Solar-assisted multi-stage vacuum membrane distillation system with heat recovery unit

Abstract This paper describes the development of a solar-assisted multi-stage vacuum membrane distillation (SMVMD) system. The proposed system employs heat recovery unit (HRU) for the energy recovery from the permeate vapor to the feed seawater. Temperature modulating (TM) scheme is also implemented for the attenuation of temperature fluctuations of the feed seawater. A commercial shell-and-tube capillary membrane module consisting of an array of polypropylene hydrophobic fibers has been adopted for the system design and mathematical model development. The SMVMD system is studied for the different numbers of HRUs using a mathematical model. For a solar-assisted VMD system with 24-stage, the total water production of SMVMD system with 10 HRUs is found to be 3.37 m 3 /day, which is about 34% higher as compared to the system with a single HRU. For a VMD system without solar-thermal unit, the overall specific thermal energy consumption ( OSTEC ) decreases by 20% with an increase in the number of HRUs from 1 to 10. For the different numbers of HRUs in the range of 1–10, the system OSTECs with solar-thermal system having 150 m 2 of evacuated-tube collectors and 16 m 3 seawater storage tanks are 28%–36% lower compared to those without the solar thermal system.

[1]  Tsung-Ching Chen,et al.  Immediate assisted solar direct contact membrane distillation in saline water desalination , 2010 .

[2]  Corinne Cabassud,et al.  Evaluation of systems coupling vacuum membrane distillation and solar energy for seawater desalination , 2011 .

[3]  V. Gnielinski.  New equations for heat and mass transfer in turbulent pipe and channel flow , 1976 .

[4]  Hemaunt Kumar,et al.  THE PLATE HEAT EXCHANGER: CONSTRUCTION AND DESIGN , 1984 .

[5]  Noam Lior,et al.  Membrane-distillation desalination: Status and potential , 2005 .

[6]  M. C. García-Payo,et al.  Treatment of olive mill wastewater by membrane distillation using polytetrafluoroethylene membranes , 2012 .

[7]  M. Sillanpää,et al.  Membrane purification in radioactive waste management: a short review. , 2012, Journal of environmental radioactivity.

[8]  E. Drioli,et al.  Potential of membrane distillation in seawater desalination: Thermal efficiency, sensitivity study and cost estimation , 2008 .

[9]  M. Khayet,et al.  Heat and mass transfer in vacuum membrane distillation , 2004 .

[10]  Noreddine Ghaffour,et al.  Performance modeling of direct contact membrane distillation (DCMD) seawater desalination process using a commercial composite membrane , 2015 .

[11]  H. G. Groehn.  INFLUENCE OF THE YAW ANGLE ON HEAT TRANSFER AND PRESSURE DROP OF TUBE BUNDLE HEAT EXCHANGERS , 1982 .

[12]  Chien-Chang Li,et al.  Modeling and optimization of a solar driven membrane distillation desalination system , 2010 .

[13]  C. S. Bhatia,et al.  Thermal analysis and performance optimization of a solar hot water plant with economic evaluation , 2012 .

[14]  Minh H. Nguyen,et al.  Shell-side mass transfer of hollow fibre modules in osmotic distillation process , 2007 .

[15]  L. Martinez-diez,et al.  Temperature and concentration polarization in membrane distillation of aqueous salt solutions , 1999 .

[16]  Paul R. Ehrlich,et al.  Human Appropriation of Renewable Fresh Water , 1996, Science.

[17]  C. G. Broyden.  A Class of Methods for Solving Nonlinear Simultaneous Equations , 1965 .

[18]  Sudjito,et al.  Desalination by solar heated membrane distillation , 1991 .

[19]  C. Cabassud,et al.  Membrane distillation for water desalination: how to chose an appropriate membrane? , 2003 .

[20]  Guillermo Zaragoza,et al.  Efficiency in the use of solar thermal energy of small membrane desalination systems for decentralized water production , 2014 .

[21]  Julián Blanco,et al.  Experimental evaluation of two pilot-scale membrane distillation modules used for solar desalination , 2012 .

[22]  D. R. Lloyd,et al.  Membrane distillation. I. Module design and performance evaluation using vacuum membrane distillation , 1996 .

[23]  Lourdes García-Rodríguez,et al.  Seawater desalination by an innovative solar-powered membrane distillation system: the MEDESOL project. , 2009 .

[24]  Mohamed Khayet,et al.  Treatment of radioactive wastewater solutions by direct contact membrane distillation using surface modified membranes , 2013 .

[25]  Samer Adham,et al.  Application of Membrane Distillation for desalting brines from thermal desalination plants , 2013 .

[26]  P. Lettieri,et al.  An introduction to heat transfer , 2007 .

[27]  Giulio C. Sarti,et al.  Low temperature distillation through hydrophobic membranes , 1987 .

[28]  Noreddine Ghaffour,et al.  Performance investigation of a solar-assisted direct contact membrane distillation system , 2013 .

[29]  M. Qtaishat,et al.  Desalination by solar powered membrane distillation systems , 2013 .

[30]  Noreddine Ghaffour,et al.  Synthesis and fabrication of nanostructured hydrophobic polyazole membranes for low-energy water recovery , 2012 .

[31]  J. Lienhard,et al.  Erratum to Thermophysical properties of seawater: A review of existing correlations and data , 2010 .

[32]  Julián Blanco,et al.  Experimental analysis of an air gap membrane distillation solar desalination pilot system , 2011 .

[33]  Saeed M. Al-Zahrani,et al.  Portable and integrated solar-driven desalination system using membrane distillation for arid remote areas in Saudi Arabia , 2014 .

[34]  Junghui Chen,et al.  Enhanced air gap membrane desalination by novel finned tubular membrane modules , 2011 .

[35]  Mohamed Khayet,et al.  A framework for better understanding membrane distillation separation process , 2006 .