance of a PV-ventilated solar greenhouse dryer for drying of peeled longan and banana , 2009 .

[14]  Y. Soysal,et al.  Crop drying programme in Turkey , 1999 .

[15]  Alfred Posch,et al.  Photovoltaics in agriculture: A case study on decision making of farmers , 2013 .

[16]  S. Chou,et al.  Low-cost drying methods for developing countries , 2003 .

[17]  Jan Pieters,et al.  Modelling the thermal performance of a naturally ventilated greenhouse in Zimbabwe using a dynamic greenhouse climate model , 2013 .

[18]  Om Prakash,et al.  Solar greenhouse drying: A review , 2014 .

[19]  G. N. Tiwari,et al.  Evaluation of convective mass transfer coefficient during drying of jaggery , 2004 .

[20]  P. Barnwal,et al.  Grape drying by using hybrid photovoltaic-thermal (PV/T) greenhouse dryer: An experimental study , 2008 .

[21]  M. S. Sodha,et al.  An analytical and experimental study of open sun drying and a cabinet tyre drier , 1985 .

[22]  V. K. Sharma,et al.  Performance evaluation of solar assisted dryers for low temperature drying application—II. Experimental results , 1993 .

[23]  S. Iniyan,et al.  A review of solar drying technologies , 2012 .

[24]  W. Mühlbauer,et al.  Present status of solar crop drying , 1986 .

[25]  Kamaruzzaman Sopian,et al.  Review of solar dryers for agricultural and marine products , 2010 .

[26]  Sanjay Agrawal,et al.  Energy and exergy analysis of hybrid micro-channel photovoltaic thermal module , 2011 .

[27]  Saad Mekhilef,et al.  Performance study of different solar dryers: A review , 2014 .

[28]  S. Janjai,et al.  A large-scale solar greenhouse dryer using polycarbonate cover: Modeling and testing in a tropical environment of Lao People’s Democratic Republic , 2011 .

[29]  D. L. Evans,et al.  Simplified method for predicting photovoltaic array output , 1980 .

[30]  Seyfi Şevik,et al.  Design, experimental investigation and analysis of a solar drying system ☆ , 2013 .

[31]  Antonio Mulet,et al.  ANALYSIS OF OPEN SUN DRYING EXPERIMENTS , 1993 .

[32]  Luigi Ledda,et al.  Solar radiation distribution inside a greenhouse with south-oriented photovoltaic roofs and effects on crop productivity , 2014 .

[33]  B. K. Bala,et al.  Thin layer solar drying of rough rice , 1989 .

[34]  Joachim Müller,et al.  DEVELOPMENT OF A MULTI-PURPOSE SOLAR CROP DRYER FOR ARID ZONES , 1987 .

[35]  R. Slama,et al.  Study of orange peels dryings kinetics and development of a solar dryer by forced convection , 2011 .