Efficient microwave-assisted synthesis of 5-hydroxymethylfurfural from concentrated aqueous fructose.

Studies on the HCl-catalysed microwave-assisted dehydration of highly concentrated aqueous fructose (27 wt%) to 5-hydroxymethylfurfural (HMF) revealed a significant increase in the fructose conversion rate over the conventional heated systems. Water, being the most benign solvent and therefore ideal for green and sustainable chemistry, normally is a poor solvent for the dehydration process resulting in low HMF selectivities and yields. However, reaction at 200 degrees C with microwave irradiation with a short reaction time of only 1s resulted in good HMF selectivity of 63% and fructose conversion of 52%, while prolonged irradiation for 60s (or more) resulted in nearly full fructose conversion (95%) but lower HMF yield (53%). Decreasing the fructose concentration significantly improved the HMF selectivity, but possibly made the production route less attractive from an industrial point of view due to the resultant low throughput.

[1]  Antoine Gaset,et al.  Selective conversion of D-fructose to 5-hydroxymethyl-2-furancarboxaldehyde using a water-solvent-ion-exchange resin triphasic system , 1981 .

[2]  Johnathan E. Holladay,et al.  Top Value Added Chemicals From Biomass. Volume 1 - Results of Screening for Potential Candidates From Sugars and Synthesis Gas , 2004 .

[3]  M. Mednick.  The Acid-Base-Catalyzed Conversion of Aldohexose into 5-(Hydroxymethyl)-2-furfural2 , 1962 .

[4]  J. Ying,et al.  Efficient catalytic system for the selective production of 5-hydroxymethylfurfural from glucose and fructose. , 2008, Angewandte Chemie.

[5]  R. Smith,et al.  Catalytic dehydration of fructose into 5-hydroxymethylfurfural by ion-exchange resin in mixed-aqueous system by microwave heating , 2008 .

[6]  H. V. Bekkum,et al.  The Conversion of Fructose and Glucose in Acidic Media: Formation of Hydroxymethylfurfural , 1986 .

[7]  Charlotte K. Williams,et al.  The Path Forward for Biofuels and Biomaterials , 2006, Science.

[8]  R. Smith,et al.  Catalytical conversion of fructose and glucose into 5-hydroxymethylfurfural in hot compressed water by microwave heating , 2008 .

[9]  H. Vogel,et al.  Dehydration of fructose to 5-hydroxymethylfurfural in sub- and supercritical acetone , 2003 .

[10]  M. Mascal,et al.  Direct, high-yield conversion of cellulose into biofuel. , 2008, Angewandte Chemie.

[11]  Richard M. Musau,et al.  The preparation of 5-hydroxymethyl-2-furaldehyde (HMF) from d-fructose in the presence of DMSO , 1987 .

[12]  Yuriy Román-Leshkov,et al.  Phase Modifiers Promote Efficient Production of Hydroxymethylfurfural from Fructose , 2006, Science.

[13]  B. Kuster,et al.  5‐Hydroxymethylfurfural (HMF). A Review Focussing on its Manufacture , 1990 .

[14]  J. Horvat,et al.  Mechanism of levulinic acid formation , 1985 .

[15]  Gerard Avignon,et al.  Dehydration of fructose to 5-hydroxymethylfurfural over H-mordenites , 1996 .

[16]  M. Schlaf.  Selective deoxygenation of sugar polyols to α,ω-diols and other oxygen content reduced materials—a new challenge to homogeneous ionic hydrogenation and hydrogenolysis catalysis , 2006 .

[17]  A. Corma,et al.  Chemical routes for the transformation of biomass into chemicals. , 2007, Chemical reviews.

[18]  James A. Dumesic,et al.  Production of 5-hydroxymethylfurfural and furfural by dehydration of biomass-derived mono- and poly-saccharides , 2007 .

[19]  Yuriy Román‐Leshkov,et al.  Production of dimethylfuran for liquid fuels from biomass-derived carbohydrates , 2007, Nature.

[20]  H. Vogel,et al.  Dehydration of d-fructose to hydroxymethylfurfural in sub- and supercritical fluids , 2005 .

[21]  Johnathan E. Holladay,et al.  Metal Chlorides in Ionic Liquid Solvents Convert Sugars to 5-Hydroxymethylfurfural , 2007, Science.

[22]  Jeppe Rass-Hansen,et al.  The renewable chemicals industry. , 2008, ChemSusChem.