An experimental study on defrosting performance of an air source heat pump unit with a multi-circuit outdoor coil at different frosting evenness values

Abstract For an air source heat pump (ASHP) unit with a vertically installed multi-circuit outdoor coil, it is rarely possible to make the frost accumulations on each circuit's surface equal, leading to different frosting evenness values (FEVs) as a reverse cycle defrosting operation starts. On the other hand, uneven defrosting phenomenon was found and reported as many methods were developed to improve defrosting performance of ASHP systems, which may be attributable to the reverse cycle defrosting starting at an uneven frosting. Understanding of defrosting performance of an ASHP unit with a multi-circuit outdoor coil at different FEVs is of importance for ASHP units' application, but studies are scarce in the open literatures. In this paper, we report an experimental study on defrosting performance when frost accumulated on the surface of outdoor coil at different FEVs. This paper presents details of an experimental ASHP unit and the experimental conditions, followed by results, and conclusions. Finally, an increase of 6.8% in defrosting efficiency was confirmed when the FEV changed from 82.6% to 96.6%.

[1]  Wang Zhiyi,et al.  Defrost improvement by heat pump refrigerant charge compensating , 2008 .

[2]  J. J. Lux,et al.  Energy considerations in hot-gas defrosting of industrial refrigeration coils , 1983 .

[3]  Dong Huang,et al.  Comparison between hot-gas bypass defrosting and reverse-cycle defrosting methods on an air-to-water heat pump , 2009 .

[4]  Shiming Deng,et al.  A study on the performance of the airside heat exchanger under frosting in an air source heat pump water heater/chiller unit , 2004 .

[5]  Wenjin Wang,et al.  Performances of air source heat pump system for a kind of mal-defrost phenomenon appearing in moderate climate conditions , 2013 .

[6]  Nilufer Egrican,et al.  Frost formation on fin-and-tube heat exchangers. Part I—Modeling of frost formation on fin-and-tube heat exchangers , 2004 .

[7]  Shiming Deng,et al.  Improved indoor thermal comfort during defrost with a novel reverse-cycle defrosting method for air source heat pumps , 2010 .

[8]  Zhang Lin,et al.  Performance investigation of a novel frost-free air-source heat pump water heater combined with energy storage and dehumidification , 2015 .

[9]  Pradeep Bansal,et al.  Thermal analysis of the defrost cycle in a domestic freezer. , 2010 .

[10]  Shiming Deng,et al.  A modeling study on alleviating uneven defrosting for a vertical three-circuit outdoor coil in an air source heat pump unit during reverse cycle defrosting , 2016 .

[11]  Dong Huang,et al.  Effect of fin types of outdoor fan-supplied finned-tube heat exchanger on periodic frosting and defrosting performance of a residential air-source heat pump , 2014 .

[12]  Han Xing,et al.  Frosting characteristics of fin-tube heat exchanger at temperature range of −18 to 6 °C of a cascade heat pump , 2014 .

[13]  Zhao Li,et al.  An experimental study on the uneven refrigerant distribution over a vertically installed multi-circuit outdoor coil in an air source heat pump unit during reverse cycle defrosting , 2015 .

[14]  Dongmei Pan,et al.  An experimental study on the effects of downwards flowing of melted frost over a vertical multi-circuit outdoor coil in an air source heat pump on defrosting performance during reverse cycle defrosting , 2014 .

[15]  Ning Li,et al.  An experimental study on the negative effects of downwards flow of the melted frost over a multi-circuit outdoor coil in an air source heat pump during reverse cycle defrosting , 2015 .

[16]  Dennis L. O'Neal,et al.  Frosting performance of tube fin heat exchangers with wavy and corrugated fins , 1991 .

[17]  Xian-min Guo,et al.  Experimental study on frost growth and dynamic performance of air source heat pump system , 2008 .

[18]  Ju-Suk Byun,et al.  Frost retardation of an air-source heat pump by the hot gas bypass method , 2008 .

[19]  Jaehong Kim,et al.  A combined Dual Hot-Gas Bypass Defrosting method with accumulator heater for an air-to-air heat pump in cold region , 2015 .

[20]  Wenjin Wang,et al.  Investigation of defrosting water retention on the surface of evaporator impacting the performance of air source heat pump during periodic frosting–defrosting cycles , 2014 .

[21]  Minglu Qu,et al.  A study of the reverse cycle defrosting performance on a multi-circuit outdoor coil unit in an air source heat pump – Part I: Experiments , 2012 .

[22]  Feng Cao,et al.  Experimental analysis of an air-source transcritical CO2 heat pump water heater using the hot gas bypass defrosting method , 2014 .

[23]  René Rieberer,et al.  Parametric analysis of the defrosting process of a reversible heat pump system for electric vehicles , 2013 .

[24]  Ali Hakkaki-Fard,et al.  Applying refrigerant mixtures with thermal glide in cold climate air-source heat pumps , 2014 .

[25]  Zhang Na,et al.  Experimental research on a novel cold storage defrost method based on air bypass circulation and electric heater , 2012 .

[26]  D. O’Neal,et al.  Frost/defrost performance of a three-row fin staged heat pump evaporator. , 2002 .

[27]  Liang Xia,et al.  A semi-empirical modeling study on the defrosting performance for an air source heat pump unit with local drainage of melted frost from its three-circuit outdoor coil , 2014 .

[28]  S. A. Sherif,et al.  Hot water defrosting of a horizontal flat plate cooling surface , 1983 .

[29]  Fernando Testoni Knabben,et al.  An experimental study on defrost heaters applied to frost-free household refrigerators , 2013 .

[30]  J.E.R. Coney,et al.  Experimental study of warm-air defrosting of heat-pump evaporators , 1993 .