Experimental investigation of the impaction of water droplets on cylindrical objects

Abstract The impaction of water droplets on isothermal cylindrical wires has been investigated experimentally in the present study. Mono-size droplets of 110, 350 and 680 μm in diameter were generated using piezoelectric droplet generators. The effects of droplet velocity and wire size were varied parametrically to reveal the impacting phenomena. Typical modes of the impaction outcome are disintegration and dripping. For droplets impacting on small wires, finer drops are disintegrated if the impacting droplet velocity is high, and larger dripping drops are observed if the velocity is low. For droplets impacting on large wires, bigger pendent drops are gradually formed which would eventually detach from the wires under the influence of gravity. In addition, droplets impacting on wires with waxy surface generate smaller dripping drops than that of the non-waxed wires. A non-dimensional regime map and new formulations in terms of the droplet Weber number, the wire Bond number and the size ratio of the wire diameter to incoming droplet diameter have been established to identify the regime for each mode of outcome and to predict the size of the dripping drops within the experimental limits.

[1]  Shi-Chune Yao,et al.  The dynamics and leidenfrost temperature of drops impacting on a hot surface at small angles , 1988 .

[2]  Dimos Poulikakos,et al.  Wetting effects on the spreading of a liquid droplet colliding with a flat surface: Experiment and modeling , 1995 .

[3]  M. Rein.  Phenomena of liquid drop impact on solid and liquid surfaces , 1993 .

[4]  J. Spillman.  Spray impaction, retention and adhesion: An introduction to basic characteristics , 1982 .

[5]  C. Avedisian,et al.  On the collision of a droplet with a solid surface , 1991, Proceedings of the Royal Society of London. Series A: Mathematical and Physical Sciences.

[6]  John E. Field,et al.  High‐speed photography of surface geometry effects in liquid/solid impact , 1988 .

[7]  Dimos Poulikakos,et al.  Heat transfer and fluid dynamics during the collision of a liquid droplet on a substrate—II. Experiments , 1996 .

[8]  Ruben D. Cohen.  Shattering of a liquid drop due to impact , 1991, Proceedings of the Royal Society of London. Series A: Mathematical and Physical Sciences.

[9]  D. L. Reichard,et al.  A System for Photographically Studying Droplet Impaction on Leaf Surfaces , 1986 .

[10]  Franklin R. Hall,et al.  Reflection of agricultural sprays from leaf surfaces , 1991 .

[11]  M. B. Lesser,et al.  Analytic solution of liquid-drop impact problems , 1981, Proceedings of the Royal Society of London. A. Mathematical and Physical Sciences.

[12]  E. Hislop.  Electrostatic Ground-Rig Spraying: An Overview , 1988, Weed Technology.

[13]  P. Hobbs,et al.  Splashing of water drops on solid and wetted surfaces: hydrodynamics and charge separation , 1971, Philosophical Transactions of the Royal Society of London. Series A, Mathematical and Physical Sciences.

[14]  Roger H. Rangel,et al.  Modeling of molten droplet impingement on a non-flat surface , 1995 .

[15]  Francis H. Harlow,et al.  The Splash of a Liquid Drop , 1967 .

[16]  A. Cazabat,et al.  How does a droplet spread , 1987 .