Simultaneous realization of light distribution and trapping in micromorph tandem solar cells using novel double-layered antireflection coatings

Implementing antireflection (AR) coatings in micromorph tandem solar cells is a challenging process in which not only more sunlight should get conducted into the cells, but also the current matching between subcells should either be maintained or get improved. In this work, the novel double-layered AR coatings were prepared on either one side or two sides of glass superstrates using hybridized hollow silica nanosphere (HSN) sols. As a result of improvement in light distribution via double-layered AR coatings, the current difference between the top and bottom subcells was decreased to be 0.05 mA/cm(2), much smaller than that of untreated cells, 0.33 mA/cm(2). Furthermore, the cells grown on the two-sided AR coated superstrates demonstrated the largest increases in current densities of top and bottom subcells, 4.20% and 7.53%, respectively, which were much higher than those of the cells on one-sided AR coated superstrates. The underlying origin was ascribed to the better light trapping induced by multiscale texturing at front boron-doped zinc oxide (BZO) electrodes, which resulted from the conformal growth of BZO on HSNs with unique surface morphologies. The findings provided a practical way to simultaneously realize light distribution and trapping using the two-sided AR coated glass superstrates without any amendment of layers inside micromorph tandem solar cells. (C) 2015 Elsevier B.V. All rights reserved.

[1]  C. Ballif,et al.  New progress in the fabrication of n–i–p micromorph solar cells for opaque substrates , 2013 .

[2]  Seeram Ramakrishna,et al.  Porous SiO2 anti-reflective coatings on large-area substrates by electrospinning and their application to solar modules , 2013 .

[3]  Wei Xu,et al.  Design, preparation, and durability of TiO2/SiO2 and ZrO2/SiO2 double-layer antireflective coatings in crystalline silicon solar modules , 2013 .

[4]  Jian Xu,et al.  Antifogging and antireflective silica film and its application on solar modules , 2011 .

[5]  Christophe Ballif,et al.  Solar glass with industrial porous SiO2 antireflection coating: measurements of photovoltaic module properties improvement and modelling of yearly energy yield gain , 2004 .

[6]  C. Battaglia,et al.  Micromorph thin-film silicon solar cells with transparent high-mobility hydrogenated indium oxide front electrodes , 2011 .

[7]  Jia Li,et al.  Sol–gel derived near-UV and visible antireflection coatings from hybridized hollow silica nanospheres , 2014, Journal of Sol-Gel Science and Technology.

[8]  Bofei Liu,et al.  Transparent double-period electrode with effective light management for thin film solar cells , 2013 .

[9]  M. Agrawal,et al.  Rigorous optical modeling and optimization of thin‐film photovoltaic cells with textured transparent conductive oxides , 2012 .

[10]  P. Buehlmann,et al.  In situ silicon oxide based intermediate reflector for thin-film silicon micromorph solar cells , 2007 .

[11]  C. Ballif,et al.  Resistive interlayer for improved performance of thin film silicon solar cells on highly textured substrate , 2010 .

[12]  K. Hermans,et al.  Analysis of short circuit current gains by an anti‐reflective textured cover on silicon thin film solar cells , 2013 .

[13]  Jing Zhang,et al.  Multifunctional antireflection coatings based on novel hollow silica-silica nanocomposites. , 2014, ACS applied materials & interfaces.

[14]  V. Polojärvi,et al.  Moth-Eye Antireflection Coatings Fabricated by Nanoimprint Lithography on Dilute Nitride Solar Cell , 2011 .

[15]  I. Abdulhalim.  Analytic propagation matrix method for linear optics of arbitrary biaxial layered media , 1999 .

[16]  Mau-Phon Houng,et al.  Porous SiO₂/MgF₂ broadband antireflection coatings for superstrate-type silicon-based tandem cells. , 2012, Optics express.

[17]  E. Fred Schubert,et al.  Enhanced Omnidirectional Photovoltaic Performance of Solar Cells Using Multiple‐Discrete‐Layer Tailored‐ and Low‐Refractive Index Anti‐Reflection Coatings , 2013 .

[18]  P. M. Kaminski,et al.  Multilayer Broadband Antireflective Coatings for More Efficient Thin Film CdTe Solar Cells , 2014, IEEE Journal of Photovoltaics.

[19]  Á. Morales,et al.  Surface modification of porous antireflective coatings for solar glass covers , 2011 .

[20]  Christophe Ballif,et al.  Optimized short-circuit current mismatch in multi-junction solar cells , 2013 .

[21]  Marcel Dyrba,et al.  Combined effect of light harvesting strings, anti‐reflective coating, thin glass, and high ultraviolet transmission encapsulant to reduce optical losses in solar modules , 2014 .

[22]  Christophe Ballif,et al.  Multiscale transparent electrode architecture for efficient light management and carrier collection in solar cells. , 2012, Nano letters.

[23]  Daniel J Aiken.  Antireflection Coating Design for Series Interconnected Multi-Junction Solar Cells , 2000 .

[24]  Daeyeon Lee,et al.  All-nanoparticle thin-film coatings. , 2006, Nano letters.

[25]  Jian Sun,et al.  Combined SiO2 antireflective coatings with MOCVD-ZnO:B to improve light absorption in thin-film solar cells , 2014 .

[26]  Alfred Thelen,et al.  Design of optical interference coatings , 1989 .

[27]  J. Shin,et al.  Multi-functional SiO2 moth-eye pattern for photovoltaic applications , 2014 .

[28]  Fuqiang Huang,et al.  Broadband antireflection TiO2–SiO2 stack coatings with refractive-index-grade structure and their applications to Cu(In,Ga)Se2 solar cells , 2014 .