Development of a Dynamic Cathode Ejector Model for Solid Oxide Fuel Cell-Gas Turbine Hybrid Systems

Solid oxide fuel cell-gas turbine (SOFC-GT) hybrid systems are attractive for future power generation with ultra-low criteria pollutant and greenhouse gas emissions. One of the challenges for SOFC-GT systems is to sufficiently pre-heat incoming air before it enters the fuel cell cathode. An ejector for cathode exhaust recirculation has the benefits of reliability, low maintenance, and cost compared to either recuperators or cathode recirculation blowers, which may be also be used for air pre-heating. In this study, a dynamic Simulink model of an ejector for cathode exhaust recirculation to pre-heat incoming fuel cell air has been developed. The ejector is to be utilized within a 100 MW SOFC-GT dynamic model operating on coal syngas. A thorough theoretical development is presented. Results for the ejector were found to be in good agreement with those reported in literature. © 2011 American Society of Mechanical Engineers.

[1]  Rory A. Roberts,et al.  Dynamic Simulation of a Pressurized 220kW Solid Oxide Fuel-Cell–Gas-Turbine Hybrid System: Modeled Performance Compared to Measured Results , 2006 .

[2]  Paola Costamagna,et al.  Design and part-load performance of a hybrid system based on a solid oxide fuel cell reactor and a micro gas turbine , 2001 .

[3]  Kyeongmin Oh,et al.  Analysis of the design of a pressurized SOFC hybrid system using a fixed gas turbine design , 2007 .

[4]  Ashok Rao,et al.  Sensitivity analysis of a Vision 21 coal based zero emission power plant , 2006 .

[5]  J. Keenan,et al.  An Investigation of Ejector Design by Analysis and Experiment , 1950 .

[6]  Jack Brouwer,et al.  Quasi-three dimensional dynamic model of a proton exchange membrane fuel cell for system and controls development , 2007 .

[7]  Jack Brouwer,et al.  Dynamic simulation of carbonate fuel cell-gas turbine hybrid systems , 2006 .

[8]  Fabian Mueller,et al.  Dynamic Simulation of an Integrated Solid Oxide Fuel Cell System Including Current-Based Fuel Flow Control , 2005 .

[9]  Y. Çengel,et al.  Thermodynamics : An Engineering Approach , 1989 .

[10]  G. S. Samuelsen,et al.  A thermodynamic analysis of tubular solid oxide fuel cell based hybrid systems , 2003 .

[11]  H. J. Richter,et al.  Combined Cycle Gas Turbine Power Plant With Coal Gasification and Solid Oxide Fuel Cell , 1996 .

[12]  David Tucker,et al.  General fuel cell hybrid synergies and hybrid system testing status , 2006 .

[13]  G. S. Samuelsen,et al.  Power and temperature control of fluctuating biomass gas fueled solid oxide fuel cell and micro gas turbine hybrid system , 2006 .

[14]  P. C van der Laag,et al.  Prospects for advanced coal-fuelled fuel cell power plants , 1994 .

[15]  Alberto Traverso,et al.  Influence of the anodic recirculation transient behaviour on the SOFC hybrid system performance , 2005 .

[16]  Christian Wächter,et al.  Dynamic Model of a Pressurized SOFC/Gas Turbine Hybrid Power Plant for the Development of Control Concepts , 2006 .

[17]  Faryar Jabbari,et al.  Novel solid oxide fuel cell system controller for rapid load following , 2007 .

[18]  S. Bhattacharya,et al.  Combination of thermochemical recuperative coal gasification cycle and fuel cell for power generation , 2005 .

[19]  Satha Aphornratana,et al.  Evaluation of a novel combined ejector-absorption refrigeration cycle — I: computer simulation , 1996 .

[20]  Jack Brouwer,et al.  Control design of an atmospheric solid oxide fuel cell/gas turbine hybrid system: Variable versus fixed speed gas turbine operation , 2006 .

[21]  G. S. Samuelsen,et al.  Analysis Strategies for Tubular Solid Oxide Fuel Cell Based Hybrid Systems , 2002 .

[22]  Aristide F. Massardo,et al.  Design and Testing of Ejectors for High Temperature Fuel Cell Hybrid Systems , 2006 .

[23]  Rory A. Roberts,et al.  Control Design for a Bottoming Solid Oxide Fuel Cell Gas Turbine Hybrid System , 2006 .

[24]  Satha Aphornratana,et al.  Ejectors: applications in refrigeration technology , 2004 .

[25]  Alberto Traverso,et al.  Gas Turbine Assessment for Air Management of Pressurized SOFC/GT Hybrid Systems , 2007 .

[26]  Rainer Kurz,et al.  Parameter Optimization on Combined Gas Turbine-Fuel Cell Power Plants , 2005 .

[27]  Loredana Magistri,et al.  Ejector performance influence on a solid oxide fuel cell anodic recirculation system , 2004 .

[28]  G. K. Alexis,et al.  Investigation of ejector design at optimum operating condition , 2000 .

[29]  W. Winkler,et al.  The design of stationary and mobile solid oxide fuel cell–gas turbine systems , 2002 .

[30]  Fabian Mueller,et al.  Synergistic integration of a gas turbine and solid oxide fuel cell for improved transient capability , 2008 .

[31]  Aristide F. Massardo,et al.  Design and Off-Design Analysis of a MW Hybrid System Based on Rolls-Royce Integrated Planar Solid Oxide Fuel Cells , 2007 .

[32]  Olav Bolland,et al.  Finite-volume modeling and hybrid-cycle performance of planar and tubular solid oxide fuel cells , 2005 .

[33]  Wolfgang Winkler.  Fuel Cell Hybrids, Their Thermodynamics and Sustainable Development , 2005 .