Hydrodynamic modelling of dense gas-fluidised beds: Comparison of the kinetic theory of granular flow with 3D hard-sphere discrete particle simulations

A novel technique to sample particle velocity distributions and collision characteristics from dynamic discrete particle simulations of intrinsically unsteady, non-homogeneous systems, such as those encountered in dense gas-fluidised beds, is presented. The results are compared to the isotropic Maxwellian particle velocity distribution and the impact velocity distribution that constitute the zeroth-order Enskog approximation for the kinetic theory of granular flow. Excellent agreement with the kinetic theory is obtained for elastic particles. The individual particle velocity distribution function is isotropic and Maxwellian. A good fit of the collision velocity distribution and frequency is obtained, using the radial distribution function proposed by Carnahan and Starling (J. Chem. Phys. 51 (1969) 635). However, for inelastic and rough particles an anisotropic Maxwellian velocity distribution is obtained. It is concluded that the formation of dense particle clusters disturbs spatial homogeneity and results in collisional anisotropy. Analysis of the impact velocity shows that, in dense gas-fluidised beds, not all impact angles are of equal likelihood. The observed anisotropy becomes more pronounced with increasing degree of inelasticity of the particles.

[1]  V. Swaaij,et al.  Hydrodynamic modeling of dense gas-fluidised beds using the kinetic theory of granular flow: effect of coefficient of restitution on bed dynamics , 2000 .

[2]  T. G. Cowling,et al.  The mathematical theory of non-uniform gases , 1939 .

[3]  J.A.M. Kuipers,et al.  Computational fluid dynamics applied to chemical reaction engineering , 1998 .

[4]  R. L. Braun,et al.  Viscosity, granular‐temperature, and stress calculations for shearing assemblies of inelastic, frictional disks , 1986 .

[5]  B. Alder,et al.  Studies in Molecular Dynamics. II. Behavior of a Small Number of Elastic Spheres , 1960 .

[6]  Jam Hans Kuipers,et al.  Hydrodynamic Modeling of Gas/Particle Flows in Riser Reactors , 1996 .

[7]  B. Hoomans.  Granular dynamics of gas-solid two-phase flows , 2000 .

[8]  S. Ogawa,et al.  On the equations of fully fluidized granular materials , 1980 .

[9]  M. Goldschmidt,et al.  Hydrodynamic Modelling of Fluidised Bed Spray Granulation , 2001 .

[10]  Goodarz Ahmadi,et al.  An equation of state for dense rigid sphere gases , 1986 .

[11]  J. Jenkins,et al.  Plane simple shear of smooth inelastic circular disks: the anisotropy of the second moment in the dilute and dense limits , 1988, Journal of Fluid Mechanics.

[12]  R. L. Braun,et al.  Stress calculations for assemblies of inelastic speres in uniform shear , 1986 .

[13]  J. Jenkins,et al.  A theory for the rapid flow of identical, smooth, nearly elastic, spherical particles , 1983, Journal of Fluid Mechanics.

[14]  J. Jenkins.  Boundary Conditions for Rapid Granular Flow: Flat, Frictional Walls , 1992 .

[15]  H. Grad.  On the kinetic theory of rarefied gases , 1949 .

[16]  Michel Y. Louge,et al.  Measurements of the collision properties of small spheres , 1994 .

[17]  R. Bagnold.  Experiments on a gravity-free dispersion of large solid spheres in a Newtonian fluid under shear , 1954, Proceedings of the Royal Society of London. Series A. Mathematical and Physical Sciences.

[18]  J. N. Fawcett,et al.  The Role of Elastic Tangential Compliance in Oblique Impact , 1981 .

[19]  W.P.M. van Swaaij,et al.  Hydrodynamic modelling of gas-solid two-phase flows , 1995 .

[20]  K. E. Starling,et al.  Equation of State for Nonattracting Rigid Spheres , 1969 .

[21]  Olivier Simonin,et al.  Large Eddy Simulation and Second-Moment Closure Model of Particle Fluctuating Motion in Two-Phase Turbulent Shear Flows , 1995 .

[22]  Mihail C. Roco,et al.  Particulate two-phase flow , 1993 .

[23]  D. Jeffrey,et al.  Kinetic theories for granular flow: inelastic particles in Couette flow and slightly inelastic particles in a general flowfield , 1984, Journal of Fluid Mechanics.

[24]  David J. Jeffrey,et al.  The stress tensor in a granular flow at high shear rates , 1981, Journal of Fluid Mechanics.

[25]  D. Gidaspow,et al.  A bubbling fluidization model using kinetic theory of granular flow , 1990 .

[26]  Larry Smarr,et al.  A numerical study of nonspherical black hole accretion. II: Finite differencing and code calibration , 1984 .

[27]  D. Gidaspow.  Multiphase Flow and Fluidization: Continuum and Kinetic Theory Descriptions , 1994 .

[28]  H. Enwald,et al.  Eulerian two-phase flow theory applied to fluidization , 1996 .

[29]  J. Centrella,et al.  Planar numerical cosmology. II. The difference equations and numerical tests , 1984 .

[30]  M. Richman.  The Source of Second Moment in Dilute Granular Flows of Highly Inelastic Spheres , 1989 .

[31]  A. A. Bent,et al.  Numerical simulation of inelastic frictional spheres in simple shear flow , 1994, Journal of Fluid Mechanics.

[32]  Harold Grad,et al.  Asymptotic Theory of the Boltzmann Equation , 1963 .

[33]  J. Kuipers,et al.  Discrete particle simulation of bubble and slug formation in a two-dimensional gas-fluidised bed: A hard-sphere approach. , 1996 .

[34]  Ailing Gong,et al.  The stress tensor in a two-dimensional granular shear flow , 1986, Journal of Fluid Mechanics.

[35]  James Clerk Maxwell,et al.  IV. On the dynamical theory of gases , 1868, Philosophical Transactions of the Royal Society of London.

[36]  Tron Solberg,et al.  An experimental and computational study of multiphase flow behavior in a circulating fluidized bed , 2000 .

[37]  S. Savage.  Streaming motions in a bed of vibrationally fluidized dry granular material , 1988, Journal of Fluid Mechanics.