Periodic silicon nanostructures for spectroscopic microsensors

Periodic silicon nanostructures can be used for different kinds of gas sensors depending on the analyte concentration. First we present an optical gas sensor based on the classical non-dispersive infrared technique for ppm-concentration using ultra-compact photonic crystal gas cells. It is conceptually based on low group velocities inside a photonic crystal gas cell and anti-reflection layers coupling light into the device. Experimentally, an enhancement of the CO2 infrared absorption by a factor of 2.6 to 3.5 as compared to an empty cell, due to slow light inside a 2D silicon photonic crystal gas cell, was observed; this is in excellent agreement with numerical simulations. In addition we report on silicon nanotip arrays, suitable for gas ionization in ion mobility microspectrometers (micro-IMS) having detection ranges in principle down to the ppt-range. Such instruments allow the detection of explosives, chemical warfare agents, and illicit drugs, e.g., at airports. We describe the fabrication process of large-scale-ordered nanotips with different tip shapes. Both silicon microstructures have been fabricated by photoelectrochemical etching of silicon.

[1]  Armin Lambrecht.  Quantum cascade lasers, systems, and applications in Europe , 2005, SPIE OPTO.

[2]  Pushing the limits of macroporous silicon etching , 2005 .

[3]  M. Zahniser,et al.  Sub-part-per-billion detection of nitric oxide in air using a thermoelectrically cooled mid-infrared quantum cascade laser spectrometer , 2002 .

[4]  Kurt Busch,et al.  Silicon‐Based Photonic Crystals , 2001 .

[5]  R. Wehrspohn,et al.  Reduced pore diameter fluctuations of macroporous silicon fabricated from neutron‐transmutation‐doped material , 2010 .

[6]  John U. White.  Long Optical Paths of Large Aperture , 1942 .

[7]  Stefan L. Schweizer,et al.  Miniature infrared gas sensors using photonic crystals , 2011 .

[8]  D. Pergande,et al.  Coupling Schemes for Low-Group Velocity Photonic Crystal Devices , 2009 .

[9]  Benjamin Gesemann,et al.  Large-Scale Fabrication of Ordered Silicon Nanotip Arrays Used for Gas Ionization in Ion Mobility Spectrometers , 2011, IEEE Transactions on Nanotechnology.

[10]  U. Gösele,et al.  Deep trench etching in macroporous silicon , 2006 .

[11]  Frank K. Tittel,et al.  Sub-ppbv nitric oxide concentration measurements using cw thermoelectrically cooled quantum cascade laser-based integrated cavity output spectroscopy , 2006 .

[12]  V. Lehmann.  The Physics of Macropore Formation in Low Doped n‐Type Silicon , 1993 .

[13]  Marco Antonio Robert Alves,et al.  Fabrication of sharp silicon tips employing anisotropic wet etching and reactive ion etching , 2005, Microelectron. J..