Piezoelectric accelerometers for ultrahigh temperature application

High temperature sensors are of major importance to aerospace and energy related industries. In this letter, a high temperature monolithic compression-mode piezoelectric accelerometer was fabricated using YCa4O(BO3)3 (YCOB) single crystals. The performance of the sensor was tested as function of temperature up to 1000 °C and over a frequency range of 100–600 Hz. The accelerometer prototype was found to possess sensitivity of 2.4±0.4 pC/g, across the measured temperature and frequency range, indicating a low temperature coefficient. Furthermore, the sensor exhibited good stability over an extended dwell time at 900 °C, demonstrating that YCOB piezoelectric accelerometers are promising candidates for high temperature sensing applications.

[1]  G. Schleinzer,et al.  Gallium phosphate, GaPO4: a new piezoelectric crystal material for high-temperature sensorics , 1997 .

[2]  Thomas R. Shrout,et al.  Gadolinium calcium oxyborate piezoelectric single crystals for ultrahigh temperature (>1000 °C) applications , 2008 .

[3]  Yiting Fei,et al.  High-temperature piezoelectric single crystal ReCa4O(BO3)3 for sensor applications , 2008, IEEE Transactions on Ultrasonics, Ferroelectrics and Frequency Control.

[4]  Morito Akiyama,et al.  Measurement of output voltage of aluminum nitride thin film as a pressure sensor at high temperature , 2006 .

[5]  Gustave C. Fralick,et al.  Development and application of high-temperature sensors and electronics for propulsion applications , 2006, SPIE Defense + Commercial Sensing.

[6]  Neil M. White,et al.  Fabrication of high temperature surface acoustic wave devices for sensor applications , 2005 .

[7]  Gary W. Hunter,et al.  Development of SiC-based Gas Sensors for Aerospace Applications , 2004 .

[8]  Gustave C. Fralick,et al.  Steady-State and Frequency Response of a Thin-Film Heat Flux Gauge , 1997 .

[9]  Yonggui Dong,et al.  A temperature insensitive quartz resonator force sensor , 2000 .

[10]  Thomas R. Shrout,et al.  Characterization of piezoelectric single crystal YCa4O(BO3)3 for high temperature applications , 2008 .

[11]  Holger Fritze,et al.  Langasite for high-temperature bulk acoustic wave applications , 2001 .

[12]  Robert S. Okojie,et al.  Reliability assessment of Ti/TaSi2/Pt ohmic contacts on SiC after 1000 h at 600 °C , 2002 .

[13]  Dragan Damjanovic,et al.  Materials for high temperature piezoelectric transducers , 1998 .

[14]  S. Zhang.  5 – High-performance, high-TC piezoelectric crystals , 2008 .

[15]  Thomas R. Shrout,et al.  Characterization of high temperature piezoelectric crystals with an ordered langasite structure , 2009 .

[16]  N. Setter,et al.  Piezoelectric materials in devices , 2002 .

[17]  Ken Haenen,et al.  Wide range pressure sensor based on a piezoelectric bimorph microcantilever , 2006 .