Two-Dimensional Flow and NOx Emissions in Deflagrative Internal Combustion Wave Rotor Configurations

A wave rotor is proposed for use as a constant volume combustor. A novel design feature is investigated as a remedy for hot gas leakage, premature ignition, and pollutant emissions that are possible in this class of unsteady machines. The base geometry involves fuel injection partitions that allow stratification of fuel/oxidizer mixtures in the wave rotor channel radially, enabling pilot ignition of overall lean mixture for low NO x combustion. In this study, available turbulent combustion models are applied to simulate approximately constant volume combustion of propane and resulting transient compressible flow. Thermal NO production histories are predicted by simulations of the STAR-CD code. Passage inlet/outlet/wall boundary conditions are time-dependent, enabling the representation of a typical deflagrative internal combustor wave rotor cycle. Some practical design improvements are anticipated from the computational results. For a large number of derivative design configurations, fuel burn rate, two-dimensional flow and emission levels are evaluated. The sensitivity of channel combustion to initial turbulence levels is evaluated.

[1]  D. E. Paxson.  A numerical model for dynamic wave rotor analysis , 1995 .

[2]  Christopher J. Rutland,et al.  Intake flow modeling in a four stroke diesel using KIVA3 , 1995 .

[3]  Tang-Wei Kuo,et al.  Multidimensional Port-and-Cylinder Gas Flow, Fuel Spray, and Combustion Calculations for a Port-Fuel-Injection Engine , 1992 .

[4]  S. Penner.  Physics of shock waves and high-temperature hydrodynamic phenomena - Ya.B. Zeldovich and Yu.P. Raizer (translated from the Russian and then edited by Wallace D. Hayes and Ronald F. Probstein); Dover Publications, New York, 2002, 944 pp., $34. , 2003 .

[5]  Ronald K. Hanson,et al.  Kinetics of the reaction of nitric oxide with hydrogen , 1975 .

[6]  M. Razi Nalim,et al.  Longitudinally Stratified Combustion in Wave Rotors , 2000 .

[7]  Frediano V. Bracco,et al.  Pressure non-uniformity and mixing characteristics in stratified-charge rotary engine combustion , 1988 .

[8]  Nyein Chan.  Turbulence and turbulent combustion in spark ignition engines , 1979 .

[9]  J. Keller,et al.  Ignition and flame propagation process with rotating hot jets in a simulated wave engine test cell , 1998 .

[10]  Daniel E. Paxson,et al.  Numerical simulation of dynamic wave rotor performance , 1996 .

[11]  L. M. Larosiliere.  Wave rotor charging process - Effects of gradual opening and rotation , 1995 .

[12]  J. Kentfield.  Circumferential cell-dividers in wave-rotors , 1998 .

[13]  John R. Bourne,et al.  Mixing and fast chemical reactionITest reactions to determine segregation , 1981 .

[14]  Salah S. Ibrahim,et al.  Predictions of turbulent, premixed flame propagation in explosion tubes , 1995 .

[15]  Robert W. Bilger,et al.  On the Eddy Break-Up coefficient , 1996 .

[16]  Rolf D. Reitz,et al.  Computation of Premixed-Charge Combustion in Pancake and Pent-Roof Engines , 1989 .

[17]  C. Westbrook,et al.  Simplified Reaction Mechanisms for the Oxidation of Hydrocarbon Fuels in Flames , 1981 .

[18]  Kenol Jules,et al.  PULSE COMBUSTION AND WAVE ROTORS FOR HIGH-SPEED PROPULSION ENGINES , 1998 .

[19]  Daniel E. Paxson.  A Numerical Investigation of the Startup Transient in a Wave Rotor , 1996 .

[20]  B. Hjertager,et al.  On mathematical modeling of turbulent combustion with special emphasis on soot formation and combustion , 1977 .

[21]  B. Launder,et al.  The numerical computation of turbulent flows , 1990 .

[22]  R. Tabaczynski.  Turbulence and turbulent combustion in spark-ignition engines , 1976 .

[23]  Daniel E. Paxson,et al.  Wave rotor optimization for gas turbine engine topping cycles , 1996 .

[24]  M. Razi Nalim,et al.  Wave Cycle Design for NOx-Limited Wave Rotor Core Engines for High Speed Propulsion , 1993 .

[25]  Kerem Pekkan,et al.  Control of Fuel and Hot-Gas Leakage in a Stratified Internal Combustion Wave Rotor , 2002 .

[26]  Gerard E. Welch,et al.  Two-Dimensional Computational Model for Wave Rotor Flow Dynamics , 1996 .

[27]  D. Spalding.  Mixing and chemical reaction in steady confined turbulent flames , 1971 .

[28]  B. Launder,et al.  THE NUMERICAL COMPUTATION OF TURBULENT FLOW , 1974 .

[29]  Stephen B. Pope,et al.  Computations of turbulent combustion: Progress and challenges , 1991 .

[30]  Gerard E. Welch,et al.  Performance Benefits for Wave Rotor-Topped Gas Turbine Engines , 1996 .

[31]  M. R. Nalim.  Assessment of combustion modes for internal combustion wave rotors , 1999 .

[32]  Frediano V. Bracco,et al.  Comparisons of computed and measured premixed charge engine combustion , 1985 .

[33]  A. Lefebvre.  Gas Turbine Combustion , 1983 .

[34]  S. Correa.  A Review of NOx Formation Under Gas-Turbine Combustion Conditions , 1993 .

[35]  Ivar S. Ertesvåg,et al.  Influence of Turbulence Modeling on Predictions of Turbulent Combustion , 1997 .

[36]  Ronald K. Hanson,et al.  Shock tube determination of the rate coefficient for the reaction N2+O→NO+N , 1979 .

[37]  Christopher J. Freitas,et al.  Perspective: Selected Benchmarks From Commercial CFD Codes , 1995 .

[38]  Weeratunge Malalasekera,et al.  An introduction to computational fluid dynamics - the finite volume method , 2007 .

[39]  Song-Charng Kong,et al.  The Development and Application of a Diesel Ignition and Combustion Model for Multidimensional Engine Simulation , 1995 .

[40]  F. Williams,et al.  Turbulent Reacting Flows , 1981 .

[41]  S. E. Tahry.  K-epsilon equation for compressible reciprocating engine flows , 1983 .

[42]  M. Razi Nalim.  NUMERICAL STUDY OF STRATIFIED CHARGE COMBUSTION IN WAVE ROTORS , 1997 .

[43]  Bjørn H. Hjertager,et al.  SIMULATION OF TRANSIENT COMPRESSIBLE TURBULENT REACTIVE FLOWS , 1982 .

[44]  Gerard E. Welch,et al.  Wave-Rotor-Enhanced Gas Turbine Engines , 1995 .

[45]  D. Spalding,et al.  A calculation procedure for heat, mass and momentum transfer in three-dimensional parabolic flows , 1972 .

[46]  Daniel E. Paxson,et al.  A comparison between numerically modelled and experimentally measured loss mechanisms in wave rotors , 1993 .

[47]  A. Gosman,et al.  Solution of the implicitly discretised reacting flow equations by operator-splitting , 1986 .

[48]  J.H.W. Lau,et al.  Comparison of Pdf and eddy-dissipation combustion models applied to a propane jet flame , 1995 .

[49]  R. P. Lindstedt,et al.  Computations of steady-state and transient premixed turbulent flames using pdf methods , 1996 .

[50]  M. S. Raju,et al.  Heat Transfer and Performance Characteristics of a Dual-Ignition Wankel Engine , 1992 .