Tonal noise production from a wall-mounted finite airfoil

Abstract This study is concerned with the flow-induced noise of a smooth wall-mounted finite airfoil with flat ended tip and natural boundary layer transition. Far-field noise measurements have been taken at a single observer location and with a microphone array in the Virginia Tech Stability Wind Tunnel for a wall-mounted finite airfoil with aspect ratios of L / C = 1 – 3 , at a range of Reynolds numbers ( Re C = 7.9 × 10 5 – 1.6 × 10 6 , based on chord) and geometric angles of attack ( α = 0 – 6 ° ) . At these Reynolds numbers, the wall-mounted finite airfoil produces a broadband noise contribution with a number of discrete equispaced tones at non-zero angles of attack. Spectral data are also presented for the noise produced due to three-dimensional vortex flow near the airfoil tip and wall junction to show the contributions of these flow features to airfoil noise generation. Tonal noise production is linked to the presence of a transitional flow state to the trailing edge and an accompanying region of mildly separated flow on the pressure surface. The separated flow region and tonal noise source location shift along the airfoil trailing edge towards the free-end region with increasing geometric angle of attack due to the influence of the tip flow field over the airfoil span. Tonal envelopes defining the operating conditions for tonal noise production from a wall-mounted finite airfoil are derived and show that the domain of tonal noise production differs significantly from that of a two-dimensional airfoil. Tonal noise production shifts to lower Reynolds numbers and higher geometric angles of attack as airfoil aspect ratio is reduced.

[1]  J. C. Hardin,et al.  Noise radiation from the side edges of flaps , 1980 .

[2]  Alan McAlpine,et al.  On the Generation of Discrete Frequency Tones by the Flow around an Aerofoil , 1999 .

[3]  David Birch,et al.  Rollup and near-field behavior of a tip vortex , 2003 .

[4]  Richard B. Green,et al.  Vortex formation on squared and rounded tip , 2013 .

[5]  Con J. Doolan,et al.  Flow-induced noise of a wall-mounted finite airfoil at low-to-moderate Reynolds number , 2014 .

[6]  M. S. Howe.  On the generation of side-edge flap noise. [part span trailing edge flaps] , 1981 .

[7]  P. Sagaut,et al.  Numerical investigation of the tone noise mechanism over laminar airfoils , 2007, Journal of Fluid Mechanics.

[8]  Hugo E. Camargo,et al.  Calibration and Demonstration of the New Virginia Tech Anechoic Wind Tunnel , 2008 .

[9]  R. D. Mehta,et al.  Effect of wing nose shape on the flow in a wing/body junction , 1984, The Aeronautical Journal (1968).

[10]  Thomas F. Brooks,et al.  Flap Edge Aeroacoustic Measurements and Predictions , 2003 .

[11]  Michael S. Howe,et al.  Hydrodynamics and sound , 2006 .

[12]  T. Brooks,et al.  Trailing edge noise prediction from measured surface pressures , 1981 .

[13]  J. C. Hardin,et al.  Noise generation at the side edges of flaps , 1980 .

[14]  William J. Devenport,et al.  Noise from a Rotor Ingesting a Planar Turbulent Boundary Layer , 2013 .

[15]  Karl-Stéphane Rossignol,et al.  Flow Field Measurements to Characterize FlapSide-Edge Noise Generation , 2013 .

[16]  Laura A. Brooks,et al.  The effect of boundary layer type on trailing edge noise from sharp-edged flat plates at low-to-moderate Reynolds number , 2012 .

[17]  J. M. Kendall.  Measurements of noise produced by flow past lifting surfaces , 1978 .

[18]  H. Arbey,et al.  Noise generated by airfoil profiles placed in a uniform laminar flow , 1983, Journal of Fluid Mechanics.

[19]  Michaela Herr,et al.  Experimental Study on Noise Reduction through Trailing Edge Brushes , 2006 .

[21]  Martin R. Fink,et al.  Vortex Noise of Isolated Airfoils , 1972 .

[22]  T. Chong,et al.  "Ladder" structure in tonal noise generated by laminar flow around an airfoil. , 2012, The Journal of the Acoustical Society of America.

[23]  Alan McAlpine,et al.  Boundary-layer instability noise on aerofoils , 1999, Journal of Fluid Mechanics.

[24]  Thomas F. Brooks,et al.  Airfoil self-noise and prediction , 1989 .

[25]  C. Doolan,et al.  The effect of a cavity on airfoil tones , 2014 .

[26]  Joseph Katz,et al.  EFFECT OF ROUGHNESS ON ROLLUP OF TIP VORTICES ON A RECTANGULAR HYDROFOIL , 1989 .

[27]  Frank K. Lu,et al.  Surface oil flow visualization , 2010 .

[28]  M. A. Marcolini,et al.  Airfoil tip vortex formation noise , 1986 .

[29]  Sp Fiddes,et al.  Laminar Boundary Layer Aeroacoustic Instabilities , 1994 .

[30]  Thomas F. Brooks,et al.  Airfoil trailing-edge flow measurements , 1986 .

[31]  T. Chong,et al.  An Experimental Study of Tonal Noise Mechanism of Laminar Airfoils , 2009 .

[32]  Con J Doolan,et al.  Broadband trailing edge noise from a sharp-edged strut. , 2011, The Journal of the Acoustical Society of America.

[33]  Ricardo A. Burdisso,et al.  The Kevlar-walled anechoic wind tunnel , 2013 .

[34]  M. Kingan,et al.  Laminar boundary layer instability noise produced by an aerofoil , 2009 .

[35]  Yueping Guo.  Aircraft Flap Side Edge Noise Modeling and Prediction , 2011 .