Nafion® Tubing Humidification System for Polymer Electrolyte Membrane Fuel Cells

Humidity and temperature have an essential influence on PEM fuel cell system performance. The water content within the polymeric membrane is important for enhancing proton conduction and achieving high efficiency of the system. The combination of non-stationary operation requests and the variability of environment conditions poses an important challenge to maintaining optimal membrane hydration. This paper presents a humidification and thermal control system, to prevent the membrane from drying. The main characteristics of such a device are small size and weight, compactness and robustness, easy implementation on commercial fuel cell, and low power consumption. In particular, the NTHS method was studied in a theoretical approach, tested and optimized in a laboratory and finally applied to a PEMFC of 1 kW that supplied energy for the prototype vehicle IDRA at the Shell Eco-Marathon competition. Using a specific electronic board, which controls several variables and decides the optimal reaction air flow rate, the NTHS was managed. Furthermore, the effects of membrane drying and electrode flooding were presented.

[1]  Hubert A. Gasteiger,et al.  Proton Conduction and Oxygen Reduction Kinetics in PEM Fuel Cell Cathodes: Effects of Ionomer-to-Carbon Ratio and Relative Humidity , 2009 .

[2]  Massimiliana Carello,et al.  Transient thermal analysis of a lithium-ion battery pack comparing different cooling solutions for automotive applications , 2017 .

[3]  Thomas F. Fuller,et al.  The effect of humidity and oxygen partial pressure on degradation of Pt/C catalyst in PEM fuel cell , 2009 .

[4]  Massimiliana Carello,et al.  Method for Increasing the Humidity in Polymer Electrolyte Membrane Fuel Cell , 2016 .

[5]  Soosan Rowshanzamir,et al.  Effects of operating parameters on performance of a proton exchange membrane fuel cell , 2006 .

[6]  Massimiliana Carello,et al.  Modeling Li-ion batteries for automotive application: A trade-off between accuracy and complexity , 2017, 2017 International Conference of Electrical and Electronic Technologies for Automotive.

[7]  Massimiliana Carello,et al.  Carbon fiber monocoque for a hydrogen prototype for low consumption challenge , 2010 .

[8]  P. Ekdunge,et al.  Proton Conductivity of Nafion 117 as Measured by a Four‐Electrode AC Impedance Method , 1996 .

[9]  Adam Z. Weber,et al.  Resistor-Network Modeling of Ionic Conduction in Polymer Electrolytes , 2015 .

[10]  Anna G. Stefanopoulou,et al.  Control-Oriented Modeling and Analysis for Automotive Fuel Cell Systems , 2004 .

[11]  Abdellatif Miraoui,et al.  Air management in PEM fuel cells: State-of-the-art and prospectives , 2007 .

[12]  Hui Li,et al.  PEM fuel cell relative humidity (RH) and its effect on performance at high temperatures , 2008 .

[13]  Massimiliana Carello,et al.  IDRApegasus: a fuel-cell prototype for 3000 km/L , 2015 .

[14]  Massimiliana Carello,et al.  Innovative and Multidisciplinary Teaching Through the Design and Construction of Low Consumption Vehicles for International Competitions , 2018, New Trends in Educational Activity in the Field of Mechanism and Machine Theory.

[15]  Massimiliana Carello,et al.  Steering System of a Low-Consumption Vehicle: From the Dynamics Analysis to the Design of the Wheel Assembly , 2018, Mechanisms and Machine Science.

[16]  Federico Millo,et al.  Design of the control strategy for a range extended hybrid vehicle by means of dynamic programming optimization , 2017, 2017 IEEE Intelligent Vehicles Symposium (IV).

[17]  Roberto Guerrieri,et al.  Alternative Efficiency Test Protocol for Lithium-Ion Battery , 2018, 2018 IEEE International Conference on Environment and Electrical Engineering and 2018 IEEE Industrial and Commercial Power Systems Europe (EEEIC / I&CPS Europe).

[18]  Massimiliana Carello,et al.  Design and optimisation of XAM 2.0 plug-in powertrain , 2017 .

[19]  Massimiliana Carello,et al.  IDRApegasus: a carbon fiber monocoque vehicle prototype , 2014 .

[20]  Aldo Bischi,et al.  The Impact of Humidification Temperature on a 1 kW Proton Exchange Membrane Fuel Cell Stack , 2017 .

[21]  Harvey G. Stenger,et al.  Flow rate and humidification effects on a PEM fuel cell performance and operation , 2007 .

[22]  T. Ohsaka,et al.  Exploring the effects of symmetrical and asymmetrical relative humidity on the performance of H2/air PEM fuel cell at different temperatures , 2007 .

[23]  Moo Hwan Kim,et al.  Role of water states on water uptake and proton transport in Nafion using molecular simulations and bimodal network , 2010 .

[24]  Thomas F. Fuller,et al.  The effect of humidity on the degradation of Nafion® membrane , 2009 .