Evaluation of Infrared Radiation Combined with Hot Air Convection for Energy-Efficient Drying of Biomass

Cost-effective biomass drying is a key challenge for energy recovery from biomass by direct combustion, gasification, and pyrolysis. The aim of the present study was to optimize the process of biomass drying using hot air convection (HA), infrared (IR), and combined drying systems (IR-HA). The specific energy consumption (SEC) decreased significantly by increasing the drying temperature using convective drying, but higher air velocities increased the SEC. Similarly, increasing air velocity in the infrared dryer resulted in a significant increase in SEC. The lowest SEC was recorded at 7.8 MJ/kg at an air velocity of 0.5 m/s and an IR intensity of 0.30 W/cm2, while a maximum SEC (20.7 MJ/kg) was observed at 1.0 m/s and 0.15 W/cm2. However, a significant reduction in the SEC was noticed in the combined drying system. A minimum SEC of 3.8 MJ/kg was recorded using the combined infrared-hot air convection (IR-HA) drying system, which was 91.7% and 51.7% lower than convective and IR dryers, respectively. The present study suggested a combination of IR and hot air convection at 60 °C, 0.3 W/cm2 and 0.5 m/s as optimum conditions for efficient drying of biomass with a high water content.

[1]  A. Werker,et al.  Polyhydroxyalkanoate (PHA) Bioplastics from Organic Waste , 2019, Biorefinery.

[2]  G. Mwithiga,et al.  Comparison of a gas fired hot-air dryer with an electrically heated hot-air dryer in terms of drying process, energy consumption and quality of dried onion slices , 2012 .

[3]  O. Fasina,et al.  Effect of infrared heating on the properties of legume seeds , 2001 .

[4]  W. Jin,et al.  Enhancement of Lipid Production of Chlorella Pyrenoidosa Cultivated in Municipal Wastewater by Magnetic Treatment , 2016, Applied Biochemistry and Biotechnology.

[5]  A. E. Abomohra,et al.  Biorefining of rice straw by sequential fermentation and anaerobic digestion for bioethanol and/or biomethane production: Comparison of structural properties and energy output. , 2018, Bioresource technology.

[6]  M. El-sheekh,et al.  Screening of different species of Scenedesmus isolated from Egyptian freshwater habitats for biodiesel production , 2018, Renewable Energy.

[7]  Junmeng Cai,et al.  Determination of Drying Kinetics for Biomass by Thermogravimetric Analysis under Nonisothermal Condition , 2008 .

[8]  C. Contreras,et al.  Influence of microwave application on convective drying: Effects on drying kinetics, and optical and mechanical properties of apple and strawberry , 2008 .

[9]  Ebru Kavak Akpinar,et al.  Energy and exergy analyses of drying of red pepper slices in a convective type dryer , 2004 .

[10]  A. Mujumdar,et al.  Studies on different combined microwave drying of carrot pieces , 2010 .

[11]  A. Haridas,et al.  Biodrying process: A sustainable technology for treatment of municipal solid waste with high moisture content. , 2016, Waste management.

[12]  Q. Wang,et al.  Co-pyrolysis and co-hydrothermal liquefaction of seaweeds and rice husk: Comparative study towards enhanced biofuel production , 2017 .

[13]  Yanhong Liu,et al.  Process-Based Drying Temperature and Humidity Integration Control Enhances Drying Kinetics of Apricot Halves , 2015 .

[14]  Byong-Hun Jeon,et al.  Biological Conversion of Amino Acids to Higher Alcohols. , 2019, Trends in biotechnology.

[15]  Haiping Yang,et al.  The Influence of Microwave Drying on Biomass Pyrolysis , 2008 .

[16]  B. B. Uzoejinwa,et al.  Co-pyrolysis of biomass and waste plastics as a thermochemical conversion technology for high-grade biofuel production: Recent progress and future directions elsewhere worldwide , 2018 .

[17]  Qian Wang,et al.  Microalgae harvest influences the energy recovery: A case study on chemical flocculation of Scenedesmus obliquus for biodiesel and crude bio-oil production. , 2019, Bioresource technology.

[18]  N. S. Rathore,et al.  Experimental studies on hemi cylindrical walk-in type solar tunnel dryer for grape drying , 2009 .

[19]  Aimin Li,et al.  Thermally assisted bio-drying of food waste: Synergistic enhancement and energetic evaluation. , 2018, Waste management.

[20]  Mayur B. Kurade,et al.  Improvement of acidogenic fermentation using an acclimatized microbiome , 2018, International Journal of Hydrogen Energy.

[21]  José Roberto Moreira,et al.  Global Biomass Energy Potential , 2006 .

[22]  B. B. Uzoejinwa,et al.  Characterization and pyrolysis behavior of the green microalga Micractinium conductrix grown in lab-scale tubular photobioreactor using Py-GC/MS and TGA/MS , 2018, Journal of Analytical and Applied Pyrolysis.

[23]  A. Mujumdar,et al.  Recent developments in high-quality drying of vegetables, fruits, and aquatic products , 2017, Critical reviews in food science and nutrition.

[24]  F. López-Rodríguez,et al.  Mathematical modelling of thin-layer infrared drying of wet olive husk , 2008 .

[25]  C. E. Silva,et al.  Bioethanol from microalgae and cyanobacteria: A review and technological outlook , 2016 .

[26]  Mahdy Elsayed,et al.  Acetogenesis and methanogenesis liquid digestates for pretreatment of rice straw: A holistic approach for efficient biomethane production and nutrient recycling , 2019, Energy Conversion and Management.

[27]  M. El-sheekh,et al.  Enhancement of lipid extraction for improved biodiesel recovery from the biodiesel promising microalga Scenedesmus obliquus , 2016 .

[28]  Yong Sik Ok,et al.  Production of bioplastic through food waste valorization. , 2019, Environment international.

[29]  R. C. Verma,et al.  Thin-layer infrared radiation drying of onion slices , 2005 .

[30]  Soon Woong Chang,et al.  Perspective on anaerobic digestion for biomethanation in cold environments , 2019, Renewable and Sustainable Energy Reviews.

[31]  Mayur B. Kurade,et al.  Whole conversion of microalgal biomass into biofuels through successive high-throughput fermentation , 2019, Chemical Engineering Journal.

[32]  J. Hallett,et al.  The multi-scale challenges of biomass fast pyrolysis and bio-oil upgrading: Review of the state of art and future research directions , 2019, Progress in Energy and Combustion Science.

[33]  Z. Pan,et al.  Moisture diffusivity of rough rice under infrared radiation drying , 2011 .

[34]  Satish Bal,et al.  Drying kinetics of high moisture paddy undergoing vibration-assisted infrared (IR) drying , 2009 .

[35]  Gauhar Mahmood,et al.  Municipal solid waste management in Indian cities - A review. , 2008, Waste management.

[36]  M. Zhanga,et al.  Trends in microwave-related drying of fruits and vegetables , 2022 .

[37]  Li Xing,et al.  Renewable energy from agro-residues in China: Solid biofuels and biomass briquetting technology , 2009 .

[38]  Yunhong Liu,et al.  A Mathematical Model for Vacuum Far-Infrared Drying of Potato Slices , 2014 .

[39]  Magnus Ståhl,et al.  Industrial processes for biomass drying and their effects on the quality properties of wood pellets , 2004 .

[40]  Daniel I. Onwude,et al.  The effectiveness of combined infrared and hot-air drying strategies for sweet potato , 2019, Journal of Food Engineering.

[41]  G. Mwithiga,et al.  Performance of a convective, infrared and combined infrared- convective heated conveyor-belt dryer , 2015, Journal of Food Science and Technology.

[42]  Ashwani Kumar,et al.  Renewable energy in India: Current status and future potentials , 2010 .

[43]  A. Ganguly,et al.  Process kinetic studies of biohydrogen production by co-fermentation of fruit-vegetable wastes and cottage cheese whey , 2018, Energy for Sustainable Development.

[44]  Ali Akbar Sabziparvar,et al.  Modeling moisture diffusivity, activation energy and specific energy consumption of squash seeds in a semi fluidized and fluidized bed drying , 2011, Journal of Food Science and Technology.

[45]  Zhongli Pan,et al.  Heat and Mass Transfer Modeling of Apple Slices Under Simultaneous Infrared Dry Blanching and Dehydration Process , 2009 .

[46]  A. Motevali,et al.  Investigation of some pretreatments on energy and specific energy consumption drying of black mulberry , 2013 .

[47]  J. L. Ramos-Suárez,et al.  Optimization of the digestion process of Scenedesmus sp. and Opuntia maxima for biogas production , 2014 .

[48]  Guangnan Chen,et al.  Recent advances of novel thermal combined hot air drying of agricultural crops , 2016 .

[49]  Suresh Prasad,et al.  Specific energy consumption in microwave drying of garlic cloves , 2006 .

[50]  P. Pathare,et al.  Recent advances in sustainable drying of agricultural produce: A review , 2019, Applied Energy.

[51]  S. Chou,et al.  Low-cost drying methods for developing countries , 2003 .

[52]  T. Kiatsiriroat,et al.  Heat and mass transfer in combined convective and far-infrared drying of fruit leather , 2010 .

[53]  Zhi-xia He,et al.  Co-pyrolysis and catalytic co-pyrolysis of Enteromorpha clathrata and rice husk , 2019, Journal of Thermal Analysis and Calorimetry.

[54]  S. Mongpraneet,et al.  Accelerated drying of welsh onion by far infrared radiation under vacuum conditions , 2002 .

[55]  I. Doymaz,et al.  Air-drying characteristics of tomatoes , 2007 .

[56]  Panna Lal Singh.  Silk cocoon drying in forced convection type solar dryer , 2011 .

[57]  Sebastian L Riedel,et al.  The Potential of Polyhydroxyalkanoate Production from Food Wastes , 2019 .

[58]  H. Mark Hanna,et al.  Farm Energy: Energy considerations for low-temperature grain drying , 2012 .

[59]  S. Minaei,et al.  Effective Moisture Diffusivity, Activation Energy and Energy Consumption in Thin-layer Drying of Jujube (Zizyphus jujube Mill) , 2012 .

[60]  Jan-Olof Anderson,et al.  Improved energy efficiency in sawmill drying system , 2014 .

[61]  Seyed Hashem Samadi,et al.  EVALUATION OF ENERGY ASPECTS OF APPLE DRYING IN THE HOT-AIR AND INFRARED DRYERS , 2013 .