Effect of Compressed Natural Gas Mixing on the Engine Performance and Emissions

Cleaner air quality is becoming a global concern, thus to improve the fuel and combustion process is vital. In this paper, computational fluid dynamics (CFD) analysis software CFD-ACE is used to investigate the flow behavior of methane and air in a compressed natural gas (CNG)–air mixer to be implemented in a CNG–diesel dual-fuel stationary engine. The effect of the number of mixer holes on the mixture quality was evaluated. The results of the 3D CFD simulation showed that the 8-hole Venturi mixer gave superior performance compared to the 4-hole mixer. Further analysis was carried out on the 8-hole Venturi mixer to investigate the effect of engine speed on the mass flow rate of CNG and the equivalence air to fuel ratio (1/). The second half of the paper presents comparative performance results between a single cylinder research compression ignition (CI) engine fueled with a CNG–diesel system and a conventional CI engine fueled by conventional diesel. The engine was equipped with the simulated 8-hole Venturi mixer. The result showed a significant reduction in exhaust gas emission components (NOx, CO and CO2) from the CNG–diesel engine compared to the conventional diesel engine, i.e. the reduction rates were on average of 54%, 59% and 31% respectively. The average power output developed by the dual-fuel engine was 10% higher than the diesel over the power curve.

[1]  Bassam B. Dally,et al.  Flow and mixing fields of turbulent bluff-body jets and flames , 1998 .

[2]  B Yan Xu,et al.  Visualization of natural gas-air mixing flow in the mixer of a CNG vehicle , 1997 .

[3]  Ahmad Faris Ismail,et al.  Design Modification of High Speed Diesel Engine to Accommodate Compressed Natural Gas , 2007 .

[4]  S. Sidhu,et al.  Semi-volatile and particulate emissions from the combustion of alternative diesel fuels. , 2001, Chemosphere.

[5]  S. Sendilvelan,et al.  Effect of Oxygenated Hydrocarbon Additives on Exhaust Emission of a Diesel Engine , 2010 .

[6]  Andrew P. Wandel,et al.  The Modelling of The Effect of Air Fuel Ratio on Unburned Hydrocarbons for MILD Combustion , 2012 .

[7]  Debi Prasad Mishra.  Experimental studies of flame stability limits of CNG-air premixed flame , 2007 .

[8]  N. Fricker,et al.  NATURAL GAS VEHICLES , 1995 .

[9]  Zhen-tao Liu,et al.  Study of CNG/diesel dual fuel engine's emissions by means of RBF neural network. , 2004, Journal of Zhejiang University. Science.

[10]  Andrew P. Wandel,et al.  A REVIEW OF MILD COMBUSTION AND OPEN FURNACE DESIGN CONSIDERATION , 2012 .

[11]  D. Fletcher,et al.  A CFD based combustion model of an entrained flow biomass gasifier , 2000 .

[12]  N. Kahraman,et al.  Internal combustion engines fueled by natural gas—hydrogen mixtures , 2004 .

[13]  Antonio Paolo Carlucci,et al.  Experimental investigation and combustion analysis of a direct injection dual-fuel diesel–natural gas engine , 2008 .

[14]  B. Launder,et al.  Application of the energy-dissipation model of turbulence to the calculation of flow near a spinning disc , 1974 .

[15]  B. Holmén,et al.  Ultrafine PM emissions from natural gas, oxidation-catalyst diesel, and particle-trap diesel heavy-duty transit buses. , 2002, Environmental science & technology.

[16]  Wanhua Su,et al.  A study on the amount of pilot injection and its effects on rich and lean boundaries of the premixed CNG/air mixture for a CNG/diesel dual-fuel engine , 2003 .

[17]  M.T. Al-Atabi,et al.  Experimental investigation of a single cylinder diesel engine as a hybrid power unit for a series hybrid electric vehicle , 2002, Student Conference on Research and Development.

[18]  B. Ghobadian,et al.  A Semi-Empirical Model to Predict Diesel Engine Combustion Parameters , 2013 .

[19]  B. F. Yousif,et al.  CNG-diesel engine performance and exhaust emission analysis with the aid of artificial neural network , 2010 .

[20]  M. RahmanM.,et al.  Performance Evaluation of External Mixture Formation Strategy in Hydrogen-Fueled Engine , 2011 .

[21]  G. Nagarajan,et al.  Experimental Investigation On Cold Start Emissions Using Electrically Heated Catalyst In A Spark Ignition Engine , 2010 .

[22]  Dong Soo Jeong,et al.  Development of a Mechanical CNG-Diesel Dual Fuel Supply System , 1993 .

[23]  Muthu Kumara Samy Sekaran,et al.  Emission and combustion characteristics of different fuel in a HCCI engine , 2011, Proceedings of 2011 International Conference on Electronic & Mechanical Engineering and Information Technology.

[24]  Guo-xiu Li,et al.  Nonlinear dynamics of cycle-to-cycle combustion variations in a lean-burn natural gas engine , 2008 .

[25]  Y. Kajii,et al.  Influence of extensive compressed natural gas (CNG) usage on air quality , 2012 .

[26]  S. Sendilvelan,et al.  EMISSION AND COMBUSTION CHARACTERISTICS OF DIFFERENT FUELS IN A HCCI ENGINE , 2011 .

[27]  W. Jones,et al.  The prediction of laminarization with a two-equation model of turbulence , 1972 .

[28]  Abul Kalam Azad,et al.  A Comprehensive Study of Di Diesel Engine PerformanceWithvegetable Oil: An Alternative Bio-Fuel Source ofEnergy , 2012 .

[29]  N. Kapilan,et al.  Improvement of Performance of Dual Fuel Engine Operated at Part Load , 2010 .

[30]  John B. Heywood,et al.  Internal combustion engine fundamentals , 1988 .

[31]  Mohamed Y. E. Selim,et al.  Sensitivity of dual fuel engine combustion and knocking limits to gaseous fuel composition , 2004 .

[32]  K. Kalyani Radha,et al.  PERFORMANCE AND EMISSION CHARACTERISTICS OF A CI ENGINE OPERATED ON VEGETABLE OILS AS ALTERNATIVE FUELS , 2011 .

[33]  R. Mamat,et al.  Influence of Fuel Temperature on a Diesel Engine Performance Operating with Biodiesel Blended , 2012 .

[34]  Liu Zhen-tao,et al.  Study of CNG/diesel dual fuel engine's emissions by means of RBF neural network , 2004 .

[35]  Jean-Michel Most,et al.  Assessment of ignition hazard in turbulent flammable gas mixers combining a Lagrangian approach and large eddy simulation , 2006 .

[36]  Xianming Li,et al.  Computational Fluid Dynamics in Industrial Combustion , 2001 .

[37]  Hong Guang Zhang,et al.  Study on the effect of engine operation parameters on cyclic combustion variations and correlation coefficient between the pressure-related parameters of a CNG engine , 2013 .

[38]  M. Kamal,et al.  Minimum Quantity Lubricant Flow Analysis In End Milling Processes: A Computational Fluid Dynamics Approach , 2012 .

[39]  Andrew P. Wandel,et al.  Implementation of Multiple Mapping Conditioning for Single Conserved Scalar , 2003 .

[40]  M. RahmanM.,et al.  Investigation of Flow Behavior in Minimum Quantity Lubrication Nozzle for End Milling Processes , 2012 .

[41]  T. Yoshikawa,et al.  Enhancement of acute lung injury related to bacterial endotoxin by components of diesel exhaust particles , 2003, Thorax.

[42]  A. Rashid A. Aziz,et al.  Combustion Analysis of a CNG Direct Injection Spark Ignition Engine , 2010 .

[43]  Frances Silverman,et al.  Fine particulate air pollution and ozone inhalation causes acute arterial vasoconstriction in healthy adults , 2002 .

[44]  Mohd Hafizil Mat Yasin,et al.  INFLUENCE OF PALM METHYL ESTER (PME) AS AN ALTERNATIVE FUEL IN MULTICYLINDER DIESEL ENGINE , 2012 .

[45]  R. Cataluña,et al.  Evaluation of the maximum horsepower of vehicles converted for use with natural gas fuel , 2006 .