Stable Operation and Electricity Generating Characteristics of a Single-Cylinder Free Piston Engine Linear Generator: Simulation and Experiments

We present a novel design of a single-cylinder free piston engine linear generator (FPELG) incorporating a linear motor as a rebound device. A systematic simulation model of this FPELG system was built containing a kinematic and dynamic model of the piston and mover, a magneto-electric model of the linear generator, a thermodynamic model of the single-cylinder engine, and a friction model between the piston ring and cylinder liner. Simulations were performed to understand the relationships between pre-set motor parameters and the running performance of the FPELG. From the simulation results, it was found that a motor rebound force with a parabolic profile had clear advantages over a force with a triangular profile, such as a higher running frequency and peak cylinder pressure, faster piston motion, etc. The rebound position and the amplitude of rebound force were also determined by simulations. The energy conversion characteristics of the generator were obtained from our FPELG test rig. The parameters of intake pressure, motor frequency, and load resistance were varied over certain ranges, and relationships among these three parameters were obtained. The electricity-generating characteristic parameters include output power and system efficiency, which can measure the quality of matching the controllable parameters. The output power can reach 25.9 W and the system efficiency can reach 13.7%. The results in terms of matching parameters and electricity-generating characteristics should be useful to future research in adapting these engines to various operating modes.

[1]  Changlu Zhao,et al.  An experimental study of the cycle stability of hydraulic free-piston engines , 2013 .

[2]  Ocktaeck Lim,et al.  A study of a two-stroke free piston linear engine using numerical analysis , 2014 .

[3]  Richard J. Atkinson,et al.  Numerical Simulation of a Two-Stroke Linear Engine-Alternator Combination , 1999 .

[4]  刘栋,et al.  Numerical Simulation of a Spark Ignited Two-Stroke Free-Piston Engine Generator , 2009 .

[5]  R. Mikalsen,et al.  Performance simulation of a spark ignited free-piston engine generator , 2008 .

[6]  Liu Dong.  Numerical Simulation of a Spark Ignited Two-Stroke Free-Piston Engine Generator , 2009 .

[7]  Zhengxing Zuo,et al.  Parameters coupling designation of diesel free-piston linear alternator , 2011 .

[8]  R. Mikalsen,et al.  The design and simulation of a two-stroke free-piston compression ignition engine for electrical power generation , 2008 .

[9]  Jaeheun Kim,et al.  Simulation on the effect of the combustion parameters on the piston dynamics and engine performance using the Wiebe function in a free piston engine , 2013 .

[10]  R. Mikalsen,et al.  The control of a free-piston engine generator. Part 2: Engine dynamics and piston motion control , 2010 .

[11]  Peter Van Blarigan,et al.  A numerical study of a free piston ic engine operating on homogeneous charge compression ignition combustion , 1999 .

[12]  Takaji Umeno,et al.  Development of Free Piston Engine Linear Generator System Part 2 - Investigation of Control System for Generator , 2014 .

[13]  G. Hohenberg.  Advanced Approaches for Heat Transfer Calculations , 1979 .

[14]  R. Mikalsen,et al.  Predictive piston motion control in a free-piston internal combustion engine ✩ , 2010 .

[15]  Richard C. Rosenberg,et al.  General Friction Considerations for Engine Design , 1982 .

[16]  Chia-Jui Chiang,et al.  Dynamic modeling of a SI/HCCI free-piston engine generator with electric mechanical valves , 2013 .

[17]  Wen Li,et al.  Multi-dimensional scavenging analysis of a free-piston linear alternator based on numerical simulation , 2011 .

[18]  Jin Xiao,et al.  Simulation of a Two-Stroke Free-Piston Engine for Electrical Power Generation , 2008 .

[19]  Yang Wang,et al.  The control of an opposed hydraulic free piston engine , 2014 .

[20]  R. Mikalsen,et al.  A review of free-piston engine history and applications , 2007 .

[21]  R. Mikalsen,et al.  The control of a free-piston engine generator. Part 1: Fundamental analyses , 2010 .

[22]  Takaji Umeno,et al.  Development of Free Piston Engine Linear Generator System Part 1 - Investigation of Fundamental Characteristics , 2014 .