Determination of Surface Exchange Coefficients of LSM, LSCF, YSZ, GDC Constituent Materials in Composite SOFC Cathodes

A novel approach to processing and modeling isothermal isotope exchange (IIE) data was developed to extract kinetic rate coefficients for the oxygen reduction reaction (ORR) on cathode materials used for solid oxide fuel cells (SOFC). IIE is capable of testing powders with particle sizes on the nano-scale, where the effective sample thickness (particle size) was shown to be below the characteristic thickness (L c ) for ionically conducting materials. This allows for accurate kinetic measurements in surface exchange controlled regimes, in contrast to secondary ion mass spectrometry depth profiling and electrical conductivity relaxation techniques where sample thicknesses are typically in the diffusion limited or mixed regimes. Surface exchange coefficients (k * ) were extracted and L c values calculated from cathode (La 0.6 Sr 0.4 )(Co 0.2 Fe 0.8 )O 3-δ (LSCF) and (La 0.8 Sr 0.2 )MnO 3 (LSM), and electrolyte (Ce 0.9 Gd 0.1 )O 1-δ (GDC) and (Zr 0.8 Y 0.2 )O 2 (YSZ) materials. Additionally, diffusion coefficients (D * ) were extracted for LSM. In a surface exchange controlled regime LSCF exhibits a low activation energy for k * , while for LSM k * was observed to increase with decreasing temperature consistent with a precursor-mediated mechanism in which there is a negative apparent activation energy for the dissociative chemisorption of O 2 . GDC was shown to exhibit a low activation energy for k * , lower than YSZ, which is attributed to higher concentration of electrons in GDC than YSZ.

[1]  E. Wachsman,et al.  Isotopic-switching analysis of oxygen reduction in solid oxide fuel cell cathode materials , 2010 .

[2]  B. Boukamp,et al.  A novel pulse isotopic exchange technique for rapid determination of the oxygen surface exchange rate of oxide ion conductors. , 2009, Physical chemistry chemical physics : PCCP.

[3]  E. Wachsman,et al.  Surface and bulk oxygen non-stoichiometry and bulk chemical expansion in gadolinium-doped cerium oxide , 2009 .

[4]  J. Weaver,et al.  Facile C−H Bond Cleavage and Deep Oxidation of Propane on a PdO(101) Thin Film , 2009 .

[5]  E. Wachsman,et al.  Investigating Oxygen Surface Exchange Kinetics of La0.8Sr.20MnO3-δ and La0.6Sr0.4Co0.2Fe0.8O3-δ Using an Isotopic Tracer , 2008 .

[6]  E. Wachsman,et al.  The role of point defects in the physical properties of nonstoichiometric ceria , 2007 .

[7]  J. P. Strakey,et al.  Solid oxide fuel cell technology development in the U.S. , 2006 .

[8]  E. Wachsman,et al.  Role of Point Defects in the Physical Properties of Fluorite Oxides , 2006 .

[9]  A. Virkar,et al.  Measurement of Surface Exchange Coefficient on Porous La0.6Sr0.4CoO3 − δ Samples by Conductivity Relaxation , 2005 .

[10]  J. Kilner,et al.  Electrical properties and oxygen diffusion in yttria-stabilised zirconia (YSZ)–La0.8Sr0.2MnO3±δ (LSM) composites , 2005 .

[11]  J. Kilner,et al.  Oxygen Transport in YSZ∕LSM Composite Materials , 2005 .

[12]  N. Brandon,et al.  Oxygen transport in La0.6Sr0.4Co0.2Fe0.8O3−δ/Ce0.8Ge0.2O2−x composite cathode for IT-SOFCs , 2004 .

[13]  B. Boukamp,et al.  Transport processes in mixed conducting oxides: combining time domain experiments and frequency domain analysis , 2004 .

[14]  H. Verweij,et al.  Reactor Flush Time Correction in Relaxation Experiments , 2001 .

[15]  Sangtae Kim,et al.  Oxygen surface exchange in mixed ionic electronic conductor membranes , 1999 .

[16]  John A. Kilner,et al.  Oxygen transport in La0.6Sr0.4Co0.2Fe0.8O3-δ , 1999 .

[17]  J. Maier.  On the correlation of macroscopic and microscopic rate constants in solid state chemistry , 1998 .

[18]  J. Kilner,et al.  Oxygen transport in La1−xSrxMn1−yCoyO3±δ perovskites: Part I. Oxygen tracer diffusion , 1998 .

[19]  J. Kilner,et al.  The kinetics of oxygen transport in 9.5 mol % single crystal yttria stabilised zirconia , 1997 .

[20]  J. Kilner,et al.  Oxygen self-diffusion and surface exchange studies of oxide electrolytes having the fluorite structure , 1996 .

[21]  J. Kilner,et al.  Surface exchange of oxygen in mixed conducting perovskite oxides , 1996 .

[22]  B. Steele,et al.  Development of a novel SIMS technique for oxygen self-diffusion and surface exchange coefficient measurements in oxides of high diffusivity , 1992 .

[23]  B. Steele,et al.  Oxygen self-diffusion studies using negative-ion secondary ion mass spectrometry (SIMS) , 1984 .

[24]  Changwen Hu,et al.  A novel application of mixed-valence Keggin-type polyoxometalates as non-aqueous electrolytes in polyacenic semiconductor secondary batteries , 2003 .

[25]  John Crank,et al.  The Mathematics Of Diffusion , 1956 .