A Large Response Range Reflectometric Urea Biosensor Made from Silica-Gel Nanoparticles

A new silica-gel nanospheres (SiO2NPs) composition was formulated, followed by biochemical surface functionalization to examine its potential in urea biosensor development. The SiO2NPs were basically synthesized based on sol–gel chemistry using a modified Stober method. The SiO2NPs surfaces were modified with amine (-NH2) functional groups for urease immobilization in the presence of glutaric acid (GA) cross-linker. The chromoionophore pH-sensitive dye ETH 5294 was physically adsorbed on the functionalized SiO2NPs as pH transducer. The immobilized urease determined urea concentration reflectometrically based on the colour change of the immobilized chromoionophore as a result of the enzymatic hydrolysis of urea. The pH changes on the biosensor due to the catalytic enzyme reaction of immobilized urease were found to correlate with the urea concentrations over a linear response range of 50–500 mM (R2 = 0.96) with a detection limit of 10 mM urea. The biosensor response time was 9 min with reproducibility of less than 10% relative standard deviation (RSD). This optical urea biosensor did not show interferences by Na+, K+, Mg2+ and NH4+ ions. The biosensor performance has been validated using urine samples in comparison with a non-enzymatic method based on the use of p-dimethylaminobenzaldehyde (DMAB) reagent and demonstrated a good correlation between the two different methods (R2 = 0.996 and regression slope of 1.0307). The SiO2NPs-based reflectometric urea biosensor showed improved dynamic linear response range when compared to other nanoparticle-based optical urea biosensors.

[1]  W. Takashima,et al.  Development of a potentiometric urea biosensor based on copolymer poly(N-3-aminopropyl pyrrole-co-pyrrole) film , 2005 .

[2]  E. Vansant,et al.  Further investigations on the modified Stöber method for spherical MCM-41 , 2006 .

[3]  S. Lanceros‐Méndez,et al.  Hydrothermal assisted synthesis of iron oxide-based magnetic silica spheres and their performance in magnetophoretic water purification , 2012 .

[4]  Lucia Gardossi,et al.  Understanding enzyme immobilisation. , 2009, Chemical Society reviews.

[5]  T. Zor,et al.  Linearization of the Bradford protein assay increases its sensitivity: theoretical and experimental studies. , 1996, Analytical biochemistry.

[6]  C. S. Sipaut,et al.  Structural and thermal characterizations of silica nanoparticles grafted with pendant maleimide and epoxide groups. , 2008, Journal of colloid and interface science.

[7]  Mikio Konno,et al.  Preparation of silica-polystyrene core-shell particles up to micron sizes. , 2004, Journal of colloid and interface science.

[8]  J A Cox,et al.  Chemical and biochemical sensors based on advances in materials chemistry. , 1999, Journal of pharmaceutical and biomedical analysis.

[9]  Noorsaiyyidah Darman Singho,et al.  Complex Impedance Spectroscopy Study of Silica Nanoparticles Via Sol-Gel Method , 2012, International Journal of Electrochemical Science.

[10]  Jean-Louis Marty,et al.  A review of the use of genetically engineered enzymes in electrochemical biosensors. , 2009, Seminars in cell & developmental biology.

[11]  S. W. Kim,et al.  Covalent immobilization of GL-7-ACA acylase on silica gel through silanization , 2002 .

[12]  Wensheng Yang,et al.  Multilayered construction of glucose oxidase and silica nanoparticles on Au electrodes based on layer-by-layer covalent attachment. , 2006, Biomaterials.

[13]  Dan Xiao,et al.  Gold nanoparticles-coated eggshell membrane with immobilized glucose oxidase for fabrication of glucose biosensor , 2011 .

[14]  Chung-Yuan Mou,et al.  Mesoporous materials for encapsulating enzymes , 2009 .

[15]  Bao-zong Li,et al.  Preparation of helical mesoporous ethylene–silica nanofibers using CTAB and (S)-2-methyl-1-butanol , 2011 .

[16]  István Lagzi,et al.  Nanoseparations: Strategies for size and/or shape-selective purification of nanoparticles , 2011 .

[17]  M. M. Bradford.  A rapid and sensitive method for the quantitation of microgram quantities of protein utilizing the principle of protein-dye binding. , 1976, Analytical biochemistry.

[18]  S. Alegret,et al.  Novel routes for inter-matrix synthesis and characterization of polymer stabilized metal nanoparticles for molecular recognition devices , 2006 .

[19]  R. Apak,et al.  An optical fibre reflectance sensor for p-aminophenol determination based on tetrahydroxycalix[4]arene as sensing reagent , 2009 .

[20]  Lee Yook Heng,et al.  An optical biosensor for dichlovos using stacked sol-gel films containing acetylcholinesterase and a lipophilic chromoionophore. , 2006, Talanta.

[21]  C. Limsakul,et al.  Comparative study of controlled pore glass, silica gel and poraver for the immobilization of urease to determine urea in a flow injection conductimetric biosensor system. , 2004, Biosensors & bioelectronics.

[22]  R. Apak,et al.  Development of an optical fibre reflectance sensor for p-aminophenol detection based on immobilised bis-8-hydroxyquinoline. , 2008, Talanta.

[23]  D. Kriz,et al.  A preliminary study of a biosensor based on flow injection of the recognition element , 1996 .

[24]  I. Tothill,et al.  Development of urease and glutamic dehydrogenase amperometric assay for heavy metals screening in polluted samples. , 2004, Biosensors & bioelectronics.

[25]  A. Minnaard,et al.  Chemical immobilisation of humic acid on silica , 1998 .

[26]  V. Castaño,et al.  Organic–inorganic hybrid coating (poly(methyl methacrylate)/monodisperse silica) , 2005 .

[27]  Alberto N. Araújo,et al.  Development of a sol-gel optical sensor for analysis of zinc in pharmaceuticals , 2004 .

[28]  G. Wang,et al.  Facile synthesis of Fe3O4/SiO2 composite nanoparticles from primary silica particles , 2008 .

[29]  Feliksas Ivanauskas,et al.  The influence of external factors on the operational stability of the biosensor response. , 2010, Talanta.

[30]  R. Srivastava,et al.  Nanoengineered optical urea biosensor for estimating hemodialysis parameters in spent dialysate. , 2010, Analytica Chimica Acta.

[31]  Yong-mei Wang,et al.  Silica/poly(N,N′-methylenebisacrylamide) composite materials by encapsulation based on a hydrogen-bonding interaction , 2007 .

[32]  M S Thakur,et al.  Enhancement of operational stability of an enzyme biosensor for glucose and sucrose using protein based stabilizing agents. , 2002, Biosensors & bioelectronics.

[33]  I. Lakatos,et al.  Colloids Surfaces A: Physicochem , 1998 .

[34]  A. Michalska,et al.  Dual potentiometric and UV/Vis spectrophotometric disposable sensors with dispersion cast polyaniline , 2010 .

[35]  M. Mutlu,et al.  A KINETIC APPROACH TO OXIDASE BASED ENZYME ELECTRODES : THE EFFECT OF ENZYME LAYER FORMATION ON THE RESPONSE TIME , 1998 .

[36]  L. Singh,et al.  Preparation of Silica Nanoparticles and its Beneficial Role in Cementitious Materials , 2011 .

[37]  Zhengpeng Yang,et al.  Piezoelectric urea biosensor based on immobilization of urease onto nanoporous alumina membranes. , 2007, Biosensors & bioelectronics.

[38]  Lee Yook Heng,et al.  A Urea Biosensor from Stacked Sol-Gel Films with Immobilized Nile Blue Chromoionophore and Urease Enzyme , 2007, Sensors.

[39]  Use of CdSe/ZnS luminescent quantum dots incorporated within sol-gel matrix for urea detection. , 2008, Analytica chimica acta.

[40]  M. Sameti,et al.  Modified silica particles for gene delivery , 2003 .

[41]  G. Shan,et al.  Synthesis of amino-silane modified superparamagnetic silica supports and their use for protein immobilization , 2004 .

[42]  B. Krajewska.  Ureases I. Functional, catalytic and kinetic properties: A review , 2009 .

[43]  S. Ahn,et al.  Surface modification of silica nanoparticles with hydrophilic polymers , 2010 .

[44]  B. Kovács,et al.  Optical biosensor for urea with improved response time. , 2003, Biosensors & bioelectronics.

[45]  Nahar Singh,et al.  Potentiometric urea biosensor based on multi-walled carbon nanotubes (MWCNTs)/silica composite material , 2011 .

[46]  U. Hanefeld,et al.  Understanding Enzyme Immobilization , 2009 .

[47]  Jianfeng Chen,et al.  Comparative study of solid silica nanoparticles and hollow silica nanoparticles for the immobilization of lysozyme , 2008 .

[48]  Junhui He,et al.  Rapid evaporation-induced synthesis of monodisperse budded silica spheres. , 2007, Journal of colloid and interface science.

[49]  Zhiwu Chen,et al.  Synthesis and enhanced electrochemical properties of pod-shaped gold/silica nanoparticles , 2010 .

[50]  B. Speiser,et al.  Stöber silica particles as basis for redox modifications: particle shape, size, polydispersity, and porosity. , 2012, Journal of colloid and interface science.

[51]  Ahmad Musa,et al.  A Biosensor for Urea from Succinimide-Modified Acrylic Microspheres Based on Reflectance Transduction , 2011, Sensors.

[52]  K. Sawicka,et al.  Electrospun biocomposite nanofibers for urea biosensing , 2005 .

[53]  H. Nishikawa,et al.  Correlation between the luminescence properties and the surface structures of submicron silica particles , 2007 .

[54]  J. Park,et al.  Sol-gel-derived thick-film conductometric biosensor for urea determination in serum , 2000 .

[55]  J. Garrido,et al.  Silica xerogels of tailored porosity as support matrix for optical chemical sensors. Simultaneous effect of pH, ethanol:TEOS and water:TEOS molar ratios, and synthesis temperature on gelation time, and textural and structural properties , 2007 .

[56]  Keiichi Kaneto,et al.  An amperometric urea biosensor based on covalent immobilization of urease onto an electrochemically prepared copolymer poly (N-3-aminopropyl pyrrole-co-pyrrole) film. , 2005, Biomaterials.

[57]  M. Vallet‐Regí,et al.  Structural characterization of nanosized silica spheres , 2007 .

[58]  Audrey Sassolas,et al.  Immobilization strategies to develop enzymatic biosensors. , 2012, Biotechnology advances.

[59]  Arunava Goswami,et al.  Synthesis of surface functionalized silica nanoparticles and their use as entomotoxic nanocides , 2012 .

[60]  L. Nie,et al.  A new urea sensor based on combining the surface acoustic wave device with urease extracted from green soya bean and its application--determination of urea in human urine. , 1996, Biosensors & bioelectronics.

[61]  L. Petit,et al.  Luminescence properties of Eu3+ or Dy3+/Au co-doped SiO2 nanoparticles , 2007 .

[62]  E. Bakker,et al.  Optical determination of ionophore diffusion coefficients in plasticized poly(vinyl chloride) sensing films , 2004 .

[63]  Sidney A. Williams,et al.  Official Methods of Analysis of the Association of Official Analytical Chemists , 1971, Soil Science Society of America Journal.

[64]  S. Vivekanandhan,et al.  Ammonium carboxylates assisted combustion process for the synthesis of nanocrystalline LiCoO2 powders , 2008 .

[65]  Ningning Zhu,et al.  Tris(2,2′-bipyridyl)cobalt(III)-doped silica nanoparticle DNA probe for the electrochemical detection of DNA hybridization , 2003 .

[66]  Xiao-hui Liu,et al.  Aminopropyl-functionalized silicas synthesized by W/O microemulsion for immobilization of penicillin G acylase , 2009 .

[67]  Xiao-hui Liu,et al.  Superparamagnetic aminopropyl-functionalized silica core-shell microspheres as magnetically separable carriers for immobilization of penicillin G acylase , 2010 .

[68]  Martin M. F. Choi,et al.  Nicotine derivative optode membrane with nonactin as ionophore. , 2002, Talanta.

[69]  F. Kuralay,et al.  Potentiometric enzyme electrode for urea determination using immobilized urease in poly(vinylferrocenium) film , 2005 .

[70]  Franja Šulek,et al.  Surface functionalization of silica-coated magnetic nanoparticles for covalent attachment of cholesterol oxidase , 2010 .

[71]  Roger A. Sheldon,et al.  Enzyme Immobilization: The Quest for Optimum Performance , 2007 .

[72]  Tianhong Cui,et al.  Ion-sensitive field-effect transistor based pH sensors using nano self-assembled polyelectrolyte/nanoparticle multilayer films , 2007 .

[73]  Wenming Tang,et al.  Multi-peak behavior of photoluminescence of silica particles heat-treated in hydrogen at elevated temperature , 2007 .

[74]  A. Araújo,et al.  Optical sensors and biosensors based on sol-gel films. , 2007, Talanta.

[75]  H. Chang,et al.  Immobilization of Mucor javanicus lipase on effectively functionalized silica nanoparticles , 2006 .

[76]  Xiaolan Song,et al.  Synthesis of CeO2-coated SiO2 nanoparticle and dispersion stability of its suspension , 2008 .

[77]  Keiichi Kaneto,et al.  A novel thin film urea biosensor based on copolymer poly(N-3-aminopropylpyrrole-co-pyrrole) film , 2005 .

[78]  H. Gu,et al.  Synthesis and characterization of pore size-tunable magnetic mesoporous silica nanoparticles. , 2011, Journal of colloid and interface science.