Atmospheric entrained-flow gasification of biomass and lignite for decentralized applications

Abstract The present study deals with the development of a small-scale entrained-flow gasification technology for the decentral use of biomass. Gasification experiments with woody biomass in a wide range of particle diameters dS in the fractions 0.04  A short review of studies prepared for entrained-flow gasification of biomass since 2006 points out the state of the art and most important findings. The concentrations of H2, CO, CO2 and N2 together with carbon conversion, cold gas efficiency and syngas yield resulting from the present work are reported and compared to the respective literature values. Carbon conversion, cold gas efficiency, and specific syngas volume varied strongly with temperature and particle diameter showing values between 63 and 100 wt%, 14 and 61%, and 0.6 and 1.4 m3 kg− 1 (STP), respectively. With the present set up, high cold gas efficiencies were only obtained at temperatures of 1100 °C and particle sizes of less than 0.2 mm. Particle residence times in the gasifier were measured at 25 °C for three sawdust fractions and varied between 1.4 and 3.3 s. These measurements indicate that the particle residence time is not equal to the gas residence time in general. A model for the calculation of particle velocities and residence times at ambient and gasification conditions is presented. The interrelationships between particle residence time, particle diameter, carbon conversion, and temperature are discussed.

[1]  J. J. Hernández,et al.  Gasification and co-gasification of biomass wastes : Effect of the biomass origin and the gasifier operating conditions , 2008 .

[2]  S. Bhattacharya,et al.  Fuel particle conversion of pulverized biomass during pyrolysis in an entrained flow reactor , 2012 .

[3]  Eric Loth,et al.  Drag of non-spherical solid particles of regular and irregular shape , 2008 .

[4]  Kj Krzysztof Ptasinski,et al.  Biomass upgrading by torrefaction for the production of biofuels: A review , 2011 .

[5]  W. Klose,et al.  On the intrinsic reaction rate of biomass char gasification with carbon dioxide and steam , 2005 .

[6]  A. Faaij,et al.  Efficiency and economy of wood-fired biomass energy systems in relation to scale regarding heat and power generation using combustion and gasification technologies , 2001 .

[7]  Sunggyu Lee,et al.  Liquid phase methanol and dimethyl ether synthesis from syngas , 2005 .

[8]  Hermann Hofbauer,et al.  In-Bed Catalytic Tar Reduction in a Dual Fluidized Bed Biomass Steam Gasifier , 2004 .

[9]  S. Salvador,et al.  Impact of torrefaction on syngas production from wood , 2009 .

[10]  Peter Arendt Jensen,et al.  High-temperature entrained flow gasification of biomass , 2012 .

[11]  Lei Cai,et al.  Influence of particle size on pyrolysis and gasification performance of municipal solid waste in a fixed bed reactor. , 2010, Bioresource technology.

[12]  Robert C. Brown,et al.  Ancillary equipment for biomass gasification , 2002 .

[13]  P K Senapati,et al.  Experimental investigation on an entrained flow type biomass gasification system using coconut coir dust as powdery biomass feedstock. , 2012, Bioresource technology.

[14]  Yan Zhang,et al.  Peculiarities of rapid pyrolysis of biomass covering medium-and high-temperature ranges , 2006 .

[15]  Anders Nordin,et al.  Entrained flow gasification of torrefied wood residues , 2014 .

[16]  A. Faaij,et al.  Exploration of the possibilities for production of Fischer Tropsch liquids and power via biomass gasification , 2002 .

[17]  Sylvain Salvador,et al.  Influence of H2O, CO2 and O-2 addition on biomass gasification in entrained flow reactor conditions: Experiments and modelling , 2016 .

[18]  S. Mani,et al.  Impact of torrefaction on the grindability and fuel characteristics of forest biomass. , 2011, Bioresource technology.

[19]  S. Salvador,et al.  Influence of steam on gasification of millimetric wood particles in a drop tube reactor: Experiments and modelling , 2013 .

[20]  S. Rapagnà,et al.  Steam gasification of almond shells in a fluidised bed reactor: the influence of temperature and particle size on product yield and distribution , 1997 .

[21]  F. Weiland,et al.  Influence of process parameters on the performance of an oxygen blown entrained flow biomass gasifier , 2015 .

[22]  D. Fletcher,et al.  A CFD based combustion model of an entrained flow biomass gasifier , 2000 .

[23]  A. Bula,et al.  Gasification of biomass wastes in an entrained flow gasifier: Effect of the particle size and the residence time , 2010 .

[24]  Wei Hsin Chen,et al.  A comparison of gasification phenomena among raw biomass, torrefied biomass and coal in an entrained-flow reactor , 2013 .

[25]  J. Spivey,et al.  Heterogeneous catalytic synthesis of ethanol from biomass-derived syngas. , 2007, Chemical Society reviews.

[26]  Ke Qin,et al.  Biomass Gasification Behavior in an Entrained Flow Reactor: Gas Product Distribution and Soot Formation , 2012 .

[27]  Kj Krzysztof Ptasinski,et al.  More efficient biomass gasification via torrefaction , 2006 .

[28]  Zhong-yang Luo,et al.  Influence of torrefaction pretreatment on biomass gasification technology , 2011 .

[29]  Alban Kitous,et al.  Transformation Patterns of the Worldwide Energy System -Scenarios for the Century with the POLES Model , 2010 .

[30]  Coal gasification characteristics in a downer reactor , 2001 .

[31]  I. Bjerle,et al.  Fast pyrolysis of sawdust in an entrained flow reactor , 1989 .

[32]  M. Asadullah.  Biomass gasification gas cleaning for downstream applications: A comparative critical review , 2014 .

[33]  F. Pinto,et al.  Effect of experimental conditions on co-gasification of coal, biomass and plastics wastes with air/steam mixtures in a fluidized bed system☆ , 2003 .

[34]  Yijun Zhao,et al.  Experimental study on sawdust air gasification in an entrained-flow reactor , 2010 .

[35]  Juan J. Hernández,et al.  Characterisation of tars from biomass gasification: effect of the operating conditions. , 2013 .

[36]  Eliseo Ranzi,et al.  Biomass pyrolysis: kinetic modelling and experimental validation under high temperature and flash heating rate conditions. , 2009 .

[37]  Andrew Narvaez,et al.  Biomass gasification with air in an atmospheric bubbling fluidized bed. Effect of six operational variables on the quality of the produced raw gas , 1996 .

[38]  P. Agrawal,et al.  Effect of Temperature, Pressure, and Residence Time on Pyrolysis of Pine in an Entrained Flow Reactor , 2014 .

[39]  Myung Won Seo,et al.  Gasification Characteristics of Coal/Biomass Blend in a Dual Circulating Fluidized Bed Reactor , 2010 .

[40]  Henry Hedman,et al.  Pressurized oxygen blown entrained flow gasification of a biorefinery lignin residue , 2013 .

[41]  Wei Wei,et al.  A short review of heterogeneous catalytic process for mixed alcohols synthesis via syngas , 2009 .

[42]  Shiro Kajitani,et al.  Tar destruction and coke formation during rapid pyrolysis and gasification of biomass in a drop-tube furnace , 2010 .

[43]  G. Aranda,et al.  Effect of steam content in the air–steam flow on biomass entrained flow gasification , 2012 .

[44]  S. Bhattacharya,et al.  Coupling of a distributed activation energy model with particle simulation for entrained flow pyrolysis of biomass , 2015 .

[45]  Ronald W. Breault,et al.  Gasification Processes Old and New: A Basic Review of the Major Technologies , 2010 .

[47]  M. Götz,et al.  Review on methanation – From fundamentals to current projects , 2016 .

[48]  Keigo Matsumoto,et al.  Gasification of oil palm residues (empty fruit bunch) in an entrained-flow gasifier , 2013 .

[49]  M. Massoudi,et al.  Slag Behavior in Gasifiers. Part I: Influence of Coal Properties and Gasification Conditions , 2013 .

[50]  Charlotte K. Williams,et al.  The Path Forward for Biofuels and Biomaterials , 2006, Science.

[51]  Yijun Zhao,et al.  Characteristics of rice husk gasification in an entrained flow reactor. , 2009, Bioresource technology.

[52]  T. A. Milne,et al.  Biomass Gasifier "Tars": Their Nature, Formation, and Conversion , 1998 .

[53]  Detlef Stolten,et al.  Industrial Scale Hydrogen Production from Biomass via CHOREN’s Unique Carbo-V-process , 2010 .

[54]  Marco Baratieri,et al.  The use of biomass syngas in IC engines and CCGT plants: A comparative analysis , 2009 .

[55]  J. Schneider,et al.  Sorptive H2S removal by impregnated activated carbons for the production of SNG , 2015 .

[56]  N. Ullrich.  ThyssenKrupp Industrial Solution's Gasification Technologies PRENFLO® and HTWTM for B‐XTL Technologies , 2014 .

[57]  E. Dinjus,et al.  The bioliq® bioslurry gasification process for the production of biosynfuels, organic chemicals, and energy , 2012, Energy, Sustainability and Society.

[58]  Staffan Jacobsson,et al.  The politics and policy of energy system transformation—explaining the German diffusion of renewable energy technology , 2006 .

[59]  Haimiao Yu,et al.  Experimental research on oxygen-enriched gasification of straw in an entrained-flow gasifier , 2013 .

[60]  Jinyue Yan,et al.  Increasing biomass utilisation in energy systems: a comparative study of CO2 reduction and cost for different bioenergy processing options. , 2004 .

[61]  J. J. Pis,et al.  Influence of torrefaction on the grindability and reactivity of woody biomass , 2008 .

[62]  B. Erlach,et al.  Entrained flow gasification of biocoal from hydrothermal carbonization , 2012 .

[63]  M. H. Chakrabarti,et al.  The effect of temperature on various parameters in coal, biomass and CO-gasification: A review , 2012 .

[64]  K. Cen,et al.  Biomass-oxygen gasification in a high-temperature entrained-flow gasifier. , 2009, Biotechnology advances.

[65]  N. K. Sinha,et al.  Drag on non-spherical particles: an evaluation of available methods , 1999 .

[66]  L. Schiller.  Uber die Grundlegenden Berechnungen bei der Schwerkraftaufbereitung , 1933 .