Biofilm parameters influencing biocide efficacy

The influence of biofilm areal cell density, species composition, and the presence of abiotic particles on the disinfection and removal of bacterial biofilms by monochloramine was investigated. Mono‐ and binary population biofilms of Pseudomonas aeruginosa and Klebsiella pneumoniae were grown on stainless‐steel slides in a continuous flow annular reactor. Biofilms were treated in the reactor with a pulse/step dose of 4 mg/L monochloramine for 2 h. Biofilm samples were disaggregated and assayed for colony formation on R2A agar and for total cell numbers by acridine orange direct counts. These data were used to determine apparent first order rate coefficients for the processes of disinfection and detachment. Disinfection rate coefficients exceeded detachment rate coefficients by as much as an order of magnitude and the two coefficients were poorly correlated (r = 0.272). The overall decay rate coefficient (disinfection plus detachment) depended strongly on the initial biofilm areal cell density. It displayed a parabolic dependence on cell density with a maximum near 108 cfu/cm2. This result points to multiple factors influencing biofilm susceptibility to antimicrobial challenge. Decay rates of K. pneumoniae measured in binary population biofilms were comparable with those measured in monopopulation biofilms (p = 0.61). P. aeruginosa decayed more slowly in biofilsm dominated by K. pneumoniae (p = 0.028), indicating some interaction between species. The presence of kaolin and calcium carbonate particles in the biofilm reduced disinfection efficacy. © 1995 John Wiley & Sons, Inc.

[1]  William G. Characklis,et al.  Biocide action of monochloramine on biofilm systems of pseudomonas aeruginosa , 1993 .

[2]  H L Walmsley,et al.  The penetration of antibiotics into aggregates of mucoid and non-mucoid Pseudomonas aeruginosa. , 1989, Journal of general microbiology.

[3]  W. G. Characklis,et al.  Transport of 1‐μm latex particles in pseudomonas aeruginosa biofilms , 1993 .

[4]  J. Nickel,et al.  Bacterial biofilms and catheters: A key to understanding bacterial strategies in catheter-associated urinary tract infection. , 1992, The Canadian journal of infectious diseases = Journal canadien des maladies infectieuses.

[5]  J. Costerton,et al.  Dynamic interactions of biofilms of mucoid Pseudomonas aeruginosa with tobramycin and piperacillin , 1992, Antimicrobial Agents and Chemotherapy.

[6]  J. Costerton,et al.  Bacterial biofilms in nature and disease. , 1987, Annual review of microbiology.

[7]  P. Stewart,et al.  Interactions of 1 μm latex particles with pseudomonas aeruginosa biofilms , 1993 .

[8]  P. Stewart,et al.  Quantitative analysis of biofilm thickness variability , 1995, Biotechnology and bioengineering.

[9]  Mark W. LeChevallier,et al.  Coliform Regrowth in Drinking Water: A Review , 1990 .

[10]  P. Stewart,et al.  Biofilm accumulation model that predicts antibiotic resistance of Pseudomonas aeruginosa biofilms , 1994, Antimicrobial Agents and Chemotherapy.

[11]  A. K. Tiller,et al.  Microbial corrosion-1 , 1988 .

[12]  J. C. Hoff,et al.  Resistance of Bacterial Subpopulations to Disinfection by Chlorine Dioxide , 1988 .

[13]  Y. Miyaji,et al.  Penetration of Biocides into Biofilm , 1991 .

[14]  D. Holt.  Microbiology of Paper and Board Manufacture , 1988 .

[15]  P. Gilbert,et al.  Evaluation of a model biofilm for the ranking of biocide performance against sulphate‐reducing bacteria , 1993 .

[16]  Gun Wirtanen,et al.  Biofilm formation in the industry: A review , 1992 .

[17]  Z Lewandowski,et al.  Biofilms, the customized microniche , 1994, Journal of bacteriology.

[18]  P. Stewart,et al.  Direct measurement of chlorine penetration into biofilms during disinfection , 1994, Applied and environmental microbiology.

[19]  A. Camper.  Coliform regrowth and biofilm accumulation in drinking water systems: a review , 1993 .

[20]  J. J. Gauthier,et al.  Cell Density and Growth Phase as Factors in the Resistance of a Biofilm of Pseudomonas aeruginosa (ATCC 27853) to Iodine , 1993, Applied and environmental microbiology.

[21]  O. Cerf,et al.  Biofilms and their consequences, with particular reference to hygiene in the food industry. , 1993, The Journal of applied bacteriology.

[22]  E. Bouwer.  Theoretical investigation of particle deposition in biofilm systems , 1987 .

[23]  W. G. Characklis.  Bioengineering report: Fouling biofilm development: A process analysis , 1981 .

[24]  M. R. Brown,et al.  Sensitivity of biofilms to antimicrobial agents. , 1993, The Journal of applied bacteriology.

[25]  W. G. Characklis,et al.  Observations of binary population biofilms , 1991, Biotechnology and bioengineering.

[26]  P. Stewart,et al.  Effects of various metal substrata on accumulation of pseudomonas aeruginosa biofilms and the efficacy of monochloramine as a biocide , 1993 .