Numerical modelling of dynamic sludge blanket behaviour in secondary clarifiers.

New developments in numerical modelling of turbulent and density-affected flow in secondary clarifiers are reported. The sludge blanket is included in the computation domain which allows us to account for sedimentation and resuspension of sludge as well as the growth and diminution of the sludge blanket and at the same time respecting mass conservation. It is shown how strongly the prediction of the sludge-blanket height depends on the approaches to describe the settling behaviour of the sludge and the rheological properties within the sludge blanket. Further, an example of dynamic simulation is presented and discussed. This demonstrates how the sludge blanket behaves during load variation and that instabilities may occur at the interface of sludge blanket and supernatant, potentially resulting in sludge wash-off during transient phases, which is not only during load increase but also during load decrease.

[1]  John A. McCorquodale,et al.  Modeling of Rectangular Settling Tanks , 1992 .

[2]  Peter Krebs.  The Hydraulics of Final Settling Tanks , 1991 .

[3]  John A. McCorquodale,et al.  Effects of hydraulic and solids loading on clarifier performance , 1993 .

[4]  James L. Barnard,et al.  Secondary settling tanks : theory, modelling, design and operation , 1997 .

[5]  Bruce A. DeVantier,et al.  Modeling Sediment‐Induced Density Currents in Sedimentation Basins , 1988 .

[6]  W. Rodi,et al.  Finite volume methods for two-dimensional incompressible flows with complex boundaries , 1989 .

[7]  Peter Krebs,et al.  Computing Shear Flow and Sludge Blanket in Secondary Clarifiers , 1999 .

[8]  C. Kranenburg,et al.  Effects of Gravity Currents in Circular Secondary Clarifiers , 1994 .

[9]  John A. McCorquodale,et al.  Secondary clarifier analysis using data from the Clarifier Research Technical Committee protocol , 1997 .

[10]  Wolfgang Rodi,et al.  Density Currents and Shear-Induced Flocculation in Sedimentation Tanks , 1992 .

[11]  H. L. Stone.  ITERATIVE SOLUTION OF IMPLICIT APPROXIMATIONS OF MULTIDIMENSIONAL PARTIAL DIFFERENTIAL EQUATIONS , 1968 .

[12]  Torben Larsen,et al.  NUMERICAL MODELLING AND MEASUREMENT IN A TEST SECONDARY SETTLING TANK , 1994 .

[13]  B. Launder,et al.  The numerical computation of turbulent flows , 1990 .

[14]  J. K. Bewtra,et al.  INFLUENCE OF MECHANICAL BLENDING ON AEROBIC DIGESTION OF WASTE ACTIVATED SLUDGE , 1973 .

[15]  Peter Krebs,et al.  Influence of inlet and outlet configuration on the flow in secondary clarifiers , 1996 .

[16]  J. A. McCorquodale,et al.  Short Circuiting and Density Interface in Primary Clarifiers , 1994 .

[17]  R. Dick,et al.  The rheology of activated sludge. , 1967, Journal - Water Pollution Control Federation.

[18]  Peter A. Wilderer,et al.  Velocity and solids distribution in circular secondary clarifiers: Full scale measurements and numerical modelling , 1998 .

[19]  I. Takács.  A dynamic model of the clarification-thickening process , 1991 .

[20]  P. Bradshaw,et al.  Turbulence Models and Their Application in Hydraulics. By W. RODI. International Association for Hydraulic Research, Delft, 1980. Paperback US $15. , 1983, Journal of Fluid Mechanics.

[21]  Peter Krebs,et al.  Laboratory experiments of buoyancy-influenced flow in clarifiers , 1998 .

[22]  Peter Krebs,et al.  Improvement of Flow in Final Settling Tanks , 1992 .