An empirical model for estimating the saturation pressures of crude oils

Abstract Recently, there has been an increasing interest in enhanced oil recovery (EOR) calculations of saturation pressures when various gases contact crude oils. Equations of state are usually used for calculations of saturation pressure at initial condition of discovery or later during EOR design. However, the equations of state results are not reliable unless they are properly tuned using some experimental data of reservoir fluid. The availability of extended analysis of reservoir fluids, characterization of heavy fraction, and number of components are influencing the saturation pressure estimated by equations of state. A simple empirical model to calculate the saturation pressures of crude oil systems was developed. Experimentally measured compositions and saturation pressures of 60 crude oil samples from the Middle East were used to develop the model. Compositions and saturation pressures of 75 crude oil samples from the literature were used to test the accuracy and validity of the model against measured data and simulations by equations of state. The results indicate that the model is accurate, valid, reliable, and eliminates the splitting and characterizing of the heavy fraction, which is necessary for the equations of state. The model is useful for estimating the saturation pressure where experimental data is not available. For EOR processes, the model can be used to calculate the saturation pressure during single contact by hydrocarbon gases.

[1]  R. A. Behrens,et al.  The Use of Semicontinuous Description To Model the C7+ Fraction in Equation of State Calculations , 1988 .

[2]  Aage Fredenslund,et al.  Thermodynamics of petroleum mixtures containing heavy hydrocarbons. 3. Efficient flash calculation procedures using the SRK equation of state , 1985 .

[3]  L. Rosenegger,et al.  Integrated Oil PVT Characterization - Lessons From Four Case Histories , 1999 .

[4]  A. Fredenslund,et al.  Thermodynamics of petroleum mixtures containing heavy hydrocarbons. 1. Phase envelope calculations by use of the Soave-Redlich-Kwong equation of state , 1984 .

[5]  K. S. Pedersen,et al.  Characterization of gas condensate mixtures , 1988 .

[6]  Bharat S. Jhaveri,et al.  Three-parameter modification of the Peng-Robinson equation of state to improve volumetric predictions , 1988 .

[7]  Karen Schou Pedersen,et al.  Phase Behavior of Petroleum Reservoir Fluids , 2006 .

[8]  Tarek Ahmed,et al.  Hydrocarbon Phase Behavior , 1989 .

[9]  L. Nghiem,et al.  A Regression Technique With Dynamic Parameter Selection for Phase-Behavior Matching , 1990 .

[10]  G. Soave.  Equilibrium constants from a modified Redlich-Kwong equation of state , 1972 .

[11]  T. Ahmed.  Comparative Study of Eight Equations of State for Predicting Hydrocarbon Volumetric Phase Behavior , 1988 .

[12]  Ali Danesh,et al.  Comparative study of cubic equations of state for predicting phase behaviour and volumetric properties of injection gas-reservoir oil systems , 1991 .

[13]  K. C. Hong.  Lumped-component characterization of crude oils for compositional simulation , 1982 .

[14]  A. M. Schulte,et al.  Birba Field PVT Variations Along the Hydrocarbon Column and Confirmatory Field Tests , 1985 .

[15]  M. Hirata,et al.  Generalized interaction parameters for the Peng—Robinson equation of state: Carbon dioxide—n-paraffin binary systems , 1981 .

[16]  C. H. Whitson,et al.  Characterizing hydrocarbon plus fractions , 1983 .

[17]  Long X. Nghiem,et al.  Phase Behaviour Computations For Reservoir Fluids: Effect Of Pseudo-Components On Phase Diagrams And Simulation Results , 1985 .

[18]  J. Prausnitz,et al.  Flash calculations for continuous or semicontinuous mixtures by use of an equation of state , 1985 .

[19]  G. Stewart,et al.  Phase Behavior of Systems Comprising North Sea Reservoir Fluids and Injection Gases , 1984 .

[20]  A. E. Hoffman,et al.  Equilibrium Constants for a Gas-Condensate System , 1953 .

[21]  Keith H. Coats,et al.  Application of a regression-based EOS PVT program to laboratory data , 1986 .

[22]  Adrian Christopher Todd,et al.  A Grouping Method To Optimize Oil Description for Compositional Simulation of Gas-Injection Processes , 1992 .

[23]  D. Peng,et al.  A New Two-Constant Equation of State , 1976 .

[24]  W. H. Goldthorpe,et al.  Enhancing the evaluation of PVT data , 1988 .

[25]  Craig A. Williams,et al.  Use Of The Peng-Robinson Equation Of State To Predict Hydrocarbon Phase Behavior And Miscibility For Fluid Displacement , 1980 .

[26]  Karen Schou Pedersen,et al.  PVT calculations on petroleum reservoir fluids using measured and estimated compositional data for the plus fraction , 1992 .

[27]  C. Whitson.  Effect of C7+ Properties on Equation-of-State Predictions , 1984 .

[28]  Adel M. Elsharkawy,et al.  Predicting the dew point pressure for gas condensate reservoirs: empirical models and equations of state , 2002 .

[29]  C. H. Whitson,et al.  Application of the gamma distribution model to molecular weight and boiling point data for petroleum fractions , 1990 .

[30]  L. Baker,et al.  Critical Point and Saturation Pressure Calculations for Multipoint Systems (includes associated paper 8871 ) , 1980 .

[31]  L. Rosenegger,et al.  Comparison of PVT Properties From Equation of State Analysis And PVT Correlations For Reservoir Studies , 2000 .

[32]  John L. Vogel,et al.  The Effect Of Nitrogen On The Phase Behavior And Physical Properties Of Reservoir Fluids , 1980 .

[33]  Mohamed A. Fahim,et al.  Prediction of Viscosity of Heavy Petroleum Fractions and Crude Oils Using a Corresponding States Method , 1995 .

[34]  Julian Y. Zuo,et al.  Plus Fraction Characterization and PVT Data Regression for Reservoir Fluids near Critical Conditions , 2000 .

[35]  A. Fredenslund,et al.  On the dangers of “tuning” equation of state parameters , 1988 .

[36]  P. Christensen.  Regression to Experimental PVT Data , 1999 .

[37]  D. Tassios,et al.  Vapor-liquid equilibria in nonpolar/weakly polar systems with different types of mixing rules , 1993 .

[38]  Abbas Firoozabadi,et al.  Predicting Phase Behavior of Condensate/Crude-Oil Systems Using Methane Interaction Coefficients , 1978 .