Moisture transport and adsorption on silica gel-calcium chloride composite adsorbents

Abstract A measurement of moisture uptake curves in silica gel–calcium composite adsorbents is performed by using the thermal gravimetrical method in a relative vapor pressure range from 0.5 to 0.9 at different temperature levels of 25, 35 and 45 °C, respectively. Also, dynamic adsorption curves individually corresponding to the temperature and relative pressure conditions of (25 °C, 0.7), (35 °C, 0.7) and (35 °C, 0.5) have been measured. This experimental study shows that the sorption rate is highest for non-impregnated macroporous silica gel; however, the same silica gel impregnated with calcium chloride has a much greater final water loading. This confirms that composite adsorbents result in a better adsorption performance compared with non-impregnated silica gel, leading to a trade off in finalizing the content of CaCl 2 in the composite. Through theoretical analysis on the experimental data, it is found that the saturated adsorption data can be well fitted by the FHH model and the dynamic adsorption data well fitted by the Crank diffusion model, simultaneously yielding the effective solid side mass diffusivities. A comparison with these obtained diffusion coefficients further supports that the mass diffusivity in the composite adsorbent also increases with an increase in temperature, as well as in humidity, but drastically decreases due to the presence of salt inside the matrix pores compared with the non-impregnated host matrix.

[1]  G. Cacciola,et al.  A family of new working materials for solid sorption air conditioning systems , 2002 .

[2]  Yuri I. Aristov,et al.  Experimental study on the kinetics of water vapor sorption on selective water sorbents, silica gel and alumina under typical operating conditions of sorption heat pumps , 2003 .

[3]  Giovanni Restuccia,et al.  Selective water sorbents for multiple applications, 1. CaCl2 confined in mesopores of silica gel: Sorption properties , 1996 .

[4]  T. L. Hill.  Physical Adsorption and the Free Volume Model for Liquids , 1949 .

[6]  E. Teller,et al.  On a Theory of the van der Waals Adsorption of Gases , 1940 .

[7]  John Crank,et al.  The Mathematics Of Diffusion , 1956 .

[8]  Ahmad Pesaran,et al.  Moisture transport in silica gel packed beds—II. Experimental study , 1987 .

[9]  Wang Ruzhu,et al.  Pore structure of new composite adsorbent SiO2 . xH2O . yCaCl2 with high uptake of water from air , 2003 .

[10]  E. Teller,et al.  ADSORPTION OF GASES IN MULTIMOLECULAR LAYERS , 1938 .

[11]  V. A. Astakhov,et al.  Description of Adsorption Equilibria of Vapors on Zeolites over Wide Ranges of Temperature and Pressure , 1971 .

[12]  F. Toribio,et al.  Adsorption of water vapor by poly(styrenesulfonic acid), sodium salt: isothermal and isobaric adsorption equilibria. , 2004, Journal of colloid and interface science.

[13]  G. Halsey,et al.  Physical Adsorption on Non‐Uniform Surfaces , 1948 .

[14]  Ahmad Pesaran,et al.  Moisture transport in silica gel packed beds—I.Theoretical study , 1987 .

[15]  J. Frankel.  Kinetic theory of liquids , 1946 .