Monotonic and cyclic short beam shear response of 3D woven composites

Monotonic, multi-step and cyclic short beam shear tests were conducted on 2D and 3D woven composites. The test results were used to determine the effect of z-yarns on the inter-laminar shear strength as well as the multi-loading behavior. The presence of z-yarns was found to affect not only the inter-laminar shear strength of the composite but also the behavior of the composite beyond the elastic limit. Microscopic examination of the damaged specimens revealed large delamination cracks in 2D woven composites while delamination cracks were hindered by z-yarns in 3D composites. This crack arrest phenomena resulted in a reduction in inter-laminar crack lengths and a higher distribution of the micro-cracks throughout the 3D composite. The multi-step and cyclic loading tests are found to be useful in the monitoring of specimen behavior during short beam shear testing. The induced damage was quantified in terms of the loss of strength and stiffness during each loading cycle. It was found that while the 2D composites have higher damage resistance, the 3D composites have a higher damage tolerance.

[1]  L. Ye,et al.  Influence of Fiber-Matrix Adhesion on Mechanical Properties of Graphite/Epoxy Composites: II. Interlaminar Fracture and Inplane Shear Behavior , 1999 .

[2]  Grant P. Steven,et al.  Behavior of 3D orthogonal woven CFRP composites. Part I. Experimental investigation , 2000 .

[3]  Grant P. Steven,et al.  Behavior of 3D orthogonal woven CFRP composites. Part II. FEA and analytical modeling approaches , 2000 .

[4]  P. Ifju,et al.  Investigation of Fracture Toughness of Laminated Stitched Composites Subjected to Mixed Mode Loading , 2010 .

[5]  Adrian P. Mouritz,et al.  Review of z-pinned composite laminates , 2007 .

[6]  B. Sankar,et al.  Damage modes in 3D glass fiber epoxy woven composites under high rate of impact loading , 2009 .

[7]  Adrian P. Mouritz,et al.  Review of applications for advanced three-dimensional fibre textile composites , 1999 .

[8]  J. Gillespie,et al.  Toughness properties of a three-dimensional carbon-epoxy composite , 1989 .

[9]  J. Whitney,et al.  On short-beam shear tests for composite materials , 1985 .

[10]  C. Sun,et al.  Interlaminar Shear Strength and Fracture Behavior in Aged Composite Laminates , 1998 .

[11]  Jun Zhang,et al.  Interlaminar shear strength of polycarbonate‐toughened epoxy composites reinforced with glass rovings , 2003 .

[12]  K. Schulte,et al.  Mode I and mode II fracture toughness of E-glass non-crimp fabric/carbon nanotube (CNT) modified polymer based composites , 2008 .

[13]  Liyong Tong,et al.  3D Fibre Reinforced Polymer Composites , 2002 .

[14]  N. K. Naik,et al.  Ballistic impact behaviour of thick composites: Parametric studies , 2008 .

[15]  S. Sharma,et al.  Effects of through-the-thickness stitching on impact and interlaminar fracture properties of textile graphite/epoxy laminates , 1995 .

[16]  Y. Mai,et al.  Numerical and experimental studies on the fracture behavior of rubber-toughened epoxy in bulk specimen and laminated composites , 2002 .

[17]  Adrian P. Mouritz,et al.  Ballistic impact and explosive blast resistance of stitched composites , 2001 .

[18]  Michael H. Santare,et al.  Comparison of the short beam shear (SBS) and interlaminar shear device (ISD) tests , 1997 .

[19]  K. Shivakumar,et al.  Modified Short Beam Shear Test for Measurement of Interlaminar Shear Strength of Composites , 2003 .

[20]  Brian N. Cox,et al.  Mechanisms of compressive failure in 3D composites , 1992 .

[21]  J. Reeder.  Stitching vs. a Toughened Matrix: Compression Strength Effects , 1995 .

[22]  Bhavani V. Sankar,et al.  Effect of Z-yarns on the stiffness and strength of three-dimensional woven composites , 2009 .

[23]  A. Mouritz.  Tensile fatigue properties of 3D composites with through-thickness reinforcement , 2008 .

[24]  Israel Herszberg,et al.  Effect of weaving damage on the tensile properties of three-dimensional woven composites , 2002 .

[25]  B. N. Cox,et al.  The Macroscopic Elasticity of 3D Woven Composites , 1995 .

[26]  J. Gillespie,et al.  Punch shear based penetration model of ballistic impact of thick-section composites , 2008 .

[27]  Kishore,et al.  Interlaminar shear of woven fabric Kevlar-epoxy composites in three-point loading , 1995 .