Growth of Soot Particles in Premixed Flames by Surface Reactions

Mean radii, number densities and specific surface areas of the soot particles generated in laminar premixed flames are measured by means of laser light extinction and scattering. Temperatures are obtained from thermal radiation of soot particles and by applying the sodium-D-line reversal method. Gas samples of the flames are analysed by means of mass-spectrometry. The experimental part of this work covers two series of experiments in sooting ethyne-oxygen-argon flames. These experiments were performed to elucidate some hypotheses for soot formation and surface growth: The dependence of soot appearance rates on the surface area of the soot particles is investigated. For this flames are seeded with alkali metal solutions to prevent the soot particles from coagulation. These flames are compared with the equivalent unseeded flames. The experimental results give the appearance rates of soot as beeing independent of the outer surface of the soot particle aggregates. The influence of chemical composition - in particular the dependence of the soot appearance rate on the ethyne partial pressure - on soot formation has been experimentally investigated. For this, flames with different pressure, flow rates, and composition of the feed have been investigated. The experiments show that the appearance rate of soot is not simply proportional to the ethyne partial pressure as stated in frequently used surface growth models but rather influenced by a number of flame properties.

[1]  C. Dasch.  The decay of soot surface growth reactivity and its importance in total soot formation , 1985 .

[2]  I. Glassman.  Soot formation in combustion processes , 1989 .

[3]  H. Bockhorn,et al.  Some new observations concerning the mass growth of soot in premixed hydrocarbon-oxygen flames , 1989 .

[4]  B. Haynes,et al.  Soot surface growth at active sites , 1991 .

[5]  Henning Bockhorn,et al.  Soot Formation in Combustion , 1994 .

[6]  H. Bockhorn,et al.  Investigation of the surface growth of soot in flat low pressure hydrocarbon oxygen flames , 1985 .

[7]  Jack B. Howard,et al.  Fullerenes synthesis in combustion , 1992 .

[8]  B. Lüers,et al.  The influence of pressure and temperature on soot formation in premixed flames , 1989 .

[9]  C. P. Lazzara,et al.  Molecular beam mass spectrometry applied to determining the kinetics of reactions in flames. I. Empirical characterization of flame perturbation by molecular beam sampling probes , 1974 .

[10]  Michael Frenklach,et al.  Detailed Modeling of PAH Profiles in a Sooting Low-Pressure Acetylene Flame , 1987 .

[11]  K. H. Homann,et al.  Formation of large molecules, particulates and ions in premixed hydrocarbon flames; Progress and unresolved questions , 1985 .

[12]  S. Harris.  Surface Growth and Soot Particle Reactivity , 1990 .

[13]  A. F. Sarofim,et al.  Optical Constants of Soot and Their Application to Heat-Flux Calculations , 1969 .

[14]  F. Fetting,et al.  Untersuchung der Bildung und des Wachstums von Rußteilchen in vorgemischten Kohlenwasserstoff – Sauerstoff Unterdruckflammen , 1987 .

[15]  B. Haynes,et al.  The Surface Growth Phenomenon in Soot Formation , 1982 .

[16]  H. F. Calcote.  Mechanisms of soot nucleation in flames—A critical review , 1981 .

[17]  J. Howard.  Fullerenes formation in flames , 1993 .

[18]  J. Lahaye,et al.  Soot in combustion systems and its toxic properties , 1983 .

[19]  M. Frenklach,et al.  Detailed modeling of soot particle nucleation and growth , 1991 .

[20]  H. Wagner,et al.  Rußbildung in verschiedenen Brennstoff-Luft-Flammen , 1983 .

[21]  B. Haynes,et al.  Optical Studies of Soot‐Formation Processes in Premixed Flames , 1980 .

[22]  B. Lüers,et al.  Soot formation in premixed C2H4-air flames for pressures up to 100 bar , 1992 .

[23]  C. P. Lazzara,et al.  Concentration profiles for radical species in a methane-oxygen-argon flame , 1973 .

[24]  A. D'alessio.  Laser Light Scattering and Fluorescence Diagnostics of Rich Flames Produced by Gaseous and Liquid Fuels , 1981 .

[25]  J. Howard.  Carbon addition and oxidation reactions in heterogeneous combustion and soot formation , 1991 .

[26]  S. Harris.  Soot particle inception and O2 profiles in a premixed ethylene flame , 1986 .