RF-MEMS Uniplanar 180 $^{\circ}$ Phase Switch Based on a Multimodal Air-Bridged CPW Cross

In this paper, a new compact broadband uniplanar 180° phase switch, based on an air-bridged coplanar-waveguide (CPW) cross loaded with two capacitive-contact microelectromechancial systems (MEMS) switches in opposed (on/off) states, is presented. The two phase-switch states (0°/180°) are defined by actuating the MEMS switches from on/off to off/on. The asymmetry in the states of the MEMS switches results in a complex multimodal interaction between the two fundamental even and odd CPW modes at the air-bridged cross. Using the multimodal theory, the phase switch is analyzed, its frequency-in dependent 180°-phase-shift properties are proven, and a set of design equations for perfect port matching are derived. A multi modal circuit model for the phase switch is then presented, and design equations and conditions for compact phase switches are derived. Finally, a very compact phase switch is designed and fabricated using an eight-mask surface micromachining process, featuring a measured phase shift of 180° ± 1.8° in a very wide frequency range (1-30 GHz) and an insertion loss better than 2.1 dB in the design band (10-20 GHz). Experimental results are in very good agreement with electromagnetic and multimodal circuit simulations, thus validating the proposed approach and design procedure.

[1]  J. E. Degenford,et al.  A 4.5 to 18 GHz Phase Shifter , 1985, 1985 IEEE MTT-S International Microwave Symposium Digest.

[2]  Leandro Lorenzelli,et al.  MEMS TECHNOLOGY FOR RF SWITCHES , 2004 .

[3]  M. Ribo,et al.  Compact, wideband CPW-to-slotline multimodal transition , 2007, 2007 European Microwave Conference.

[4]  Tadashi Takagi,et al.  An ultra-broad-band reflection-type phase-shifter MMIC with series and parallel LC circuits , 2001, IMS 2001.

[5]  A. Mediavilla,et al.  Very low-noise differential radiometer at 30 GHz for the PLANCK LFI , 2005, IEEE Transactions on Microwave Theory and Techniques.

[6]  Roberto Sorrentino,et al.  Reliability and Power Handling Issues in Ohmic Series and Shunt Capacitive RF MEMS Switches , 2006 .

[7]  M. Ribo,et al.  Circuit model for coplanar-slotline tees , 2000 .

[8]  R. Sloan,et al.  A Ka-band InP MMIC 180/spl deg/ phase switch , 2005, IEEE Microwave and Wireless Components Letters.

[9]  M. Ribo,et al.  Circuit model for a coplanar-slotline cross , 2000 .

[10]  M. Ribo,et al.  Circuit model for mode conversion in coplanar waveguide asymmetric series-impedances , 1999 .

[11]  M. Ribo,et al.  A Rigorous Multimodal Analysis and Design Procedure of a Uniplanar 180$^{\circ}$ Hybrid , 2009, IEEE Transactions on Microwave Theory and Techniques.

[12]  J.F. Luy,et al.  SIMMWIC-MEMS 180/spl deg/ switched line phase shifter , 2000, 2000 Topical Meetings on Silicon Monolithic Integrated Circuits in RF Systems. Digest of Papers (Cat. No.00EX397).

[13]  Giancarlo Bartolucci,et al.  Realisation of distributed RF MEMS phase shifter with very low number of switches , 2007 .

[14]  A. Lazaro,et al.  Characterization of dynamics and power handling of RF MEMS using vector measurement techniques , 2004, IEEE Transactions on Microwave Theory and Techniques.

[15]  David Girbau,et al.  MEMS-Based 180$^{\circ}$ Phase Switch for Differential Radiometers , 2010, IEEE Transactions on Microwave Theory and Techniques.

[16]  Enrique Villa,et al.  Wideband uniplanar 180° phase switch , 2009 .