Steam gasification of biomass for hydrogen-rich gas in a free-fall reactor

Abstract Characteristics of steam gasification of two kinds of biomass (legume straw and pine sawdust) at high heating rate (in the order of 1000 ∘ C s - 1 ) in a gas–solid concurrent downflow free-fall reactor were investigated. The effects of steam/biomass ( S / B ) mass ratio (0.0–1.0 g/g) and reactor temperature (750– 850 ∘ C ) on the product yields and the compositions of product gas were determined. The experimental results show that the gas yields and the content of H2 in the gas increase with reactor temperature, while the yields of tar, char and the content of CO and CH4 in the product gas decrease. The presence of steam increases the gas yields and reduces the tar and char yields. It is inferred that an in situ steam reforming reaction of tar takes place even in a short gas residence time in the free-fall reactor. Water–gas shift reaction determines greatly the gas compositions and H2 production at higher temperature. The effects of different natural occurring catalysts, limestone, olivine and dolomite, were also investigated in the same unit. Dolomite reveals a comparably good performance in terms of catalytic activity of tar destruction and the consequential increase in the production of gases in thus a short vapor-catalyst contact time. The tars produced were analyzed by FTIR spectrometry. The results verify that the presence of steam and catalyst favors the tar decomposition.

[1]  P. U. Foscolo,et al.  Catalytic gasification of biomass to produce hydrogen rich gas , 1998 .

[2]  José Corella,et al.  Catalytic Hot Gas Cleaning with Monoliths in Biomass Gasification in Fluidized Beds. 3. Their Effectiveness for Ammonia Elimination , 2004 .

[3]  Jun-ichiro Hayashi,et al.  Rapid conversion of tar and char from pyrolysis of a brown coal by reactions with steam in a drop-tube reactor , 2000 .

[4]  Kj Krzysztof Ptasinski,et al.  Catalytic decomposition of biomass tars: use of dolomite and untreated olivine , 2005 .

[5]  Pier Ugo Foscolo,et al.  Decomposition of Wood Particles in Fluidized Beds , 2005 .

[6]  Ralph P. Overend,et al.  Biomass and renewable fuels , 2001 .

[7]  Tomoaki Minowa,et al.  Fundamental design of a continuous biomass gasification process using a supercritical water fluidized bed , 2004 .

[8]  A. Tsutsumi,et al.  Effect of heating rate on steam gasification of biomass. 2. Thermogravimetric-mass spectrometric (TG-MS) analysis of gas evolution , 2003 .

[9]  Shaoping Xu,et al.  Fast pyrolysis of biomass in free-fall reactor for hydrogen-rich gas , 2004 .

[10]  T. A. Milne,et al.  Biomass Gasifier "Tars": Their Nature, Formation, and Conversion , 1998 .

[11]  S. Rapagnà.  Steam-gasification of biomass in a fluidised-bed of olivine particles. , 2000 .

[12]  Chuang-zhi Wu,et al.  Test Results and Operation Performance Analysis of a 1-MW Biomass Gasification Electric Power Generation System , 2003 .

[13]  Hermann Hofbauer,et al.  In-Bed Catalytic Tar Reduction in a Dual Fluidized Bed Biomass Steam Gasifier , 2004 .

[14]  Shaoping Xu,et al.  Steam gasification of apricot stones with olivine and dolomite as downstream catalysts , 2006 .

[15]  Isabel Cabrita,et al.  The study of reactions influencing the biomass steam gasification process , 2003 .

[16]  José Corella,et al.  Biomass Gasification with Steam in Fluidized Bed: Effectiveness of CaO, MgO, and CaO−MgO for Hot Raw Gas Cleaning , 1997 .

[17]  Javier Herguido,et al.  Steam gasification of lignocellulosic residues in a fluidized bed at a small pilot scale. Effect of the type of feedstock , 1992 .

[18]  Wolter Prins,et al.  Principles of a novel multistage circulating fluidized bed reactor for biomass gasification , 2003 .

[19]  José Corella,et al.  Olivine or Dolomite as In-Bed Additive in Biomass Gasification with Air in a Fluidized Bed: Which Is Better? , 2004 .