Generation of CO and smoke during underventilated combustion

The CO and smoke yields observed for underventilated laminar diffusion flames are presented for methane and ethene for global equivalence ratio (Phi) over the range 0.5 to 4.0. A Burke-Schumann type burner with fuel in the center tube and air in the annular region was used. The peak CO yields for methane and ethene, 0.37 and 0.47, respectively, are at least a factor of 100 greater than for overventilated burning. The ratio of CO/CO[sub 2] versus [Phi] for the methane flame is compared with local measurements of this ratio for both overventilated and underventilated laminar diffusion flames and with the results for turbulent natural gas flames quenched in an upper layer. The peak smoke yields for methane at a flow rate of 10 cm[sup 3]/s and for ethene at a fuel flow rate of 6.4 cm[sup 3]/s are 0.01 and 0.05, respectively, compared with yields of 0.0 and 0.028 for the overventilated case. The proportionally between smoke yield observed for overventilated burning for a wide range of fuels is found not to be valid for the underventilated case. The chemical makeup and structure of the smoke produced at high equivalence ratio is qualitatively different from smoke produced under overventilated conditions;more » the smoke is mainly organic rather than graphitic and it has an agglutinated structure rather than an agglomerate structure with distinct primary spheres usually observed in overventilated burning.« less

[1]  Reginald E. Mitchell,et al.  Experimental and numerical investigation of confined laminar diffusion flames , 1980 .

[2]  Robert J. Santoro,et al.  Soot particle measurements in diffusion flames , 1983 .

[3]  Craig L. Beyler,et al.  Major species production by diffusion flames in a two-layer compartment fire environment , 1986 .

[4]  George Sidebotham,et al.  Flame temperature, fuel structure, and fuel concentration effects on soot formation in inverse diffusion flames , 1992 .

[5]  D. Abam.  Carbon monoxide oxidation in laminar diffusion flames , 1987 .

[6]  T. Kubota,et al.  Species production and heat release rates in two-layered natural gas fires , 1991 .

[7]  Stephen A. Wise,et al.  Polycyclic aromatic hydrocarbon emissions from the combustion of crude oil on water , 1990 .

[8]  D. Honnery,et al.  Soot Formation in Long Ethylene Diffusion Flames , 1990 .

[9]  J. Lahaye,et al.  Chemical aspects of soot particles oxidation in a laminar methane-air diffusion flame☆ , 1990 .

[10]  George Granger. Brown,et al.  Combustion Symposium: Introduction , 1928 .

[11]  Robert J. Santoro,et al.  Soot inception in a methane/air diffusion flame as characterized by detailed species profiles , 1985 .

[12]  Craig L. Beyler,et al.  Carbon Monoxide Production in Compartment Fires , 1992 .

[13]  R. B. Williamson,et al.  Smoke Emission Factors from Medium-Scale Fires: Part 2 , 1989 .

[14]  C. Smith,et al.  The prediction of laminar jet diffusion flame sizes: Part II. Experimental verification , 1977 .

[15]  Robert J. Santoro,et al.  The Transport and Growth of Soot Particles in Laminar Diffusion Flames , 1987 .

[16]  John Kent,et al.  Who do Diffusion flames Emit smoke , 1984 .

[17]  P. Hopke,et al.  Atmospheric aerosol : source/air quality relationships , 1981 .