Thermal stress-induced microcracking in building granite

Abstract Microcracking induced by wide fluctuations in temperature affects granite quality and durability, making the stone more vulnerable to decay. Determining the extent of that effect is not always straightforward, however, given the excellent durability of these materials. Four types of construction granite quarried in the region of Madrid, Spain, and frequently used in both the built heritage and in de novo construction (Alpedrete, Cadalso de los Vidrios, Colmenar Viejo and Zarzalejo) were exposed to 42 thermal cycles (105–20 °C; UNE-EN, 14066, 2003). Petrographic and petrophysical properties were analysed using both destructive and non-destructive techniques. Microcracking generated in the granite stones by 42 thermal cycles had barely any impact on their petrophysical properties, which are the parameters normally assessed to establish material quality and durability. Their petrographic properties, which are not generally assessed in this type of studies, were affected, however. This study contends that petrographic analysis is needed to objectively quantify the actual quality and durability of the most highly resistant materials when petrophysical studies are inconclusive. Petrographic and fluorescence microscopy, along with fractography, are among the most prominent techniques for petrographic exploration. Thanks to the deployment of these techniques, mineral microcracking could be monitored throughout the present tests conducted. The microscopic findings revealed substantial micro-textural and microstructural change in and around the granite minerals, which play a prominent role in decay. The findings showed that pre-existing microcracks coalesced and generated further microcracking as decay progressed. Microcracking was most intense in Zarzalejo granite due to its textural characteristics determined by its high feldspar content. Microscopic observation revealed that the microstructure of feldspar minerals, with their crystallographic anisotropies and secondary mineral phases, favoured microcrack development. Zarzalejo granite exhibited lower quality and durability than Colmenar Viejo and Cadalso de los Vidrios granites, which were more resistant to heat treatment.

[1]  M. J. Varas-Muriel,et al.  Alpedrete Granite (spain). A Nomination for the "Global Heritage Stone Resource" Designation , 2015 .

[2]  Bd Thompson,et al.  Quantifying Damage, Saturation and Anisotropy in Cracked Rocks by Inverting Elastic Wave Velocities , 2006 .

[3]  P. Ranjith,et al.  Effect of cooling rate on the mechanical behavior of heated Strathbogie granite with different grain sizes , 2014 .

[4]  Y. Matsukura,et al.  A new technique for non‐destructive field measurement of rock‐surface strength: an application of the Equotip hardness tester to weathering studies , 2007 .

[5]  J. Lindqvist,et al.  The influence of foliation on the fragility of granitic rocks, image analysis and quantitative microscopy , 2003 .

[6]  Luís Guerra Rosa,et al.  Implications of exposure to high temperatures for stone cladding requirements of three Portuguese granites regarding the use of dowel–hole anchoring systems , 2014 .

[7]  G. Horneck,et al.  Survival of lichens and bacteria exposed to outer space conditions – Results of the Lithopanspermia experiments , 2010 .

[8]  Amalendu Sinha,et al.  Thermo-mechanical properties of Indian and other granites , 2008 .

[9]  Abdul Shakoor,et al.  A Laboratory Investigation of the Effects of Cyclic Heating and Cooling, Wetting and Drying, and Freezing and Thawing on the Compressive Strength of Selected Sandstones , 2003 .

[10]  D. Upadhyay.  Alteration of plagioclase to nepheline in the Khariar alkaline complex, SE India: Constraints on metasomatic replacement reaction mechanisms , 2012 .

[11]  Richard Přikryl,et al.  Acoustic Emission Characteristics and Failure of Uniaxially Stressed Granitic Rocks: the Effect of Rock Fabric , 2003 .

[12]  P. Renard,et al.  Hydraulic testing of low-permeability formations A case study in the granite of Cadalso de los Vidrios, Spain , 2009 .

[13]  L. L. Mambou,et al.  Modeling and numerical analysis of granite rock specimen under mechanical loading and fire , 2015 .

[14]  J. Fredrich,et al.  Micromechanics of thermally induced cracking in three crustal rocks , 1986 .

[15]  C. Tanimoto,et al.  An Attempt to Estimate Mechanical Properties of Rocks Using the Equotip Hardness Tester , 2002 .

[16]  M. H. B. Nasseri,et al.  Coupled evolutions of fracture toughness and elastic wave velocities at high crack density in thermally treated Westerly granite , 2007 .

[17]  Hisashi Aoki,et al.  Estimating the unconfined compressive strength of intact rocks from Equotip hardness , 2008 .

[18]  Candan Gokceoglu,et al.  A comparative study on indirect determination of degree of weathering of granites from some physical and strength parameters by two soft computing techniques , 2009 .

[19]  D. Benavente,et al.  Estudio del efecto de los acabados superficiales en granitos y calizas para su aplicación en pavimentos exteriores de baldosas de piedra , 2008 .

[20]  W. Verwaal,et al.  Estimating rock strength with the equotip hardness tester , 1993 .

[21]  D. Fabbri,et al.  Nature and decay effects of urban soiling on granitic building stones , 1995 .

[22]  Rafael Fort,et al.  Evolution in the use of natural building stone in Madrid, Spain , 2013 .

[23]  F. Homand-Etienne,et al.  Behaviour of granites and limestones subjected to slow and homogeneous temperature changes , 1984 .

[24]  Paulo B. Lourenço,et al.  Prediction of the mechanical properties of granites by ultrasonic pulse velocity and Schmidt hammer hardness , 2007 .

[25]  M. S. Hassan,et al.  Characterization of some Egyptian serpentinites used as ornamental stones , 2008 .

[26]  B. Christaras,et al.  Determination of the moduli of elasticity of rocks. Comparison of the ultrasonic velocity and mechanical resonance frequency methods with direct static methods , 1994 .

[27]  F. Heuze,et al.  High-temperature mechanical, physical and Thermal properties of granitic rocks— A review , 1983 .

[28]  C. Casquet,et al.  Episienitas de la Sierra de Guadarrama: un proceso hidrotermal regional de edad Pérmico Inferior ligado al inicio de la extensión alpina , 1996 .

[29]  S. Laubach,et al.  Modeling fracture porosity evolution in dolostone , 2010 .

[30]  R. Siddique,et al.  Damage in granite under heating/cooling cycles and water freeze-thaw condition , 2008 .

[31]  Patricia Warke,et al.  Thermal response characteristics of stone: Implications for weathering of soiled surfaces in urban environments , 1996 .

[32]  A. Tugrul,et al.  The effect of weathering on pore geometry and compressive strength of selected rock types from Turkey , 2004 .

[33]  Luís M.O. Sousa,et al.  Influence of microfractures and porosity on the physico-mechanical properties and weathering of ornamental granites , 2005 .

[34]  H. Yavuz,et al.  Effect of freeze–thaw and thermal shock weathering on the physical and mechanical properties of an andesite stone , 2011 .

[35]  M. J. Varas-Muriel,et al.  Nomination of Zarzalejo Granite, a Spanish Heritage Building Stone, as a “Global Heritage Stone Resource” , 2015 .

[36]  V. Rives,et al.  Weathering and decay of granitic rocks : its relation to their pore network , 2000 .

[37]  H. C. Heard,et al.  Thermal stress cracking in granite , 1989 .

[38]  Nicola Careddu,et al.  The effects of freeze–thaw cycles on the gloss values of polished stone surfaces , 2012 .

[39]  W. R. Dearman,et al.  Engineering grading of weathered granite , 1978 .

[40]  Kevin Hall,et al.  The role of thermal stress fatigue in the breakdown of rock in cold regions , 1999 .

[41]  D. Benavente,et al.  Assessment of the strength of building rocks using signal processing procedures , 2006 .

[42]  Ove Alm,et al.  The influence of microcrack density on the elastic and fracture mechanical properties of Stripa granite , 1985 .

[43]  G. Simmons,et al.  Thermal cycling cracks in three igneous rocks , 1978 .

[44]  M. P. Fiorucci,et al.  Nd:YVO4 laser removal of graffiti from granite. Influence of paint and rock properties on cleaning efficacy , 2012 .

[45]  S. Grab,et al.  The use of the Schmidt Hammer and Equotip for rock hardness assessment in geomorphology and heritage science: a comparative analysis , 2011 .

[46]  C. Moses,et al.  Methods for measuring rock surface weathering and erosion: A critical review , 2014 .

[47]  S. Laubach,et al.  Microfractures: A review , 2014 .

[48]  Miguel Gómez-Heras,et al.  Influence of mineralogy on granite decay induced by temperature increase: Experimental observations and stress simulation , 2015 .

[49]  D. M. Freire,et al.  Heritage Stone 4. The Piedra Berroqueña Region: Candidacy for Global Heritage Stone Province Status , 2015 .

[50]  Jimmy Stigh,et al.  Characterisation of microcracks in the Bohus granite, western Sweden, caused by uniaxial cyclic loading , 2004 .

[51]  Salvador Ivorra,et al.  Temperature influence on the physical and mechanical properties of a porous rock: San Julian's calcarenite , 2013 .

[52]  Bernard Smith,et al.  Impacts of Fire on Stone-Built Heritage , 2009 .

[53]  Bin Liu,et al.  Relationship between anisotropy of P and S wave velocities and anisotropy of attenuation in serpentinite and amphibolite , 1997 .

[54]  R. Fort,et al.  Microcracking of granite feldspar during thermal artificial processes , 2015 .

[55]  Jean Braun,et al.  Modeling postbreakup landscape development and denudational history across the southeast African (Drakensberg Escarpment) margin , 2002 .

[56]  Paulo B. Lourenço,et al.  Compressive Behavior of Granite: Experimental Approach , 2009 .

[57]  S. Chaki,et al.  Influence of thermal damage on physical properties of a granite rock: Porosity, permeability and ultrasonic wave evolutions , 2008 .

[58]  William Prince-Agbodjan,et al.  Temperature Effects on Physical Properties and Mechanical Behavior of Granite: Experimental Investigation of Material Damage , 2008 .

[59]  A. C. Iñigo,et al.  Colour and ultrasound propagation speed changes by different ageing of freezing/thawing and cooling/heating in granitic materials , 2013 .

[60]  Luís Sousa,et al.  Petrophysical properties and durability of granites employed as building stone: a comprehensive evaluation , 2014, Bulletin of Engineering Geology and the Environment.

[61]  A. Tugrul,et al.  Correlation of mineralogical and textural characteristics with engineering properties of selected granitic rocks from Turkey , 1999 .

[62]  J. Wees,et al.  Cenozoic thick-skinned deformation and topography evolution of the Spanish Central System , 2007 .

[63]  R. P. Young,et al.  Bonded-particle modeling of thermally fractured granite , 2008 .

[64]  E. Belousova,et al.  Recycled metaigneous crustal sources for S- and I-type Variscan granitoids from the Spanish Central System batholith: Constraints from Hf isotope zircon composition , 2012 .

[65]  M. Räisänen.  Relationships between texture and mechanical properties of hybrid rocks from the Jaala–Iitti complex, southeastern Finland , 2004 .

[66]  Siegfried Siegesmund,et al.  Physical and Mechanical Properties of Rocks , 2011 .

[67]  Rafael Fort,et al.  Influence of surface heterogeneities of building granite on its thermal response and its potential for the generation of thermoclasty , 2008 .

[68]  S. Kou,et al.  Influence of the mineralogical composition and textural properties on the quality of coarse aggregates , 2004 .

[69]  David J. Mitchell,et al.  Influence of climatically induced cycles in physical weathering , 1998, Quarterly Journal of Engineering Geology.

[70]  Elisa Franzoni,et al.  Artificial weathering of stone by heating , 2013 .

[71]  T. Reuschlé,et al.  The effect of heating on the microstructural evolution of La Peyratte granite deduced from acoustic velocity measurements , 2006 .

[72]  S. Laubach.  A Method to Detect Natural Fracture Strike in Sandstones , 1997 .

[73]  Youqing Chen,et al.  Influence of thermal damage on linear and nonlinear acoustic properties of granite , 2013 .

[74]  P. Basheer,et al.  Near-surface temperature cycling of stone and its implications for scales of surface deterioration , 2011 .

[75]  Weiren Lin.  Permanent strain of thermal expansion and thermally induced microcracking in Inada granite , 2002 .

[76]  R. Fort,et al.  Characterisation of monzogranitic batholiths as a supply source for heritage construction in the northwest of Madrid , 2010 .

[77]  Rafael Fort,et al.  Freeze–thaw fracturing in building granites , 2015 .

[78]  F. Homand-Etienne,et al.  Thermally induced microcracking in granites: characterization and analysis , 1989 .

[79]  Miguel Gómez-Heras.  Procesos y formas de deterioro térmico en piedra natural del patrimonio arquitectónico , 2005 .

[80]  John Coggan,et al.  Petrographic features as an effective indicator for the variation in strength of granites , 2016 .

[81]  Yong-Seok Seo,et al.  Microscopic observation and contact stress analysis of granite under compression , 2002 .

[82]  R. Fort,et al.  Determination of anisotropy to enhance the durability of natural stone , 2011 .

[83]  A. Shakoor,et al.  Relative contribution of various climatic processes in disintegration of clay-bearing rocks , 2009 .

[84]  Francisco J. García Alonso,et al.  Ornamental granites: Relationships between p-waves velocity, water capillary absorption and the crack network , 2010 .

[85]  I. Çemen,et al.  Linking microcracks and mineral zoning of detachment-exhumed granites to their tectonomagmatic history: Evidence from the Salihli and Turgutlu plutons in western Turkey (Menderes Massif) , 2011 .

[86]  F. Scarciglia,et al.  Role of lichens in weathering of granodiorite in the Sila uplands (Calabria, southern Italy) , 2012 .

[87]  T. Taboada,et al.  Pseudomorphic transformation of plagioclases during the weathering of granitic rocks in Galicia (NW Spain) , 1999 .

[88]  Kevin Hall,et al.  Thermal fatigue and thermal shock in bedrock: An attempt to unravel the geomorphic processes and products , 2014 .

[89]  S. Demirdag.  Effects of freezing–thawing and thermal shock cycles on physical and mechanical properties of filled and unfilled travertines , 2013 .

[90]  Rafael Fort,et al.  Surface temperature differences between minerals in crystalline rocks: Implications for granular disaggregation of granites through thermal fatigue , 2006 .