Durability of compressed and cement-stabilised building blocks

Adequate shelter is a basic human need, yet about 80% of the urban population in developing countries still live in spontaneous settlements as they cannot afford the high cost of building materials. The compressed and stabilised block (CSB) has been identified as a low-cost material with the potential to redress the problem and reverse the shelter backlog. While its other properties are well understood, the durability of the material remains enigmatic. The principal objective of this research was therefore to investigate the durability of CSBs, especially as used in the humid tropics. The thesis examines the interplay between three main factors: constituent materials used (cement, soil, water); quality of block processing methods employed; and the effects of natural exposure conditions (physical, chemical, biological). Through a multi-pronged methodology involving literature reviews, laboratory experiments, petrographic analysis and an exposure condition survey, block properties and behaviour are rigorously investigated. The findings are presented under the two main division of the thesis: Part A and Part B. Part A introduces a review of the literature on the main theoretical concepts of durability and cement-soil stabilisation. It discusses various deterioration modes, and examines in more detail mechanisms of stabilisation using Ordinary Portland cement. Part A also identifies and highlights critical stages of the CSB production cycle, and recommends a strict adherence to proper testing and processing procedures. Part B presents the results of direct investigation methods used. Findings from the fieldwork confirmed that premature deterioration was widespread in exposed unrendered blocks, with defects exhibited mainly as surface erosion and cracking. Quality checks on site materials and practice established an urgent need for improvement through the provision of appropriate standards and codes. Laboratory experiments which compared the properties of traditional blocks (TDB) and blocks improved by the inclusion of micro silica (IPD), established that the latter significantly out-performed the former. A new quick predictive surface test, the slake durability test, which is more reliable and repeatable than existing tests, is proposed. The thesis concludes that it is possible to significantly raise the strength, improve the dimensional stability and wear resistance of CSBs to the extent that they can be safely used in unrendered walls in the humid tropics. This improvement is achieved via better intergranular bonding, reduction in voids and lowered absorption. Using the slake durability test, it is now tenable to freely discriminate, classify, and compare not only blocks but other like materials of any category and storage history as well. New quantitative durability gradings are recommended for future incorporation into CSB standards. The findings are likely to contribute to the widespread use of CSBs. The research, however, also raises a number of new questions which are listed for further work.

[1]  H. Olphen.  An Introduction to Clay Colloid Chemistry , 1977 .

[2]  Rjs Spence,et al.  INTERNATIONAL FORUM ON APPROPRIATE INDUSTRIAL TECHNOLOGY, HELD AT NEW DELHI/ANAND, INDIA ON NOVEMBER 20-30, 1978. APPROPRIATE TECHNOLOGIES FOR SMALL-SCALE PRODUCTION OF CEMENT AND CEMENTITIOUS MATERIALS , 1978 .

[3]  Paul Oliver,et al.  Dwellings: The House Across the World , 1987 .

[4]  Inter-American Housing.  Soil-cement, its use in building , 1964 .

[5]  Raymond L. Sterling,et al.  Earth Sheltered Housing Design , 1985 .

[6]  A. A. Hammond.  Prolonging the life of earth buildings in the tropics , 1973 .

[7]  J. R. Coad.  Lime-stabilised soil building blocks , 1979 .

[8]  J. Gamble.  Durability - Plasticity Classification of Shales and Other Argillaceous Rocks , 1971 .

[9]  E. F. Schumacher,et al.  Small is Beautiful: A Study of Economics as if People Mattered , 1974 .

[10]  T. Akroyd.  Laboratory testing in soil engineering , 1957 .

[11]  J. Kironde.  Dar es Salaam, Tanzania , 2019, The Statesman’s Yearbook Companion.

[12]  Ola Oloidi,et al.  African Traditional Architecture , 1978 .

[13]  Brian Vickers.  Laboratory Work in Soil Mechanics , 1983 .

[14]  Alfred B. Searle,et al.  The Chemistry and Physics of Clays : and other Ceramic Materials , 1934, Nature.

[15]  Christopher Hall,et al.  Water movement in porous building materials—II. Hydraulic suction and sorptivity of brick and other masonry materials , 1980 .

[16]  John S. Scott.  The Penguin Dictionary Of Building , 1986 .

[17]  W. G. Lockett.  Appropriate technology in civil engineering , 1982 .

[18]  Braja M. Das,et al.  Principles of Foundation Engineering , 1984 .

[19]  C. D. Vincent.  The construction industry of Uganda , 1965 .

[20]  J. Norton,et al.  Building with earth. , 1997 .

[21]  池田 安隆,et al.  Sedimentary Rocks , 2019, Dictionary of Geotourism.

[22]  João M.P.Q. Delgado,et al.  Durability of Building Materials and Components , 1980 .

[23]  Harold K. Dancy.  A Manual of Building Construction , 1973 .

[24]  Carl T.F. Ross,et al.  Strength of materials and structures , 1992 .

[25]  Michael Carter,et al.  Correlations of Soil Properties , 1991 .

[26]  Richard Hughes.  Material and structural behaviour of soil constructed walls , 1983 .

[27]  Turhan Y. Erdoğan.  Materials of construction , 2002 .

[28]  Roland Stulz,et al.  Appropriate building materials : a catalogue of potential solutions , 1981 .

[29]  Peter Domone,et al.  Construction materials : their nature and behaviour , 2001 .

[30]  James Marston Fitch,et al.  Primitive Architecture and Climate , 1960 .

[31]  Felicien Van Den Branden,et al.  Plastering Skill and Practice , 1953 .

[32]  Ronald F. Scott,et al.  Principles of soil mechanics , 1963 .

[33]  R. L. Fullerton.  Building construction in warm climates , 1978 .

[34]  J. Franklin,et al.  The slake-durability test , 1972 .

[35]  Anil Agarwal.  Mud, mud : the potential of earth-based materials for Third World housing , 1981 .

[36]  A. Casagrande.  Classification and Identification of Soils , 1948 .

[37]  李幼升,et al.  Ph , 1989 .

[38]  C. Crowe,et al.  Engineering fluid mechanics , 1975 .

[39]  A. Gammie.  Technical assistance programme , 2000 .

[40]  J. H. Bungey,et al.  Testing concrete in structures , 1989 .

[41]  D. J. Naus,et al.  Durability of building materials and components) , 1990 .

[42]  D S Young.  Appropriate technology for developing countries. , 1991, Clinical chemistry.

[43]  B. H. C. Sutton,et al.  Solving Problems in Soil Mechanics , 1986 .

[44]  Robert Fitzmaurice,et al.  Manual on stabilized soil construction for housing , 1958 .

[45]  I. Smith,et al.  Elements of Soil Mechanics , 1990 .

[46]  Nabeel Hamdi,et al.  Housing Without Houses: Participation, Flexibility, Enablement , 1995 .

[47]  J. F. Young,et al.  The Science and Technology of Civil Engineering Materials , 1997 .

[48]  Geoffrey Payne,et al.  Urban Projects Manual , 2000 .

[49]  D. T. Davidson,et al.  LIME FIXATION IN CLAYEY SOILS , 1960 .

[50]  Marisa B.Guaraldo Choguill.  Building materials for low-income housing , 1995 .

[51]  Anne Cloudsley.  Mud, Mud. The Potential of Earth Based Materials for Third World Housing , 1982 .

[52]  Dominic Edward Maxwell Gooding,et al.  Improved processes for the production of soil-cement building blocks , 1994 .

[53]  H. Fathy.  Architecture for the poor , 1973 .

[54]  M. A. Kohler,et al.  Hydrology for engineers , 1958 .

[55]  B Vickers.  LABORATORY WORK IN SOIL MECHANICS. 2ND EDITION , 1983 .

[56]  T. Stambolov,et al.  Porous Building Materials: Materials Science for Architectural Conservation , 1982 .

[57]  W. H. Wischmeier,et al.  Rainfall energy and its relationship to soil loss , 1958 .

[58]  Paul Oliver,et al.  Shelter in Africa , 1971 .

[59]  Martyn S. Ray,et al.  Engineering Experimentation: Ideas, Techniques and Presentation , 1988 .

[60]  Terry Thomas,et al.  DEVELOPMENT TECHNOLOGY UNIT , 2000 .

[61]  R.J.S. Spence,et al.  Predicting the performance of soil-cement as a building material in tropical countries , 1975 .

[62]  D E Gooding,et al.  The Potential of Cement-Stabilised Building Blocks as an Urban Building Material in Developing Countries , 1995 .

[63]  Ken Darrow,et al.  Appropriate Technology Sourcebook: A Guide to Practical Books for Village and Small Community Technology , 1986 .

[64]  F. Lea.  The chemistry of cement and concrete , 1970 .

[65]  Hassan Fathy,et al.  Architecture for the Poor : An Experiment in Rural Egypt , 2000 .

[66]  S. A. Ola,et al.  Durability of soil-cement for building purposes — rain erosion resistance test , 1990 .

[67]  Carl W. Condit,et al.  Architecture for the Poor: An Experiment in Rural Egypt by Hassan Fathy (review) , 1974 .

[68]  R. M. Kenedi,et al.  Standards and Specifications , 1979 .

[69]  Braja M. Das,et al.  Principles of Geotechnical Engineering , 2021 .

[70]  J. Keddie,et al.  Brick Manufacture in Developing Countries , 1980 .

[71]  J. F. R. McIlveen,et al.  Fundamentals of weather and climate , 1991 .

[72]  James Burgess,et al.  LOW COST HOUSING , 1976 .

[73]  M. Swilling,et al.  Johannesburg, South Africa , 1999 .

[74]  R. J. S. Spence,et al.  Building materials in developing countries , 1983 .

[75]  J. Laws,et al.  Measurements of the fall-velocity of water -drops and raindrops , 1941 .

[76]  David John Tudor Webb.  Stabilised soil building blocks , 1988 .

[77]  K. Stewartson.  Mechanics of fluids , 1978, Nature.

[78]  G. Richert.  Swedish Agency for Research Cooperation with Developing Countries , 1979 .

[79]  C. Hall,et al.  Water sorptivity of mortars and concretes: a review , 1989 .

[80]  A. Neville.  Properties of Concrete , 1968 .

[81]  Hugo Houben,et al.  Earth Construction: A Comprehensive Guide , 1994 .