The vortex effect of Francis turbine in electric power generation

In this study, the vibration effects of a vortex that occurred in high-head Francis turbines and an alternator are examined. The vortex effect, which directly affects the efficiency and the quality of the energy, was tested at the DarOoΩca-1 hydroelectric power plant (HPP) located in Ordu Province, Turkey. Formed by undissolved oxygen in the water, the vortex effect, which is parallel to the alternator load, causes tremendous vibration within the alternator and Francis turbine bearings. This problem, which has a direct negative effect on the alternator capacity, was solved by adding an air-admission system. In doing so, power production was increased by 11.11%, from 44 MW to 49.5 MW. This caused a significant head loss, specifically in the Francis turbines. Vortex optimization was successfully established at the Darica-1 HPP.

[1]  James M. Montgomery,et al.  Water Treatment Principles and Design , 1985 .

[2]  Okan Ozgonenel,et al.  Wavelet Transform Based Protection of Stator Faults in Synchronous Generators , 2007 .

[3]  Brane Širok,et al.  Simultaneous study of pressure pulsation and structural fluctuations of a cavitated vortex core in the draft tube of a Francis turbine , 2003 .

[4]  Sebastian Muntean,et al.  Experimental investigations of the unsteady flow in a Francis turbine draft tube cone , 2010 .

[5]  Sebastian Muntean,et al.  Development of a Swirling Flow Control Technique for Francis Turbines Operated at Partial Discharge , 2007 .

[6]  Fotis Sotiropoulos,et al.  Numerical Simulation of Swirling Flow in Complex Hydroturbine Draft Tube Using Unsteady Statistical Turbulence Models , 2005 .

[7]  G. Degremont.  Mémento technique de l'eau , 1972 .

[8]  F. Avellan,et al.  Analysis of the Cavitating Draft Tube Vortex in a Francis Turbine Using Particle Image Velocimetry Measurements in Two-Phase Flow , 2008 .

[9]  F. Avellan,et al.  Analysis and Prevention of Vortex Breakdown in the Simplified Discharge Cone of a Francis Turbine , 2010 .

[10]  王正伟,et al.  Dynamic Stresses in a Francis Turbine Runner Based on Fluid-Structure Interaction Analysis , 2008 .

[11]  François Avellan,et al.  Identification and Modeling of Pressure Fluctuations of a Francis Turbine Scale Model at Part Load Operation , 2004 .

[12]  J. Gulliver,et al.  Oxygen transfer similitude for vented hydroturbine , 1997 .

[13]  Christophe Nicolet,et al.  On the upper part load vortex rope in Francis turbine: Experimental investigation , 2010 .

[14]  Alin Bosioc,et al.  Unsteady pressure measurements and numerical investigation of the jet control method in a conical diffuser with swirling flow , 2010 .

[15]  Mehmet Uzunoğlu,et al.  A power quality monitoring system based on MATLAB Server Pages , 2010 .