Electrical Properties of Cement-Based Composites with Carbon Nanotubes, Graphene, and Graphite Nanofibers

This study was conducted to evaluate the effect of the carbon-based nanomaterial type on the electrical properties of cement paste. Three different nanomaterials, multi-walled carbon nanotubes (MWCNTs), graphite nanofibers (GNFs), and graphene (G), were incorporated into the cement paste at a volume fraction of 1%. The self-sensing capacity of the cement composites was also investigated by comparing the compressive stress/strain behaviors by evaluating the fractional change of resistivity (FCR). The electrical resistivity of the plain cement paste was slightly reduced by adding 1 vol % GNFs and G, whereas a significant decrease of the resistivity was achieved by adding 1 vol % MWCNTs. At an identical volume fraction of 1%, the composites with MWCNTs provided the best self-sensing capacity with insignificant noise, followed by the composites containing GNFs and G. Therefore, the addition of MWCNTs was considered to be the most effective to improve the self-sensing capacity of the cement paste. Finally, the composites with 1 vol % MWCNTs exhibited a gauge factor of 113.2, which is much higher than commercially available strain gauges.

[1]  M. Pigeon,et al.  Electrical resistivity of carbon and steel micro-fiber reinforced cements , 1992 .

[2]  K. Hill,et al.  Photosensitivity in optical fiber waveguides: Application to reflection filter fabrication , 1978 .

[3]  Chao Wang,et al.  Application of Multiplexed FBG and PZT Impedance Sensors for Health Monitoring of Rocks , 2008, Sensors.

[4]  Filippo Ubertini,et al.  Investigations on scalable fabrication procedures for self-sensing carbon nanotube cement-matrix composites for SHM applications , 2016 .

[5]  Nemkumar Banthia,et al.  Effect of Carbon Fiber and Graphite Powder on Resistivity of Cement-based Sensor under Compression , 2014 .

[6]  M. Chiarello,et al.  Electrical conductivity of self-monitoring CFRC , 2005 .

[7]  Jia-Liang Le,et al.  Use of 2D Graphene Nanoplatelets (GNP) in cement composites for structural health evaluation , 2014 .

[8]  T. K. Gangopadhyay,et al.  Fibre Bragg gratings in structural health monitoring—Present status and applications , 2008 .

[9]  D.D.L. Chung,et al.  Cement-based materials for stress sensing by dielectric measurement , 2002 .

[10]  Filippo Ubertini,et al.  Micromechanics modeling of the uniaxial strain-sensing property of carbon nanotube cement-matrix composites for SHM applications , 2017 .

[11]  Filippo Ubertini,et al.  Micromechanics modeling of the electrical conductivity of carbon nanotube cement-matrix composites , 2017 .

[12]  Jinping Ou,et al.  Embedded piezoresistive cement-based stress/strain sensor , 2007 .

[13]  Habeom Lee,et al.  Heating and heat-dependent mechanical characteristics of CNT-embedded cementitious composites , 2016 .

[14]  D.D.L. Chung,et al.  Uniaxial compression in carbon fiber-reinforced cement, sensed by electrical resistivity measurement in longitudinal and transverse directions , 2000 .

[15]  Kamyar C. Mahboub,et al.  Interfacial Bond between Reinforcing Fibers and Calcium Sulfoaluminate Cements: Fiber Pullout Characteristics , 2014 .

[16]  Jing Xu,et al.  Modeling of conductivity in carbon fiber-reinforced cement-based composite , 2010 .

[17]  Bing Chen,et al.  Conductivity of carbon fiber reinforced cement-based composites , 2004 .

[18]  Dan Li,et al.  Reinforcing effects of graphene oxide on portland cement paste , 2015 .

[19]  G. Kim,et al.  Influences of CNT dispersion and pore characteristics on the electrical performance of cementitious composites , 2017 .

[20]  Filippo Ubertini,et al.  Multipurpose experimental characterization of smart nanocomposite cement-based materials for thermal-energy efficiency and strain-sensing capability , 2017 .

[21]  Jinping Ou,et al.  Electrode design, measuring method and data acquisition system of carbon fiber cement paste piezoresistive sensors , 2007 .

[22]  Eil Kwon,et al.  A carbon nanotube/cement composite with piezoresistive properties , 2009 .

[23]  Jinping Ou,et al.  Nano graphite platelets-enabled piezoresistive cementitious composites for structural health monitoring , 2017 .