Boiling on a Tube Bundle: Part I—Flow Visualization and Onset of Dryout

A novel visualization method was developed and implemented in a refrigerant-flooded evaporator tube bundle. Specifically, a method to visualize the two-phase flow inside plain tube bundles was developed using a dummy tube with a tubular glass section for visual access with a digital high-speed video camera and a laser light/photodiode. These were used to observe and characterize the two-phase flow structure and improve understanding of the physical phenomena taking place. In particular, a dryout line was objectively identified in a flow pattern map separating high- and low-performance heat transfer data measured locally on the bundle. The database was recorded for vertical flow of R134a and R236fa over smooth tubes at saturation temperatures of 5–15°C. The tests span low mass velocities applicable in flooded evaporators, and heat fluxes include adiabatic and diabatic tests of 7–25 kW/m2. A new prediction method for onset of dryout on smooth tube bundles is proposed.

[1]  Tadashi Sakaguchi,et al.  Studies on the Fluctuation of Pressure Drop in Two-Phase Slug Flow , 1971 .

[2]  J. Thome,et al.  Local Bundle Boiling Heat Transfer Coefficients on a Turbo-BII HP Tube Bundle (RP-1089) , 2004 .

[3]  M. Kondo,et al.  Experimental Investigation of Air-water Two Phase Upflow across Horizontal Tube Bundles : Part 1, Flow Pattern and Void Fraction , 1980 .

[4]  M. Afzaal Malik,et al.  A review of heat exchanger tube bundle vibrations in two-phase cross-flow , 2004 .

[5]  Vertical, Bubbly, Cross-Flow Characteristics over Tube Bundles , 2005 .

[6]  Dieter Mewes,et al.  VERTICAL, UPWARD GAS-LIQUID TWO-PHASE FLOW ACROSS A TUBE BUNDLE , 1994 .

[7]  J. Thome,et al.  Flow Visualization and Flow Pattern Identification With Power Spectral Density Distributions of Pressure Traces During Refrigerant Condensation in Smooth and Microfin Tubes , 2005 .

[8]  Dvora Barnea,et al.  A unified model for predicting flow-pattern transitions for the whole range of pipe inclinations , 1987 .

[9]  C. P. Tso,et al.  Hydrodynamics of two-phase flow in vertical up and down-flow across a horizontal tube bundle , 1998 .

[10]  D. Chisholm,et al.  Two-Phase Flow on the Shell-Side of a Segmentally Baffled Shell-and-Tube Heat Exchanger , 1979 .

[11]  Experimental characterization of gas–liquid intermittent subregimes by phase density function measurements , 2003 .

[12]  I. G. Currie,et al.  Vibration of Tube Bundles in Two-Phase Cross-Flow: Part 3—Turbulence-Induced Excitation , 1989 .

[13]  J. Weisman,et al.  Effects of fluid properties and pipe diameter on two-phase flow patterns in horizontal lines , 1979 .

[14]  R. P. Roy,et al.  Stochastic characteristics of vapor fraction and wall pressure fluctuations in boiling flows , 1983 .

[15]  J. Thome,et al.  Local Bundle Boiling Heat Transfer Coefficients on an Integral Finned Tube Bundle (RP-1089) , 2004 .

[16]  A.M.C. Chan,et al.  Investigation of two-phase flow regimes in tube bundles under cross-flow conditions , 1999 .

[17]  M. J. Pettigrew,et al.  Vibration of Tube Bundles in Two-Phase Cross-Flow: Part 2—Fluid-Elastic Instability , 1989 .

[18]  John R. Thome,et al.  Local Bundle Boiling Heat Transfer Coefficients on a Plain Tube Bundle (RP-1089) , 2004 .

[19]  T. Sakaguchi,et al.  Studies on the Fluctuation of pressure Drop in Two-Phase Slug Flow : 1 st Report, Experimental Study , 1971 .

[20]  Narinder K. Tutu,et al.  Pressure fluctuations and flow pattern recognition in vertical two phase gas-liquid flows , 1982 .

[21]  John R. Thome,et al.  Characterization of diabatic two-phase flows in microchannels: Flow parameter results for R-134a in a 0.5 mm channel , 2006 .

[22]  Richard T. Lahey,et al.  On the development of an objective flow regime indicator , 1982 .

[23]  J. Meyer,et al.  Probabilistic flow pattern-based heat transfer correlation for condensing intermittent flow of refrigerants in smooth horizontal tubes , 2010 .

[24]  Owen C. Jones,et al.  The interrelation between void fraction fluctuations and flow patterns in two-phase flow , 1975 .

[25]  Goichi Matsui,et al.  Identification of flow regimes in vertical gas-liquid two-phase flow using differential pressure fluctuations , 1984 .

[26]  M. J. Pettigrew,et al.  Vibration of Tube Bundles in Two-Phase Cross-Flow: Part 1—Hydrodynamic Mass and Damping , 1989 .

[27]  On the Pulsation Phenomena in Gas-Liquid Two-Phase Flow : Relationship between Pulsating Pressure and Flow Pattern in Upward Two-Phase Flow , 1969 .

[28]  John R. Thome,et al.  Two-Phase Flow and Heat Transfer across Horizontal Tube Bundles‐A Review , 2007 .

[29]  B. M. Burnside,et al.  Flow velocities in an experimental kettle reboiler determined by particle image velocimetry , 2005 .