What Advanced Treatments Can Be Used to Minimize the Production of Sewage Sludge in WWTPs?

Similar to other types of waste, sewage sludge (SS) must be minimized, not only to respect the European Directive 2018/851 on waste, but also because the cost of sludge management is approximately 50% of the total running costs of a wastewater treatment plant (WWTP). Usually, minimization technologies can involve sewage sludge production with three different strategies: (i) adopting a process in the water line that reduces the production of sludge; (ii) reducing the water content (dewatering processes) or (iii) reducing the fraction of volatile solids (stabilization). This review, based on more than 130 papers, aims to provide essential information on the process, such as the advantages, the drawbacks and the results of their application. Moreover, significant information on the technologies still under development is provided. Finally, this review reports a discussion on the impact of the application of the proposed processes in the sludge line on a WWTP with a capacity exceeding 100,000 population equivalent (PE).

[1]  Massimiliano Fabbricino,et al.  Dewaterability of CAS and MBR Sludge: Effect of Biological Stability and EPS Composition , 2018 .

[2]  Sharifah Rafidah Wan Alwi,et al.  Optimization of thermo-alkaline disintegration of sewage sludge for enhanced biogas yield. , 2012, Bioresource technology.

[3]  Evangelos Gidarakos,et al.  Options for sustainable sewage sludge management in small wastewater treatment plants on islands: The case of Crete , 2010 .

[4]  Fuli Li,et al.  Diversity of Thermophilic Microorganisms and Their Roles in Carbon Cycle , 2015 .

[5]  Roberto Canziani,et al.  A full-scale plug-flow reactor for biological sludge ozonation. , 2015, Water science and technology : a journal of the International Association on Water Pollution Research.

[6]  Harald Wedwitschka,et al.  Wet Oxidation of Process Waters from the Hydrothermal Carbonization of Sewage Sludge , 2018 .

[7]  M C Samolada,et al.  Comparative assessment of municipal sewage sludge incineration, gasification and pyrolysis for a sustainable sludge-to-energy management in Greece. , 2014, Waste management.

[8]  Guangming Zeng,et al.  Feasibility of bioleaching combined with Fenton oxidation to improve sewage sludge dewaterability. , 2015, Journal of environmental sciences.

[9]  Hongtao Wang,et al.  Influence of pyrolysis temperature on characteristics and heavy metal adsorptive performance of biochar derived from municipal sewage sludge. , 2014, Bioresource technology.

[10]  S. I. Pérez-Elvira,et al.  Sludge minimisation technologies , 2006 .

[11]  M C M van Loosdrecht,et al.  Full scale performance of the aerobic granular sludge process for sewage treatment. , 2015, Water research.

[12]  Magdalena Svanström,et al.  Upgrading small wastewater treatment plants with the sequencing batch biofilter granular reactor technology: Techno-economic and environmental assessment , 2017 .

[13]  D. Eikelboom,et al.  Minimization of excess sludge production for biological wastewater treatment. , 2003, Water research.

[14]  Giorgio Bertanza,et al.  Sewage sludge treatment in a thermophilic membrane reactor (TMR): factors affecting foam formation , 2016, Environmental Science and Pollution Research.

[15]  Giuseppe Mancini,et al.  An integrated wastewater treatment system using a BAS reactor with biomass attached to tubular supports. , 2012, Journal of environmental management.

[16]  E. Chatzisymeon,et al.  Sewage Treatment Plants: Economic Evaluation of Innovative Technologies for Energy Efficiency , 2015 .

[17]  Massimiliano Fabbricino,et al.  Effect of Anaerobic Digestion on Rheological Parameters and Dewaterability of Aerobic Sludges from MBR and Conventional Activated Sludge Plants , 2015 .

[18]  Evan Diamadopoulos,et al.  Biochar production by sewage sludge pyrolysis , 2013 .

[19]  Markéta Kalová,et al.  VORACIOUS LARVAE HERMETIA ILLUCENS AND TREATMENT OF SELECTED TYPES OF BIODEGRADABLE WASTE , 2013 .

[20]  Agostina Chiavola,et al.  Technical and experimental evaluation of an innovative decentralized technology for the municipal wastewater treatment in the city of Rome. , 2010, Water science and technology : a journal of the International Association on Water Pollution Research.

[21]  Shang-Lien Lo,et al.  Application of physico-chemical pretreatment methods to enhance the sludge disintegration and subsequent anaerobic digestion: an up to date review , 2011 .

[22]  Massimo Raboni,et al.  Methodological approach for the optimization of drinking water treatment plants' operation: a case study. , 2015, Water science and technology : a journal of the International Association on Water Pollution Research.

[23]  Saeid Baroutian,et al.  Relative influence of process variables during non-catalytic wet oxidation of municipal sludge. , 2013, Bioresource technology.

[24]  Mary P. Ryan,et al.  Electrodeposited nanometer-size IrO2/Ti electrodes with 0.3 mg IrO2 cm−2 for sludge dewatering electrolysers , 2018 .

[25]  Irina S. Moreira,et al.  Treatment of a simulated wastewater amended with a chiral pharmaceuticals mixture by an aerobic granular sludge sequencing batch reactor , 2016 .

[26]  Oskar Modin,et al.  Microbial Population Dynamics and Ecosystem Functions of Anoxic/Aerobic Granular Sludge in Sequencing Batch Reactors Operated at Different Organic Loading Rates , 2017, Front. Microbiol..

[27]  Massimiliano Fabbricino,et al.  Biological stability and dewaterability of CAS and MBR sludge , 2016 .

[28]  T. Katoh,et al.  Solubilization of excess sludge in activated sludge process using the solar photo-Fenton reaction. , 2009, Journal of hazardous materials.

[29]  J. Werther,et al.  Sewage sludge combustion , 1999 .

[30]  C Di Iaconi,et al.  Municipal wastewater treatment by a periodic biofilter with granular biomass. , 2008, Water science and technology : a journal of the International Association on Water Pollution Research.

[31]  Z. Hildenbrand,et al.  Mass Spectrometry for the Study of Microbial Communities in Environmental Waters , 2017 .

[32]  Mohamed Amin,et al.  Review on hybrid energy systems for wastewater treatment and bio-energy production. , 2016 .

[33]  Anastasia Zabaniotou,et al.  Towards sewage sludge based biofuels via thermochemical conversion – A review , 2012 .

[34]  He Liu,et al.  Evaluation of volatile fatty acids production and dewaterability of waste activated sludge with different thermo-chemical pretreatments , 2018 .

[35]  Vincenzo Torretta,et al.  Overview of the main disinfection processes for wastewater and drinking water treatment plants , 2017 .

[36]  Changyuan Liu,et al.  Electro-dewatering of sewage sludge: Influence of combined action of constant current and constant voltage on performance and energy consumption. , 2019, The Science of the total environment.

[37]  J. Rajesh Banu,et al.  Enhancement of waste activated sludge reduction potential by amalgamated solar photo-Fenton treatment. , 2016 .

[38]  Suli Zhi,et al.  Sewage sludge drying method combining pressurized electro-osmotic dewatering with subsequent bio-drying. , 2018, Bioresource technology.

[39]  Cheng Cheng,et al.  Insight into the roles of packing carriers and ultrasonication in anaerobic side-stream reactor coupled membrane bioreactors: Sludge reduction performance and mechanism. , 2019, Water research.

[40]  G. Viviani,et al.  Biological minimization of excess sludge in a membrane bioreactor: Effect of plant configuration on sludge production, nutrient removal efficiency and membrane fouling tendency. , 2018, Bioresource technology.

[41]  S. Kavitha,et al.  Effect of deflocculation on the efficiency of sludge reduction by Fenton process , 2016, Environmental Science and Pollution Research.

[42]  Willy Verstraete,et al.  Reduced sludge production in a two-stage membrane-assisted bioreactor , 2000 .

[43]  C. M. Hooijmans,et al.  Sludge reduction by ozone: Insights and modeling of the dose-response effects. , 2018, Journal of environmental management.

[44]  Giorgio Bertanza,et al.  How can sludge dewatering devices be assessed? Development of a new DSS and its application to real case studies. , 2014, Journal of environmental management.

[45]  Gang Xue,et al.  Activated sludge ozonation to reduce sludge production in membrane bioreactor (MBR). , 2006, Journal of hazardous materials.

[46]  Giuseppe Laera,et al.  Methodology for technical and economic assessment of advanced routes for sludge processing and disposal , 2014, Environmental Science and Pollution Research.

[47]  Giuseppe Laera,et al.  Effects of sludge retention time on the performance of a membrane bioreactor treating municipal sewage , 2008 .

[48]  G. Erden Kaynak,et al.  Assessment of Fenton Process as a Minimization Technique forBiological Sludge: Effects on Anaerobic Sludge Bioprocessing , 2008 .

[49]  Sayiter Yildiz,et al.  Fenton process effect on sludge disintegration , 2020, International journal of environmental health research.

[50]  Oliver Terna Iorhemen,et al.  Membrane Bioreactor (MBR) Technology for Wastewater Treatment and Reclamation: Membrane Fouling , 2016, Membranes.

[51]  Maria Cristina Collivignarelli,et al.  Gheorghe Asachi ” Technical University of Iasi , Romania RECOVERY OF SEWAGE SLUDGE ON AGRICULTURAL LAND IN LOMBARDY : CURRENT ISSUES AND REGULATORY SCENARIOS , 2015 .

[52]  E. Gaughran.  THE THERMOPHILIC MICROÖRGANISMS , 1947, Bacteriological reviews.

[53]  Giacinto Cornacchia,et al.  Sewage sludge gasification in a bench scale rotary kiln , 2018 .

[54]  F. Akbal,et al.  Classification and Effects of Sludge Disintegration Technologies Integrated Into Sludge Handling Units: An Overview , 2016 .

[55]  Seong-Hoon Yoon,et al.  The optimum operational condition of membrane bioreactor (MBR): cost estimation of aeration and sludge treatment. , 2004, Water research.

[56]  Elena Cristina Rada,et al.  Assessment of Biological Kinetics in a Conventional Municipal WWTP by Means of the Oxygen Uptake Rate Method , 2014 .

[57]  W. A. Barton,et al.  THE ELECTRODEWATERING OF SEWAGE SLUDGES , 1999 .

[58]  Adrian T. Hanson,et al.  Regression Modeling of Ozonation Process in Wastewater Treatment Plants for Reduction of Waste Activated Sludge , 2014 .

[59]  Roberto Canziani,et al.  Electrode surface treatments in sludge electro-osmosis dewatering , 2016 .

[60]  Jérémy Olivier,et al.  A comparative study of electro-dewatering process performance for activated and digested wastewater sludge. , 2018, Water research.

[61]  Giuseppe Mancini,et al.  A wastewater treatment using a biofilm airlift suspension reactor with biomass attached to supports: a numerical model , 2014, International Journal of Environmental Science and Technology.

[62]  Chulhwan Park,et al.  Upgrading of anaerobic digestion by incorporating two different hydrolysis processes. , 2005, Journal of bioscience and bioengineering.

[63]  Alessandro Abbà,et al.  Electrolytic Recovery of Nickel and Copper from Acid Pickling Solutions Used to Treat Metal Surfaces , 2019, Water, Air, & Soil Pollution.

[64]  Krist V. Gernaey,et al.  Resource recovery from organic solid waste using hydrothermal processing: Opportunities and challenges , 2018, Renewable and Sustainable Energy Reviews.

[65]  Hardy Temmink,et al.  Membrane Bioreactor (MBR) as Alternative to a Conventional Activated Sludge System Followed by Ultrafiltration (CAS-UF) for the Treatment of Fischer-Tropsch Reaction Water from Gas-to-Liquids Industries , 2017, Water, Air, & Soil Pollution.

[66]  Brent R. Young,et al.  Hydrothermal degradation of organic matter in municipal sludge using non-catalytic wet oxidation , 2015 .

[67]  Jun Liu,et al.  Exploration on the technology for ozone reduction in urban sewage treatment , 2017 .

[68]  E. Fiałkowska,et al.  The effect of three different predatory ciliate species on activated sludge microfauna. , 2017, European journal of protistology.

[69]  Jens Tränckner,et al.  Optimization and fouling mechanism of a thermophile submerged MBR (TSMBR) pilot plant for wastewater treatment in a paper mill , 2017 .

[70]  Muzammil Anjum,et al.  Wastewater sludge stabilization using pre-treatment methods , 2016 .

[71]  S. Caffaz,et al.  Long-term stability of aerobic granular sludge for the treatment of very low-strength real domestic wastewater , 2019, Journal of Cleaner Production.

[72]  Alessandro Abbà,et al.  Treatments for color removal from wastewater: State of the art. , 2019, Journal of environmental management.

[73]  Giorgio Bertanza,et al.  Treatment of high strength aqueous wastes in a thermophilic aerobic membrane reactor (TAMR): performance and resilience. , 2017, Water science and technology : a journal of the International Association on Water Pollution Research.

[74]  Gianni Andreottola,et al.  Sludge Reduction Technologies in Wastewater Treatment Plants , 2010 .

[75]  Alexandros Kelessidis,et al.  Comparative study of the methods used for treatment and final disposal of sewage sludge in European countries. , 2012, Waste management.

[76]  C Di Iaconi,et al.  A single-stage biological process for municipal sewage treatment in tourist areas. , 2014, Journal of environmental management.

[77]  G. Mannina,et al.  Waste activated sludge dewaterability: comparative evaluation of sludge derived from CAS and MBR systems , 2016 .

[78]  Giorgio Bertanza,et al.  Minimization of municipal sewage sludge by means of a thermophilic membrane bioreactor with intermittent aeration , 2017 .

[79]  Paolo Battistoni,et al.  Two advanced biological approaches for sludge minimization from municipal wastewater treatment , 2016 .

[80]  Magdalena Svanström,et al.  Techno-economic and environmental assessment of upgrading alternatives for sludge stabilization in municipal wastewater treatment plants , 2016 .

[81]  Chao-hai Wei,et al.  Performance of membrane bioreactor (MBR) system with sludge Fenton oxidation process for minimization of excess sludge production. , 2010, Journal of hazardous materials.

[83]  Anastasia Zabaniotou,et al.  Utilization of sewage sludge in EU application of old and new methods--A review , 2008 .

[84]  C Saccani,et al.  Sewage sludge drying process integration with a waste-to-energy power plant. , 2015, Waste management.

[85]  T. Kamiya,et al.  New combined system of biological process and intermittent ozonation for advanced wastewater treatment , 1998 .

[86]  Wenshan Guo,et al.  Sludge cycling between aerobic, anoxic and anaerobic regimes to reduce sludge production during wastewater treatment: performance, mechanisms, and implications. , 2014, Bioresource technology.

[87]  Magdalena Svanström,et al.  Techno-economic and environmental assessment of sewage sludge wet oxidation , 2015, Environmental Science and Pollution Research.

[88]  Jun-Wei Lim,et al.  Enhancement of anaerobic digestibility of waste activated sludge using photo-Fenton pretreatment , 2017, Environmental Science and Pollution Research.

[89]  Ganesh Dattatraya Saratale,et al.  Feasibility analysis of homogenizer coupled solar photo Fenton process for waste activated sludge reduction. , 2019, Journal of environmental management.

[90]  Zhiguo Yuan,et al.  Technologies for reducing sludge production in wastewater treatment plants: State of the art. , 2017, The Science of the total environment.

[91]  Giorgio Bertanza,et al.  Wet Oxidation of sewage sludge: a mathematical model for estimating the performance based on the VSS/TSS ratio , 2016 .

[92]  M C M van Loosdrecht,et al.  Aerobic granular sludge technology: an alternative to activated sludge? , 2004, Water science and technology : a journal of the International Association on Water Pollution Research.

[93]  C. Teodosiu,et al.  A review on wastewater sludge valorisation and its challenges in the context of circular economy , 2019, Journal of Cleaner Production.

[94]  Alnour Bokhary,et al.  Thermophilic membrane bioreactors: A review. , 2017, Bioresource technology.

[95]  J. K. Lee,et al.  Filter Press for Electrodewatering of Waterworks Sludge , 2007 .

[96]  Yaobin Lu,et al.  Performance of a combined system of microbial fuel cell and membrane bioreactor: wastewater treatment, sludge reduction, energy recovery and membrane fouling. , 2013, Biosensors & bioelectronics.

[97]  Xiaobo Liu,et al.  Characteristics of Biochemical and Fractal Structure of Activated Sludge with Thermochemical Lysis , 2017, Water, Air, & Soil Pollution.

[98]  A Pollice,et al.  Zero net growth in a membrane bioreactor with complete sludge retention. , 2005, Water research.

[99]  Giorgio Bertanza,et al.  Wet oxidation of sewage sludge: full-scale experience and process modeling , 2015, Environmental Science and Pollution Research.

[100]  Lidia Lombardi,et al.  Environmental comparison of alternative treatments for sewage sludge: An Italian case study. , 2017, Waste management.

[101]  Sebastian Werle,et al.  Analysis of the combustion and pyrolysis of dried sewage sludge by TGA and MS. , 2014, Waste management.

[102]  N. Ren,et al.  Minimization of excess sludge production by in-situ activated sludge treatment processes--a comprehensive review. , 2013, Biotechnology advances.

[103]  J. R. Portela,et al.  Enhancement of methane production in mesophilic anaerobic digestion of secondary sewage sludge by advanced thermal hydrolysis pretreatment. , 2015, Water research.

[104]  Serkan Şahinkaya,et al.  Disintegration of waste activated sludge by different applications of Fenton process , 2015 .

[105]  K. Keiding,et al.  Dewatering in biological wastewater treatment: A review. , 2015, Water research.

[106]  Vincenzo Torretta,et al.  Environmental and economic aspects of water kiosks: case study of a medium-sized Italian town. , 2013, Waste management.

[107]  Andrea Turolla,et al.  Environmental and economic assessment of electro-dewatering application to sewage sludge: A case study of an Italian wastewater treatment plant , 2019, Journal of Cleaner Production.

[108]  Xu Wu,et al.  Effects of temperature variation on wastewater sludge electro-dewatering , 2019, Journal of Cleaner Production.

[109]  C. Gagnon,et al.  Microbiological aspects of aerobic thermophilic treatment of swine waste , 1990, Applied and environmental microbiology.

[110]  M. Azuara,et al.  Sewage sludge pyrolysis for liquid production: A review , 2012 .

[111]  V. Garg,et al.  Stabilization of primary sewage sludge during vermicomposting. , 2008, Journal of hazardous materials.

[112]  H. Itokawa,et al.  Demonstration of energy-saving membrane bioreactor (MBR) systems. , 2019, Water science and technology : a journal of the International Association on Water Pollution Research.

[113]  J. Andrews,et al.  Acetic acid recovery from a hybrid biological-hydrothermal treatment process of sewage sludge - a pilot plant study. , 2015, Water science and technology : a journal of the International Association on Water Pollution Research.

[114]  J. A. Menéndez,et al.  On the pyrolysis of sewage sludge: the influence of pyrolysis conditions on solid, liquid and gas fractions , 2002 .

[115]  Giorgio Bertanza,et al.  Treatment of sewage sludge in a thermophilic membrane reactor (TMR) with alternate aeration cycles. , 2015, Journal of environmental management.

[116]  Cosmin Copot,et al.  Performance and stability of a dynamically controlled EBPR anaerobic/aerobic granular sludge reactor. , 2019, Bioresource technology.

[117]  Changzhu Yang,et al.  Stability of aerobic granular sludge in a pilot scale sequencing batch reactor enhanced by granular particle size control. , 2019, Chemosphere.

[118]  Jian Sun,et al.  Thermodynamics and kinetics parameters of co-combustion between sewage sludge and water hyacinth in CO2/O2 atmosphere as biomass to solid biofuel. , 2016, Bioresource technology.

[119]  Roberto Ramadori,et al.  SBBGR technology for minimising excess sludge production in biological processes. , 2010, Water research.

[120]  Yoshinori Kawase,et al.  Photo-Fenton process for excess sludge disintegration , 2007 .

[121]  Michele Torregrossa,et al.  Comparison between ozonation and the OSA process: analysis of excess sludge reduction and biomass activity in two different pilot plants. , 2012, Water science and technology : a journal of the International Association on Water Pollution Research.

[122]  José Ferrer,et al.  The operating cost of an anaerobic membrane bioreactor (AnMBR) treating sulphate-rich urban wastewater , 2014 .

[123]  Onur Atak,et al.  Co-combustion of sewage sludge from different treatment processes and a lignite coal in a laboratory scale combustor , 2018, Energy.

[124]  Anurag Garg,et al.  Performance of non-catalytic thermal hydrolysis and wet oxidation for sewage sludge degradation under moderate operating conditions. , 2019, Journal of environmental management.

[125]  Giuseppe Mancini,et al.  Effect of Powdered Activated Carbon to Reduce Fouling in Membrane Bioreactors: A Sustainable Solution. Case Study , 2013 .

[126]  Iskender Gökalp,et al.  Pyrolysis, combustion and gasification characteristics of miscanthus and sewage sludge. , 2015 .

[127]  Hiroko Yoshida,et al.  Reducing Viscosity of Thickened Waste Activated Sludge, Improving Dewaterability of Digested Sludge, and Increasing Biogas Production through Thermochemical Hydrolysis Process , 2017 .

[128]  Giorgio Bertanza,et al.  Why use a thermophilic aerobic membrane reactor for the treatment of industrial wastewater/liquid waste? , 2015, Environmental technology.