Early-age acoustic emission measurements in hydrating cement paste: Evidence for cavitation during solidification due to self-desiccation

In this study, the acoustic emission activity of cement pastes was investigated during the first day of hydration. Deaired, fresh cement pastes were cast in sealed sample holders designed to minimize friction and restraint. The majority of acoustic emission events occurred in lower water to cement ratio pastes, while cement pastes with higher water to cement ratios showed significantly less acoustic activity. These acoustic events occurred around the time of setting. A layer of water on the surface of the cement pastes substantially reduced acoustic emission activity at the time of setting. According to these experimental results, the acoustic emission measured around setting time was attributed to cavitation events occurring in the pores of the cement paste due to self-desiccation. This paper shows how acoustic emission might be used to indicate the time when the fluid-solid transition occurs in a cement paste, often referred to as time-zero. Knowledge of time-zero is fundamental for determining when mechanical properties develop and in calculations of residual stresses.

[1]  T. A. Hammer.  Test Methods for Linear Measurement of Autogenous Shrinkage before Setting , 1998 .

[2]  W. Jason Weiss,et al.  Using acoustic emission to quantify damage in restrained fiber-reinforced cement mortars , 2003 .

[3]  Frank Winnefeld,et al.  The microstructure of dispersed and non-dispersed fresh cement pastes : New insight by cryo-microscopy , 2008 .

[4]  Sidney Mindess,et al.  Acoustic Emission in the Drying of Hardened Cement Paste and Mortar , 1981 .

[5]  Surendra P. Shah,et al.  DAMAGE ASSESSMENT IN CONCRETE USING QUANTITATIVE ACOUSTIC EMISSION , 1991 .

[6]  M. Minnaert.  XVI.On musical air-bubbles and the sounds of running water , 1933 .

[7]  C. T. Peters,et al.  Acoustic emission activity during accelerated conversion of high alumina cement pastes , 1977 .

[8]  T. Chotard,et al.  Acoustic emission characterisation of calcium aluminate cement hydration at an early stage , 2003 .

[9]  Per Freiesleben Hansen,et al.  Autogenous deformation and RH-change in perspective , 2001 .

[10]  Gaurav Sant,et al.  A discussion of analysis approaches for determining time-zero from chemical shrinkage and autogenous strain measurements in cement paste , 2006 .

[11]  Bradley Justin Pease,et al.  Quantifying Volume Change, Stress Development, and Cracking Due to Self-Desiccation , 2004 .

[12]  Jeffrey W. Bullard,et al.  Detecting the Fluid-to-Solid Transition in Cement Pastes , 2009 .

[13]  Pietro Lura,et al.  Use of acoustic emission to detect cavitation and solidification (time zero) in cement pastes , 2006 .

[14]  Timothy G. Leighton,et al.  Bubble population phenomena in acoustic cavitation , 1995 .

[15]  Thierry Chotard,et al.  Application of the acoustic emission technique to characterise liquid transfer in a porous ceramic during drying , 2006 .

[16]  E. Garboczi,et al.  Percolation and pore structure in mortars and concrete , 1994 .

[17]  M. Arrington,et al.  Acoustic emission testing of high alumina cement concrete , 1977 .

[18]  Pietro Lura,et al.  Measurement of Volume Change in Cementitious Materials at Early Ages: Review of Testing Protocols and Interpretation of Results , 2006 .

[19]  J. Weiss.  Experimental determination of the 'Time Zero', t0 ('Maturity-Zero', M0) , 2003 .

[20]  Acoustic Emission (AE) and Nonlinear Elastic Wave Spectroscopy (NEWS) for Online Monitoring of Concrete Curing , 2006 .

[21]  Pietro Lura,et al.  Influence of Shrinkage-Reducing Admixtures on Development of Plastic Shrinkage Cracks , 2007 .

[22]  V. R. Skal’s’kyi,et al.  Investigation of the Solidification of Concrete According to the Signals of Acoustic Emission , 2004 .

[23]  J. Weiss,et al.  Cracking in cement paste induced by autogenous shrinkage , 2009 .

[24]  M. Tyree,et al.  Ultrasonic acoustic emissions from the sapwood of cedar and hemlock : an examination of three hypotheses regarding cavitations. , 1984, Plant physiology.

[25]  J. Kaufmann.  EXPERIMENTAL IDENTIFICATION OF ICE FORMATION IN SMALL CONCRETE PORES , 2004 .

[26]  M. Minnarert,et al.  Musical air-bubbles and the sound of running water , 1933 .

[27]  K. Mørch.  Cavitation Nuclei and Bubble Formation—A Dynamic Liquid-Solid Interface Problem , 2000 .

[28]  P. Lura,et al.  Measuring techniques for autogenous strain of cement paste , 2007 .