Charging mechanism of electret film made of potassium-ion-doped SiO2

A charging model is proposed for an electret film made of potassium-ion-doped SiO2 that can be formed between the two opposing micro-electrodes of a micro-electrostatic actuator, separated by a microscopic gap. On the basis of experimental evidence that charging only occurs in the positively biased electrode during the charging process and that the charging polarity is negative, we assumed that the cause of the electret charges is negatively charged oxygen ions residing in the SiO2 film, which arise as a consequence of potassium ion depletion. This assumption was supported by SIMS (Secondary Ion Mass Spectroscopy) analyses that indicate the presence of a depletion region of potassium ions near the interface of the silicon and the oxide film on the positively biased electrode. Calculations of the charged potential using Poisson’s equation with the spatially distributed negative charges in the depletion region showed good agreement with the measured surface potential. It appears that our charging model can ...

[1]  P. Gunther,et al.  Mechanism of charge storage in electron-beam or corona-charged silicon-dioxide electrets , 1991 .

[2]  Yoshinori Iguchi,et al.  Trench-filled cellular parylene electret for piezoelectric transducer , 2012 .

[3]  Yuji Suzuki,et al.  High-speed electret charging using vacuum UV photoionization , 2011 .

[4]  H. Mimura,et al.  $In Situ$ Measurement of Charging Process in Electret-Based Comb-Drive Actuator and High-Voltage Charging , 2015, Journal of Microelectromechanical Systems.

[5]  C. Reedyk.  Electret transducers applied to the telephone , 1971 .

[6]  Wouter Olthuis,et al.  On the charge storage and decay mechanism in silicon dioxide electrets , 1992 .

[7]  Gerhard M. Sessler,et al.  Electromechanical response of cellular electret films , 1999 .

[8]  J. F. Verweij,et al.  On the mobility of potassium ions in SiO2 , 1979 .

[9]  Mototarô Eguchi,et al.  XX. On the permanent electret , 1925 .

[10]  R. Fjeld,et al.  The effect of particle charge on penetration in an electret filter , 1988 .

[12]  D. Carlson,et al.  Ion Depletion of Glass at a Blocking Anode: II, Properties of Ion‐Depleted Glasses , 1974 .

[13]  H. Fujita,et al.  SiO2 Electret Generated by Potassium Ions on a Comb-Drive Actuator , 2011 .

[14]  D. Carlson.  Ion Depletion of Glass at a Blocking Anode: I, Theory and Experimental Results for Alkali Silicate Glasses , 1974 .

[15]  C. Jean-Mistral,et al.  Advances for dielectric elastomer generators: Replacement of high voltage supply by electret , 2012 .

[16]  G. Montanari.  Electrical measurements for the characterization of electret properties of cellular polymers , 2003 .

[17]  J. A. Voorthuyzen,et al.  Research and development of miniaturized electrets , 1989 .

[18]  H. Kuwano,et al.  Improving an electret transducer by fully utilizing the implanted charge , 2008 .

[19]  Y. Suzuki,et al.  Electret charging method based on soft X-ray photoionization for MEMS transducers , 2012, IEEE Transactions on Dielectrics and Electrical Insulation.