Piezoelectric-on-Silicon Lateral Bulk Acoustic Wave Micromechanical Resonators

This paper reports on the design, fabrication, and characterization of piezoelectrically-transduced micromechanical single-crystal-silicon resonators operating in their lateral bulk acoustic modes to address the need for high-Q microelectronic-integrable frequency-selective components. A simple electromechanical model for optimizing performance is presented. For verification, resonators were fabricated on 5-mum-thick silicon-on- insulator substrates and use a 0.3-mum zinc oxide film for transduction. A bulk acoustic mode was observed from a 240 mum times 40 mum resonator with a 600-Omega impedance (Q=3400 at P=1 atm) at 90 MHz. A linear resonator absorbed power of -0.5 dBm and an output current of 1.3 mA rms were measured. The same device also exhibited a Q of 12 000 in its fundamental extensional mode at a pressure of 5 torr.

[1]  A. Ballato,et al.  Piezoelectric resonator materials , 1994, Proceedings of IEEE 48th Annual Symposium on Frequency Control.

[2]  Farrokh Ayazi,et al.  Vertical capacitive SiBARs , 2005, 18th IEEE International Conference on Micro Electro Mechanical Systems, 2005. MEMS 2005..

[3]  G. Chen,et al.  The dimensional effect of breakdown field in ZnO varistors , 2002 .

[4]  H. Morkoç,et al.  POLARIZATION EFFECTS IN NITRIDE SEMICONDUCTOR HETEROSTRUCTURES , 2000 .

[5]  H. Seppa,et al.  Nonlinear limits for single-crystal silicon microresonators , 2004, Journal of Microelectromechanical Systems.

[6]  C. Nguyen,et al.  MEMS technology for timing and frequency control , 2005, Proceedings of the 2005 IEEE International Frequency Control Symposium and Exposition, 2005..

[7]  Reza Abdolvand,et al.  High frequency micromechanical piezo-on-silicon block resonators , 2003, IEEE International Electron Devices Meeting 2003.

[8]  M. Madou.  Fundamentals of microfabrication , 1997 .

[9]  K. Lakin,et al.  Thin film resonator technology , 2003, IEEE Transactions on Ultrasonics, Ferroelectrics and Frequency Control.

[10]  J. Larson,et al.  Ultra-miniature high-Q filters and duplexers using FBAR technology , 2001, 2001 IEEE International Solid-State Circuits Conference. Digest of Technical Papers. ISSCC (Cat. No.01CH37177).

[11]  G. K. Ho,et al.  High-Q single crystal silicon HARPSS capacitive beam resonators with self-aligned sub-100-nm transduction gaps , 2003 .

[12]  Kazuo Tsubouchi,et al.  AlN Material Constants Evaluation and SAW Properties on AlN/Al 2 O 3 and AlN/Si , 1981 .

[13]  C. J. Brierley,et al.  The influence of ZnO and electrode thickness on the performance of thin film bulk acoustic wave resonators , 1999, 1999 IEEE Ultrasonics Symposium. Proceedings. International Symposium (Cat. No.99CH37027).

[14]  S. Trolier-McKinstry,et al.  Thin Film Piezoelectrics for MEMS , 2004 .

[15]  G. Piazza,et al.  Low motional resistance ring-shaped contour-mode aluminum nitride piezoelectric micromechanical resonators for UHF applications , 2005, 18th IEEE International Conference on Micro Electro Mechanical Systems, 2005. MEMS 2005..