Small embedded sensors for accurate temperature measurements in DMOS power transistors

Device temperature is one of the most important limits for the safe operating area and the reliability of power DMOS transistors. Therefore, accurate measurements of their intrinsic device temperature are required. However, standard methods such as IR thermography usually cannot be applied to advanced smart power technologies where a thick power metal layer obscures the - often significantly hotter - active device area. Thus, we propose to embed very small temperature sensors in the active DMOS cell array. These sensors allow for an accurate reading of the intrinsic device temperature while not influencing the DMOS behavior noticeably. The sensors are calibrated up to 600°C, validated by comparison to TIM measurements up to 400°C, and used to investigate thermal runaway. Results from 60 sensors embedded in one large power DMOS with on-chip analog multiplexing are also presented.

[1]  Martin Pfost,et al.  Measurement and Simulation of Self-Heating in DMOS Transistors up to Very High Temperatures , 2008, 2008 20th International Symposium on Power Semiconductor Devices and IC's.

[2]  Kunihiro Asada,et al.  -1/+0.8°C Error, Accurate Temperature Sensor using 90nm 1V CMOS for On-line Thermal Monitoring of VLSI circuits , 2006 .

[3]  Sergey Bychikhin,et al.  Scanning heterodyne interferometer setup for the time-resolved thermal and free-carrier mapping in semiconductor devices , 2005, IEEE Transactions on Instrumentation and Measurement.

[4]  K. Asada,et al.  -1/+0.8/spl deg/C error, accurate temperature sensor using 90nm 1V CMOS for on-line thermal monitoring of VLSI circuits , 2006, 2006 IEEE International Conference on Microelectronic Test Structures.

[5]  Hans-Martin Rein,et al.  Influence of impact-ionization-induced instabilities on the maximum usable output voltage of Si-bipolar transistors , 2001 .

[6]  Gerhard K. M. Wachutka,et al.  Testing semiconductor devices at extremely high operating temperatures , 2008, Microelectron. Reliab..

[7]  V. Parthasarathy,et al.  Detection and optimization of temperature distribution across large-area power MOSFETs to improve energy capability , 2004, IEEE Transactions on Electron Devices.

[8]  B.H. Krabbenborg,et al.  Robustness of LDMOS power transistors in SOI-BCD processes and derivation of design rules using thermal simulation , 2001, Proceedings of the 13th International Symposium on Power Semiconductor Devices & ICs. IPSD '01 (IEEE Cat. No.01CH37216).

[9]  H. Grubin.  The physics of semiconductor devices , 1979, IEEE Journal of Quantum Electronics.

[10]  M. Stecher,et al.  Analysis and modeling of DMOS FBSOA limited by n-p-n leakage diffusion current , 2005, Proceedings. ISPSD '05. The 17th International Symposium on Power Semiconductor Devices and ICs, 2005..

[11]  A. Irace,et al.  Fast transient infrared thermal analysis of smart Power MOSFETS in permanent short circuit operation , 2006, 2006 IEEE International Symposium on Power Semiconductor Devices and IC's.

[12]  P. Dobson.  Physics of Semiconductor Devices (2nd edn) , 1982 .

[13]  Sergey Bychikhin,et al.  Thermal imaging of smart power DMOS transistors in the thermally unstable regime using a compact transient interferometric mapping system , 2009, Microelectron. Reliab..