Operation and performance of a low temperature organic Rankine cycle

Abstract The test and analysis of an Organic Rankine Cycle (ORC) with R123 as the working fluid were presented in this paper. A scroll expander was integrated in the system to generate work. The expander was connected with an AC dynamometer unit, which was used to control and measure the expander shaft torque and rotating speed. The conductive oil simulated the low grade heat source. Operation characteristics were compared between the heat source temperatures of 140 °C and 160 °C. The experiments were conducted by adjusting two independent parameters: the pumping frequency of the R123 pump and the shaft torque of the expander. The former parameter was directly related to the R123 mass flow rate and the later to the external load. The optimum system performance can be determined by these two parameters. The maximum measured shaft power and thermal efficiency were 2.35 kW and 6.39% at the heat source temperature of 140 °C, but they were 3.25 kW and 5.12% at the heat source temperature of 160 °C. This study identified that the measured shaft power was about 15–20% lower than the enthalpy determined values, and the pumping power of the organic fluid was 2–4 times higher than the enthalpy determined values. The enthalpy determined values were based on the local pressure and temperature sensor measurements.

[1]  Maoqing Li,et al.  Construction and preliminary test of a low-temperature regenerative Organic Rankine Cycle (ORC) using R123 , 2013 .

[2]  Bertrand F. Tchanche,et al.  Fluid selection for a low-temperature solar organic Rankine cycle , 2009 .

[3]  Hui Xie,et al.  The environmental impact of organic Rankine cycle for waste heat recovery through life-cycle assessment , 2013 .

[4]  Vincent Lemort,et al.  Testing and modeling a scroll expander integrated into an Organic Rankine Cycle , 2009 .

[5]  Jiang Wang,et al.  Performance evaluation of a low-temperature solar Rankine cycle system utilizing R245fa , 2010 .

[6]  George Kosmadakis,et al.  Identification of behaviour and evaluation of performance of small scale, low-temperature Organic Rankine Cycle system coupled with a RO desalination unit , 2009 .

[7]  N. Lai,et al.  Working fluids for high-temperature organic Rankine cycles , 2007 .

[8]  Jinliang Xu,et al.  The optimal evaporation temperature and working fluids for subcritical organic Rankine cycle , 2012 .

[9]  Jinliang Xu,et al.  Development and dynamic characteristics of an Organic Rankine Cycle , 2014 .

[10]  G. Kosmadakis,et al.  On site experimental evaluation of a low-temperature solar organic Rankine cycle system for RO desalination , 2009 .

[11]  Zhen Lu,et al.  Dynamic modeling and simulation of an Organic Rankine Cycle (ORC) system for waste heat recovery , 2008 .

[12]  Vincent Lemort,et al.  Experimental study and modeling of an Organic Rankine Cycle using scroll expander , 2010 .

[13]  Richard N. Christensen,et al.  EXPERIMENTAL TESTING OF GEROTOR AND SCROLL EXPANDERS USED IN, AND ENERGETIC AND EXERGETIC MODELING OF, AN ORGANIC RANKINE CYCLE , 2009 .

[14]  E. Stefanakos,et al.  A REVIEW OF THERMODYNAMIC CYCLES AND WORKING FLUIDS FOR THE CONVERSION OF LOW-GRADE HEAT , 2010 .

[15]  Stefano Clemente,et al.  Experimental tests and modelization of a domestic-scale ORC (Organic Rankine Cycle) , 2013 .

[16]  Vincent Lemort,et al.  Experimental study on an open-drive scroll expander integrated into an ORC (Organic Rankine Cycle) system with R245fa as working fluid , 2013 .

[17]  Wencheng Fu,et al.  Experimental comparison of R245fa and R245fa/R601a for organic Rankine cycle using scroll expander , 2015 .

[18]  Jie Ji,et al.  Energetic and exergetic investigation of an organic Rankine cycle at different heat source temperatures , 2012 .

[19]  Jie Ji,et al.  Construction and dynamic test of a small-scale organic rankine cycle , 2011 .

[20]  T. Hung.  Waste heat recovery of organic Rankine cycle using dry fluids , 2001 .

[21]  George Papadakis,et al.  Experimental evaluation of an autonomous low-temperature solar Rankine cycle system for reverse osmosis desalination , 2007 .

[22]  You-Rong Li,et al.  Influence of coupled pinch point temperature difference and evaporation temperature on performance of organic Rankine cycle , 2012 .

[23]  Chao Liu,et al.  Effect of the critical temperature of organic fluids on supercritical pressure Organic Rankine Cycles , 2013 .

[24]  Chi-Chuan Wang,et al.  Effect of working fluids on organic Rankine cycle for waste heat recovery , 2004 .

[25]  Rodolfo Taccani,et al.  Energy efficiency analysis of Organic Rankine Cycles with scroll expanders for cogenerative applications , 2012 .

[26]  Takahisa Yamamoto,et al.  Design and testing of the Organic Rankine Cycle , 2001 .

[27]  Jinliang Xu,et al.  A new design method for Organic Rankine Cycles with constraint of inlet and outlet heat carrier fluid temperatures coupling with the heat source , 2012 .

[28]  Jie Ji,et al.  Examination of the expander leaving loss in variable organic Rankine cycle operation , 2013 .

[29]  Thomas J. Bruno,et al.  Rapid Screening of Fluids for Chemical Stability in Organic Rankine Cycle Applications , 2005 .

[30]  Tzu-Chen Hung,et al.  A study of organic working fluids on system efficiency of an ORC using low-grade energy sources , 2010 .

[31]  P. Mago,et al.  Performance analysis of different working fluids for use in organic Rankine cycles , 2007 .

[32]  Li Zhao,et al.  Experimental verification of a rolling-piston expander that applied for low-temperature Organic Rankine Cycle , 2013 .

[33]  Vasile Minea,et al.  Power generation with ORC machines using low-grade waste heat or renewable energy , 2014 .