Full scale performance of the aerobic granular sludge process for sewage treatment.

Recently, aerobic granular sludge technology has been scaled-up and implemented for industrial and municipal wastewater treatment under the trade name Nereda(®). With full-scale references for industrial treatment application since 2006 and domestic sewage since 2009 only limited operating data have been presented in scientific literature so far. In this study performance, granulation and design considerations of an aerobic granular sludge plant on domestic wastewater at the WWTP Garmerwolde, the Netherlands were analysed. After a start-up period of approximately 5 months, a robust and stable granule bed (>8 g L(-1)) was formed and could be maintained thereafter, with a sludge volume index after 5 min settling of 45 mL g(-1). The granular sludge consisted for more than 80% of granules larger than 0.2 mm and more than 60% larger than 1 mm. Effluent requirements (7 mg N L(-1) and 1 mg P L(-1)) were easily met during summer and winter. Maximum volumetric conversion rates for nitrogen and phosphorus were respectively 0.17 and 0.24 kg (m(3) d)(-1). The energy usage was 13.9 kWh (PE150·year)(-1) which is 58-63 % lower than the average conventional activated sludge treatment plant in the Netherlands. Finally, this study demonstrated that aerobic granular sludge technology can effectively be implemented for the treatment of domestic wastewater.

[1]  P. Hugenholtz,et al.  Identification of Polyphosphate-Accumulating Organisms and Design of 16S rRNA-Directed Probes for Their Detection and Quantitation , 2000, Applied and Environmental Microbiology.

[2]  J. Tay,et al.  Aerobic Granulation: Advances and Challenges , 2012, Applied Biochemistry and Biotechnology.

[3]  J. Tay,et al.  Selection pressure-driven aerobic granulation in a sequencing batch reactor , 2005, Applied Microbiology and Biotechnology.

[4]  J. Wagner,et al.  Aerobic Granulation in a Sequencing Batch Reactor Using Real Domestic Wastewater , 2013 .

[5]  R. Méndez,et al.  Operation of an aerobic granular pilot scale SBR plant to treat swine slurry , 2013 .

[6]  H. Horn,et al.  Aerobic Sludge Granulation in a Full-Scale Sequencing Batch Reactor , 2014, BioMed research international.

[7]  Julio Pérez,et al.  A novel control strategy for enhancing biological N-removal in a granular sequencing batch reactor: A model-based study , 2013 .

[8]  J. Banfield,et al.  Glycogen-accumulating organisms in laboratory-scale and full-scale wastewater treatment processes. , 2002, Microbiology.

[9]  M. V. van Loosdrecht,et al.  Modeling the nutrient removal process in aerobic granular sludge system by coupling the reactor‐ and granule‐scale models , 2015, Biotechnology and bioengineering.

[10]  M. Loosdrecht,et al.  Method for acquiring grain-shaped growth of a microorganism in a reactor , 1998 .

[11]  M. V. van Loosdrecht,et al.  Evaluating the solid retention time of bacteria in flocculent and granular sludge. , 2012, Water research.

[12]  M. V. van Loosdrecht,et al.  The contribution of exopolysaccharides induced struvites accumulation to ammonium adsorption in aerobic granular sludge. , 2012, Water research.

[13]  A. Jobbágy,et al.  Savings with upgraded performance through improved activated sludge denitrification in the combined activated sludge-biofilter system of the Southpest Wastewater Treatment Plant. , 2008, Water science and technology : a journal of the International Association on Water Pollution Research.

[14]  R. Amann,et al.  Combination of 16S rRNA-targeted oligonucleotide probes with flow cytometry for analyzing mixed microbial populations , 1990, Applied and environmental microbiology.

[15]  M. V. van Loosdrecht,et al.  Effect and behaviour of different substrates in relation to the formation of aerobic granular sludge , 2015, Applied Microbiology and Biotechnology.

[16]  M C M van Loosdrecht,et al.  Sieving wastewater--cellulose recovery, economic and energy evaluation. , 2013, Water research.

[17]  J J Heijnen,et al.  Stoichiometry and kinetics of poly‐β‐hydroxybutyrate metabolism under denitrifying conditions in activated sludge cultures , 2000, Biotechnology and bioengineering.

[18]  R. Amann,et al.  Community Structure and Activity Dynamics of Nitrifying Bacteria in a Phosphate-Removing Biofilm , 2001, Applied and Environmental Microbiology.

[19]  L. M. M. de Bruin,et al.  Advancements in the application of aerobic granular biomass technology for sustainable treatment of wastewater , 2013 .

[20]  M C M van Loosdrecht,et al.  Ammonium adsorption in aerobic granular sludge, activated sludge and anammox granules. , 2011, Water research.

[21]  Peter A. Wilderer,et al.  Aerobic granular sludge in a sequencing batch reactor , 1997 .

[22]  K. Schleifer,et al.  The domain-specific probe EUB338 is insufficient for the detection of all Bacteria: development and evaluation of a more comprehensive probe set. , 1999, Systematic and applied microbiology.

[23]  S. Takizawa,et al.  Factors affecting nitrogen removal from domestic wastewater using immobilized bacteria , 1998 .

[24]  Thierry Morliere,et al.  Installation for the treatment of waste , 2013 .

[25]  J. Tramper,et al.  Reduced temperature sensitivity of immobilized Nitrobacter agilis cells caused by diffusion limitation , 1997 .

[26]  Zhenxing Yao,et al.  Aerobic granulation and nitrogen removal with the effluent of internal circulation reactor in start-up of a pilot-scale sequencing batch reactor , 2012, Bioprocess and Biosystems Engineering.

[27]  H. Horn,et al.  Aerobic granules dwelling vorticella and rotifers in an SBR fed with domestic wastewater , 2013 .

[28]  R. Zeng,et al.  Simultaneous nitrification, denitrification, and phosphorus removal in a lab‐scale sequencing batch reactor , 2003, Biotechnology and bioengineering.

[29]  R. Méndez,et al.  Anaerobic digestion of aerobic granular biomass: effects of thermal pre‐treatment and addition of primary sludge , 2014 .

[30]  M. V. van Loosdrecht,et al.  N-removal in a granular sludge sequencing batch airlift reactor. , 2001, Biotechnology and bioengineering.

[31]  Joo-Hwa Tay,et al.  Effect of settling time on aerobic granulation in sequencing batch reactor , 2004 .

[32]  M C M van Loosdrecht,et al.  Aerobic granular sludge technology: an alternative to activated sludge? , 2004, Water science and technology : a journal of the International Association on Water Pollution Research.

[33]  C. Holliger,et al.  Dynamics of Microbial Community Structure of and Enhanced Biological Phosphorus Removal by Aerobic Granules Cultivated on Propionate or Acetate , 2011, Applied and Environmental Microbiology.

[34]  J. Heijnen,et al.  Aerobic granulation in a sequencing batch reactor , 1999 .

[35]  Joo-Hwa Tay,et al.  Advances in aerobic granule formation and granule stability in the course of storage and reactor operation. , 2010, Biotechnology advances.

[36]  Thomas Welander,et al.  Use of protozoa and metazoa for decreasing sludge production in aerobic wastewater treatment , 1996, Biotechnology Letters.

[37]  Mark C.M. van Loosdrecht,et al.  A more unifying hypothesis for biofilm structures , 1997 .

[38]  R. Lemaire,et al.  Micro-scale observations of the structure of aerobic microbial granules used for the treatment of nutrient-rich industrial wastewater , 2008, The ISME Journal.

[39]  P A Wilderer,et al.  Generation and properties of aerobic granular sludge. , 2001, Water science and technology : a journal of the International Association on Water Pollution Research.

[40]  M C M van Loosdrecht,et al.  Behavior of polymeric substrates in an aerobic granular sludge system. , 2010, Water research.

[41]  V. B. Manilal,et al.  Involvement of protozoa in anaerobic wastewater treatment process. , 2007, Water research.

[42]  M. V. van Loosdrecht,et al.  Aerobic granular sludge--state of the art. , 2007, Water science and technology : a journal of the International Association on Water Pollution Research.

[43]  M. V. van Loosdrecht,et al.  Effect of Elevated Salt Concentrations on the Aerobic Granular Sludge Process: Linking Microbial Activity with Microbial Community Structure , 2011, Applied and Environmental Microbiology.

[44]  Julio Pérez,et al.  Long term operation of a granular sequencing batch reactor at pilot scale treating a low-strength wastewater , 2012 .

[45]  J. J. Heijnen,et al.  The sharon process: an innovative method for nitrogen removal from ammonium-rich waste water , 1998 .

[46]  M. Loosdrecht,et al.  Formation of Aerobic Granules with Domestic Sewage , 2006 .

[47]  R. Stuetz,et al.  Monitoring of wastewater odours using an electronic nose , 2000 .

[48]  L. M. M. de Bruin,et al.  Towards sustainable waste water treatment with Dutch Nereda® technology , 2011 .

[49]  J. Tramper,et al.  Effects of diffusion limitation on immobilized nitrifying microorganisms at low temperatures , 1995, Biotechnology and bioengineering.

[50]  C. Holliger,et al.  Optimized aeration strategies for nitrogen and phosphorus removal with aerobic granular sludge. , 2013, Water research.

[51]  Zhiguo Yuan,et al.  Reducing the startup time of aerobic granular sludge reactors through seeding floccular sludge with crushed aerobic granules. , 2011, Water research.

[52]  J. I. Pérez,et al.  Optimization of Reactor Depth in Membrane Bioreactors for Municipal Wastewater Treatment , 2014 .

[53]  Johannes Tramper,et al.  Nitrification by immobilized cells. , 1995 .

[54]  M. Coma,et al.  Enhancing aerobic granulation for biological nutrient removal from domestic wastewater. , 2012, Bioresource technology.

[55]  C. Cornea,et al.  Aerobic granular sludge in a sequencing batch reactor , 2015 .

[56]  P. Wilderer,et al.  Aerobic granular sludge in an SBR-system treating wastewater rich in particulate matter. , 2004, Water science and technology : a journal of the International Association on Water Pollution Research.

[57]  J. Tay,et al.  Formation, physical characteristics and microbial community structure of aerobic granules in a pilot-scale sequencing batch reactor for real wastewater treatment. , 2010, Enzyme and microbial technology.

[58]  J J Heijnen,et al.  Simultaneous COD, nitrogen, and phosphate removal by aerobic granular sludge. , 2005, Biotechnology and bioengineering.

[59]  J. Tay,et al.  Characteristics of Aerobic Granules Grown on Glucose and Acetate in Sequential Aerobic Sludge Blanket Reactors , 2002, Environmental technology.