Vanadium redox flow batteries application to electric buses propulsion: Performance analysis of hybrid energy storage system

Abstract This paper presents a comparison between different battery energy storage systems (ESS) suitable for an urban electric bus. The investigation starts from a daily energy consumption analysis of a bus route in term of batteries state of charge (SOC). Specifically, three different ESS configurations are modelled basing on experimental data: LiFePO4 battery pack, LiFePO4 battery coupled with PEM fuel cell stack and a hybrid battery system composed by LiFePO4 and vanadium redox flow batteries (VRFBs). Moreover, authors provide an evaluation about the battery life through the application of the rainflow-counting algorithm on the yearly SOC trends of each system. As result, the proposed analysis highlights the favorable effect on the ESS due to the introduction of VRFB in the system. The improvements are found both on the net daily operating hours (one hour longer than the conventional case) and on the life expectancy of the LiFePO4 battery (over 9 years, with a gain factor of 5). The obtained results can be considered as a starting point for a wider study focused both on the ESS sizing and on the routes planning of a city buses fleet.

[1]  V. P. C. Dassanayake,et al.  Designing standalone hybrid energy systems minimizing initial investment, life cycle cost and pollutant emission , 2013 .

[2]  F. V. P. Robinson,et al.  Analysis of Battery Lifetime Extension in a Small-Scale Wind-Energy System Using Supercapacitors , 2013, IEEE Transactions on Energy Conversion.

[3]  Andrius Vilkauskas,et al.  Performance of an all-electric vehicle under UN ECE R101 test conditions: A feasibility study for the city of Kaunas, Lithuania , 2013 .

[4]  Antti Lajunen,et al.  Energy consumption and cost-benefit analysis of hybrid and electric city buses , 2014 .

[5]  Bruno Sareni,et al.  Design methodologies for sizing a battery bank devoted to a stand-alone and electronically passive wind turbine system , 2016 .

[6]  Yifeng Li,et al.  Optimal Sizing of Vanadium Redox Flow Battery Systems for Residential Applications Based on Battery Electrochemical Characteristics , 2016 .

[7]  Maria Skyllas-Kazacos,et al.  Adaptive estimation of state of charge and capacity with online identified battery model for vanadium redox flow battery , 2016 .

[8]  A. García-Olivares,et al.  Transportation in a 100% renewable energy system , 2018 .

[9]  Randall Guensler,et al.  Electric vehicles: How much range is required for a day’s driving? , 2011 .

[10]  O. Veneri,et al.  Experimentation with a ZEBRA plus EDLC based hybrid storage system for urban means of transport , 2015, 2015 International Conference on Electrical Systems for Aircraft, Railway, Ship Propulsion and Road Vehicles (ESARS).

[11]  Miguel A. Figliozzi,et al.  An economic and technological analysis of the key factors affecting the competitiveness of electric commercial vehicles: A case study from the USA market , 2013 .

[12]  Luis Marroyo,et al.  Improvement of a control strategy for PV power ramp-rate limitation using the inverters: Reduction of the associated energy losses , 2016 .

[13]  Qi Zhang,et al.  A methodology for economic and environmental analysis of electric vehicles with different operational conditions , 2013 .

[14]  Maria Skyllas-Kazacos,et al.  Online state of charge and model parameter co-estimation based on a novel multi-timescale estimator for vanadium redox flow battery , 2016 .

[15]  Ottorino Veneri,et al.  Experimental study on the performance of a ZEBRA battery based propulsion system for urban commercial vehicles , 2017 .

[16]  Chris Manzie,et al.  Fuel economy improvements for urban driving : Hybrid vs. intelligent vehicles , 2007 .

[17]  Laurencas Raslavičius,et al.  Electric vehicles challenges and opportunities: Lithuanian review , 2015 .

[18]  B. Scrosati,et al.  Lithium batteries: Status, prospects and future , 2010 .

[19]  Stephen Potter,et al.  Developing a viable electric bus service: The Milton Keynes demonstration project , 2014 .

[20]  José L. Bernal-Agustín,et al.  Multi-objective optimization minimizing cost and life cycle emissions of stand-alone PV–wind–diesel systems with batteries storage , 2011 .

[21]  Emanuela Colombo,et al.  The role of electrical energy storage in sub-Saharan Africa , 2016 .

[22]  Ali Emadi,et al.  Modern electric, hybrid electric, and fuel cell vehicles : fundamentals, theory, and design , 2009 .

[23]  C. Roth,et al.  Degradation of all-vanadium redox flow batteries (VRFB) investigated by electrochemical impedance and X-ray photoelectron spectroscopy: Part 2 electrochemical degradation , 2016 .

[24]  C. Dustmann.  Advances in ZEBRA batteries , 2004 .

[25]  José L. Bernal-Agustín,et al.  Optimisation of energy supply at off-grid healthcare facilities using Monte Carlo simulation , 2016 .

[26]  Mark Ferguson,et al.  Electric buses: A review of alternative powertrains , 2016 .

[27]  Jie Bao,et al.  Studies on dynamic responses and impedance of the vanadium redox flow battery , 2019, Applied Energy.

[28]  Ran Wei,et al.  Optimizing the spatio-temporal deployment of battery electric bus system , 2018 .

[29]  Jing-Quan Li,et al.  Battery-electric transit bus developments and operations: A review , 2016 .

[30]  King Jet Tseng,et al.  A multi-timescale estimator for battery state of charge and capacity dual estimation based on an online identified model , 2017 .

[31]  Daniel Kirschen,et al.  Factoring the Cycle Aging Cost of Batteries Participating in Electricity Markets , 2018, 2018 IEEE Power & Energy Society General Meeting (PESGM).

[32]  Nigel P. Brandon,et al.  Comparative analysis of battery electric, hydrogen fuel cell and hybrid vehicles in a future sustainable road transport system , 2010 .

[33]  Malcolm McCulloch,et al.  Modeling the prospects of plug-in hybrid electric vehicles to reduce CO2 emissions , 2011 .

[34]  George A. Hoffman.  ELECTRIC BUS DESIGNS FOR URBAN TRANSPORTATION , 1972 .

[35]  Remus Teodorescu,et al.  Lifetime investigations of a lithium iron phosphate (LFP) battery system connected to a wind turbine for forecast improvement and output power gradient reduction , 2011 .

[36]  Guangzhong Dong,et al.  Online Estimation of Power Capacity With Noise Effect Attenuation for Lithium-Ion Battery , 2019, IEEE Transactions on Industrial Electronics.

[37]  N. Schofield,et al.  Battery and supercapacitor combination for a series hybrid electric vehicle , 2010 .

[38]  Linda Barelli,et al.  Optimization of a PEMFC/battery pack power system for a bus application , 2012 .

[39]  Jinwhan Kim,et al.  Nano carbon/fluoroelastomer composite bipolar plate for a vanadium redox flow battery (VRFB) , 2017 .

[40]  Antti Lajunen,et al.  Powertrain design alternatives for electric city bus , 2012, 2012 IEEE Vehicle Power and Propulsion Conference.

[41]  Min Zhang,et al.  Analysis of battery lifetime extension in a SMES-battery hybrid energy storage system using a novel battery lifetime model , 2015 .

[42]  Rodolfo Dufo-López,et al.  Techno-economic assessment of an off-grid PV system for developing regions to provide electricity for basic domestic needs: A 2020–2040 scenario , 2016 .