Antimicrobial films produced from chitosan.

Antimicrobial films were prepared by dissolving chitosan into hydrochloric, formic, acetic, lactic and citric acid solutions. Below 40 degrees C, the counter ions could be classified into two groups based on their effect on zero-shear-rate viscosity in 2% solutions of organic acids. Chloride and citrate produced solutions with much lower viscosities than formate, acetate and lactate. At higher temperatures, these differences vanished, and the activation energies of viscous flow were all similar between 40 and 60 degrees C. Films prepared from these solutions were evaluated in tension for Young's modulus, stress and elongation at yield and break points. Films made from hydrochloric, formic and acetic acids were hard and brittle, whereas those from lactic and citric acids were soft and could be stretched. Good correlation was found between Young's modulus and volume of the counter ion. Film properties are essentially governed by the volume of the counter ion and not by the interactions between this counter ion and the macromolecule. Results suggest that acetate has the maximum molecular volume above which the film strength decreases very rapidly.

[1]  F. Tanfani,et al.  The degree of acetylation of chitins by gas chromatography and infrared spectroscopy. , 1980, Journal of biochemical and biophysical methods.

[2]  C. Rha,et al.  Mechanical properties of chitosan films: Effect of solvent acid , 1982 .

[3]  Chitosan,et al.  Advances in chitin and chitosan , 1992 .

[4]  Y. Weng,et al.  Anhydrides as antimycotic agents added to polyethylene films for food packaging , 1993 .

[5]  N. E. Dweltz,et al.  Studies on chitan (β-(1 → 4)-linked 2-acetamido-2-deoxy-D-glucan) fibers of the diatom Thalassiosira fluviatilis, Hustedt. III. The structure of chitan from x-ray diffraction and electron microscope observations , 1968 .

[6]  Fred W. Billmeyer,et al.  Textbook Of Polymer Science , 1971 .

[7]  G. Roberts,et al.  Determination of the viscometric constants for chitosan , 1982 .

[8]  P. Gennes.  Scaling Concepts in Polymer Physics , 1979 .

[9]  A D Russell,et al.  Mechanisms of bacterial resistance to non-antibiotics: food additives and food and pharmaceutical preservatives. , 1991, The Journal of applied bacteriology.

[10]  R. Holley,et al.  Inhibitory Effect of Organic Acids upon Meat Spoilage Bacteria. , 1997, Journal of food protection.

[11]  Chitosan,et al.  Chitin and chitosan : sources, chemistry, biochemistry, physical properties, and applications , 1989 .

[12]  M. V. Tracey,et al.  THE INHIBITION OF FERMENTATION IN BAKER'S YEAST BY CHITOSAN. , 1964, Biochimica et biophysica acta.

[13]  Dietrich Knorr,et al.  Antibacterial action of chitosan , 1992 .

[14]  B. Chiang,et al.  ANTIMICROBIAL AND PHYSICOCHEMICAL PROPERTIES OF METHYLCELLULOSE AND CHITOSAN FILMS CONTAINING A PRESERVATIVE , 1996 .

[15]  D. Young,et al.  Release of Calcium from Suspension-Cultured Glycine max Cells by Chitosan, Other Polycations, and Polyamines in Relation to Effects on Membrane Permeability. , 1983, Plant physiology.

[16]  G. Vinogradov,et al.  Rheology of polymers , 1980 .

[17]  Dietrich Knorr,et al.  Antimicrobial effect of water‐soluble chitosans with high hydrostatic pressure , 1991 .

[18]  Y. Weng,et al.  Inhibition of Surface Molds on Cheese by Polyethylene Film Containing the Antimycotic Imazalil. , 1992, Journal of food protection.

[19]  L. Hadwiger,et al.  The fungicidal effect of chitosan on fungi of varying cell wall composition , 1979 .