Plant Application of a T-Junction as a Partial Phase Separator

It is considered good practice for a distillation column with a two-phase (vapour/liquid) feed to separate the phases and feed them into the column at different points. The phase separation is normally effected in a cylindrical vessel. The cost of design, construction and installation of such a vessel is not trivial. This paper presents an alternative, more economical approach to tackle the task. It utilizes the maldistribution of the phases that occur when a gas/liquid stream is divided at a T-junction. The design approach adopted to specify the geometrical parameters of the junction and surrounding pipework is described. Post installation tests, which were carried on the equipment to verify its correct operation, are also reported. The plant management are delighted with the operation of the equipment.

[1]  A. Dukler,et al.  A model for predicting flow regime transitions in horizontal and near horizontal gas‐liquid flow , 1976 .

[2]  P. Andreussi,et al.  A physically based correlation for drop size in annular flow , 1991 .

[3]  B. Azzopardi.  THE SPLIT OF ANNULAR-MIST FLOWS AT VERTICAL AND HORIZONTAL TS , 1989 .

[4]  B. J. Azzopardi,et al.  Drop sizes in annular two-phase flow , 1985 .

[5]  J. Teixeira,et al.  Detailed Measurements of Vertical Annular Two-Phase Flow—Part I: Drop Velocities and Sizes , 1994 .

[6]  T. Bott,et al.  The influence of a bend on drop sizes in horizontal annular two-phase flow , 2001 .

[7]  T. J. Hanratty,et al.  Droplet flux distributions and entrainment in horizontal gas-liquid flows , 1996 .

[8]  T. J. Hanratty,et al.  Droplet size measurements in horizontal annular gas–liquid flow , 2001 .

[9]  G. F. Hewitt,et al.  Phenomenological modelling of non-equilibrium flows with phase change , 1990 .

[10]  John S. McNown,et al.  Mechanics of Manifold Flow , 1954 .

[11]  R. A. Mugele,et al.  Droplet Size Distribution in Sprays , 1951 .

[12]  Mamoru Ishii,et al.  Generation and Size Distribution of Droplet in Annular Two-Phase Flow , 1983 .

[13]  Thomas J. Hanratty,et al.  Rates of atomization and deposition in vertical annular flow , 1990 .

[14]  T. J. Hanratty,et al.  Relation of deposition to drop size when the rate law is nonlinear , 1996 .

[15]  Barry J. Azzopardi.  The split of vertical annular flow at a large diameter T junction , 1994 .

[16]  A. E. Dukler,et al.  The distribution of drop size and velocity in gas-liquid annular flow , 1995 .