Dynamic Model for UASB Reactor Including Reactor Hydraulics, Reaction, and Diffusion

A dynamic model has been developed to describe upflow anaerobic sludge blanket (UASB) reactors from several aspects including reactor hydraulics, biological reaction kinetics, and mass transfer within anaerobic granules. A flow model of a nonideal continuously stirred tank reactor (CSTR) followed by a dispersion plug flow reactor (PFR) was used to simulate the reactor hydraulics as observed from a LiCl tracer study. The dynamic model based on this flow model was then evaluated by a set of acetate impulse data and verified with a data set from a two-step acetate feed increase experiment from a bench-scale UASB reactor. The model describes UASB reactor performance well. Simulation results indicate significant effects of reactor nonideal flow, diffusional resistance, as well as degradation kinetics on overall substrate utilization rate. Sensitivity analyses on model parameters Ks, km, KL, D, R, and nonideal flow factors revealed granule size has a strong impact on the reactor performance. The effect of KL is...

[1]  N. Kossen,et al.  An integral dynamic model for the UASB reactor , 1986, Biotechnology and bioengineering.

[2]  Wen K. Shieh,et al.  Mathematical model for the fluidized bed biofilm reactor , 1982 .

[3]  F. Mosey.  Mathematical Modelling of the Anaerobic Digestion Process: Regulatory Mechanisms for the Formation of Short-Chain Volatile Acids from Glucose , 1983 .

[4]  W. Verstraete,et al.  Heterogeneous Distribution of Microbial Activity in Methanogenic Aggregates: pH and Glucose Microprofiles , 1993, Applied and environmental microbiology.

[5]  R. Speece.  A survey of municipal anaerobic sludge digesters and diagnostic activity assays , 1988 .

[6]  John F. Andrews,et al.  A mathematical model for the continuous culture of microorganisms utilizing inhibitory substrates , 1968 .

[7]  G. Andrews,et al.  Fluidized-bed bioreactors , 1988 .

[8]  C. Bennett,et al.  Momentum, Heat, and Mass Transfer , 1962 .

[9]  Robert L. Street,et al.  Numerical Simulation of Mixed-Culture Biofilm , 1984 .

[10]  E J Lamotta,et al.  Internal diffusion and reaction in biological films. , 1976, Environmental science & technology.

[11]  P. Mccarty,et al.  Model of steady-state-biofilm kinetics. , 1980, Biotechnology and bioengineering.

[12]  B. Rittman,et al.  The effect of shear stress on biofilm loss rate. , 1982, Biotechnology and bioengineering.

[13]  C. Criddle,et al.  Mass transfer and temperature effects on substrate utilization in brewery granules , 1995, Biotechnology and bioengineering.

[14]  L Benefield,et al.  A model for the activated sludge process which considers wastewater characteristics, floc behavior, and microbial population , 1984, Biotechnology and bioengineering.

[15]  Dirk de Beer,et al.  The effect of pH profiles in methanogenic aggregates on the kinetics of acetate conversion , 1992 .

[16]  D. T. Hill,et al.  A comprehensive dynamic model of attached growth anaerobic fermenters , 1993 .

[17]  A. Rozzi,et al.  Development of a four population model of the anaerobic degradation of carbohydrates , 1985 .

[18]  J. Steyer,et al.  Comprehensive modeling of methanogenic biofilms in fluidized bed systems: Mass transfer limitations and multisubstrate aspects , 1995, Biotechnology and bioengineering.

[19]  D. T. Hill,et al.  A dynamic model for simulation of animal waste digestion , 1977 .