Developments in Gigascale Silicon Optical Modulators Using Free Carrier Dispersion Mechanisms

This paper describes the recent advances made in silicon optical modulators employing the free carrier dispersion effect, specifically those governed by majority carrier dynamics. The design, fabrication, and measurements for two different devices are discussed in detail. We present an MOS capacitor-based modulator delivering 10 Gbps data with an extinction ratio of ∼ 4 dB and a pn-diode-based device with high-speed transmission of 40 Gbps and bandwidth greater than 30 GHz. Device improvements for achieving higher extinction ratios, as required for certain applications, are also discussed. These devices are key components of integrated silicon photonic chips which could enable optical interconnects in future terascale processors.

[1]  M. Morse,et al.  High speed silicon Mach-Zehnder modulator. , 2005, Optics express.

[2]  M. Paniccia,et al.  A high-speed silicon optical modulator based on a metal–oxide–semiconductor capacitor , 2004, Nature.

[3]  Alexander Fang,et al.  Net continuous wave optical gain in a low loss silicon-on-insulator waveguide by stimulated Raman scattering. , 2005, Optics express.

[4]  Saurabh Dighe,et al.  An 80-Tile 1.28TFLOPS Network-on-Chip in 65nm CMOS , 2007, 2007 IEEE International Solid-State Circuits Conference. Digest of Technical Papers.

[5]  R. Mooney,et al.  A 20Gb/s Forwarded Clock Transceiver in 90nm CMOS B. , 2006, 2006 IEEE International Solid State Circuits Conference - Digest of Technical Papers.

[6]  M. Morse,et al.  31 GHz Ge n-i-p waveguide photodetectors on Silicon-on-Insulator substrate. , 2007, Optics express.

[7]  Bahram Jalali,et al.  Demonstration of 11dB fiber-to-fiber gain in a silicon Raman amplifier , 2004, IEICE Electron. Express.

[8]  T. Shoji,et al.  Microphotonics devices based on silicon microfabrication technology , 2005, IEEE Journal of Selected Topics in Quantum Electronics.

[9]  R. Iga,et al.  A 40-gb/s InGaAlAs-InAlAs MQW n-i-n Mach-Zehnder Modulator with a drive Voltage of 2.3 V , 2005, IEEE Photonics Technology Letters.

[10]  James E. Jaussi,et al.  A Scalable 5–15 Gbps, 14–75 mW Low-Power I/O Transceiver in 65 nm CMOS , 2008, IEEE Journal of Solid-State Circuits.

[11]  Graham T. Reed,et al.  Coupling to nanophotonic waveguides using a dual grating-assisted directional coupler , 2005 .

[12]  J. Bowers,et al.  Electrically pumped hybrid AlGaInAs-silicon evanescent laser. , 2006, Optics express.

[13]  Guo Liang Li,et al.  A 10Gb/s photonic modulator and WDM MUX/DEMUX integrated with electronics in 0.13µm SOI CMOS , 2006, ISSCC.

[14]  M. Lipson,et al.  Nanotaper for compact mode conversion. , 2003, Optics letters.

[15]  J. Denton,et al.  Multiple layers of silicon-on-insulator islands fabrication by selective epitaxial growth , 1999, IEEE Electron Device Letters.

[16]  Michal Lipson,et al.  Demonstration of high Raman gain in a submicrometer-size silicon-on-insulator waveguide. , 2005, Optics letters.

[17]  Manfred Berroth,et al.  High bandwidth Ge p-i-n photodetector integrated on Si , 2006 .

[18]  M. Paniccia,et al.  Net optical gain in a low loss silicon-on-insulator waveguide by stimulated Raman scattering. , 2004, Optics express.

[19]  Efficient Mode Converter for Coupling between Fiber and Micrometer Size Silicon Waveguides , 2007, 2007 4th IEEE International Conference on Group IV Photonics.

[20]  R. Walker.  High-speed III-V semiconductor intensity modulators , 1991 .

[21]  O. Mitomi,et al.  Millimeter-wave Ti:LiNbO/sub 3/ optical modulators , 1998 .

[22]  C. E. Png,et al.  A sub-micron depletion-type photonic modulator in Silicon On Insulator. , 2005, Optics express.

[23]  Graham T. Reed,et al.  Highly efficient optical phase modulator in SOI waveguides , 1995 .

[24]  A. Knights,et al.  Silicon Photonics: An Introduction , 2004 .

[25]  Nahum Izhaky,et al.  High-speed optical modulation based on carrier depletion in a silicon waveguide. , 2007, Optics express.

[26]  Alfred Grill,et al.  Germanium-on-insulator photodetectors , 2005 .

[27]  F. Gan,et al.  High-speed silicon electrooptic Modulator design , 2005, IEEE Photonics Technology Letters.

[28]  R. Soref,et al.  Electrooptical effects in silicon , 1987 .

[29]  Qianfan Xu,et al.  12.5 Gbit/s carrier-injection-based silicon micro-ring silicon modulators. , 2007, Optics express.

[30]  R. Soref,et al.  All-silicon active and passive guided-wave components for λ = 1.3 and 1.6 µm , 1986 .

[31]  D. Samara-Rubio,et al.  Scaling the modulation bandwidth and phase efficiency of a silicon optical modulator , 2005, IEEE Journal of Selected Topics in Quantum Electronics.

[32]  Qianfan Xu,et al.  Micrometre-scale silicon electro-optic modulator , 2005, Nature.

[33]  Ying-Hao Kuo,et al.  High efficiency wavelength conversion of 10 Gb/s data in silicon waveguides. , 2006, Optics express.

[34]  L. Liao,et al.  Optical transmission losses in polycrystalline silicon strip waveguides: Effects of waveguide dimensions, thermal treatment, hydrogen passivation, and wavelength , 2000 .

[35]  Bahram Jalali,et al.  Demonstration of a silicon Raman laser. , 2004, Optics express.

[36]  Juthika Basak,et al.  High-Speed Silicon Modulator for Future VLSI Interconnect , 2007 .

[37]  R. Mooney,et al.  A Scalable 5-15Gbps, 14-75mW Low Power I/O Transceiver in 65nm CMOS , 2007, 2007 IEEE Symposium on VLSI Circuits.

[38]  R. Alferness.  Waveguide Electrooptic Modulators , 1982 .

[39]  M. Paniccia,et al.  A continuous-wave Raman silicon laser , 2005, Nature.

[40]  O. Hansen,et al.  Strained silicon as a new electro-optic material , 2006, Nature.

[41]  D. Miller,et al.  Strong quantum-confined Stark effect in germanium quantum-well structures on silicon , 2005, Nature.

[42]  Y. Vlasov,et al.  C-band wavelength conversion in silicon photonic wire waveguides. , 2005, Optics express.

[43]  M. Salib,et al.  Phase modulation efficiency and transmission loss of silicon optical phase shifters , 2005, IEEE Journal of Quantum Electronics.

[44]  T. Shoji,et al.  All-optical efficient wavelength conversion using silicon photonic wire waveguide , 2006, IEEE Photonics Technology Letters.