Catalytic wet oxidation of phenol in a trickle bed reactor

Abstract Catalytic liquid phase oxidation of aqueous phenol was studied in a pilot plant trickle bed reactor using a copper oxide catalyst supported on alumina. Catalysts were prepared by impregnating CuO on alumina extrudates and on computer designed shape (CDS) alumina pellets. Phenol oxidation was carried out in a 2.54 cm diameter reactor with a catalyst bed length of 60 cm and in the pressure range of 1–15 atm and temperature range of 373–403 K Compared to alumina extrudates higher phenol conversion was achieved over CDS pellets under identical conditions. Phenol oxidation reaction was strongly affected by the temperature and pressure, however, pressure had less effect. Hydrodynamics of the reactor had strong influence on phenol oxidation reaction. A one dimensional axial dispersion model was proposed to simulate the experimental results. The model satisfactorily explains the experimental results with a deviation of ±15%.

[1]  F. Larachi,et al.  Wet air oxidation solid catalysis analysis of fixed and sparged three-phase reactors , 2001 .

[2]  D. González-Mendizabal,et al.  Liquid}solid wetting factor in trickle-bed reactors: its determination by a physical method , 1999 .

[3]  J. Levec,et al.  Catalytic oxidation of aqueous -chlorophenol and -nitrophenol solutions , 1994 .

[4]  Lixiong Li,et al.  Catalytic Oxidation in Supercritical Water , 1996 .

[5]  Krishna D.P. Nigam,et al.  Liquid distribution in trickle-bed reactors , 1998 .

[6]  Janez Levec,et al.  Catalytic liquid-phase oxidation of aqueous phenol solutions in a trickle-bed reactor , 1997 .

[7]  J. Smith,et al.  Trickle‐bed reactor performance. Part II. Reaction studies , 1975 .

[8]  F Castells,et al.  Water pollution abatement by catalytic wet air oxidation in a trickle bed reactor , 1999 .

[9]  J. Levec,et al.  Catalytic Liquid-Phase Oxidation of Phenol Aqueous Solutions. A Kinetic Investigation , 1994 .

[10]  R. Reid,et al.  The Properties of Gases and Liquids , 1977 .

[11]  Christophe Bengoa,et al.  Catalytic removal of phenol from aqueous phase using oxygen or air as oxidant , 1995 .

[12]  I. Furzer,et al.  Liquid‐phase dispersion in packed beds with two‐phase flow , 1970 .

[13]  J. Smith,et al.  Trickle‐bed reactor performance. Part I. Holdup and mass transfer effects , 1975 .

[14]  Krishna D.P. Nigam,et al.  Liquid distribution studies in trickle-bed reactors , 2001 .

[15]  Jyeshtharaj B. Joshi,et al.  Wet air oxidation , 1995 .

[16]  F. Luck.  A review of industrial catalytic wet air oxidation processes , 1996 .

[17]  Martin A. Abraham,et al.  Monolith froth reactor: Development of a novel three‐phase catalytic system , 1995 .

[18]  S. Martin,et al.  Environmental Applications of Semiconductor Photocatalysis , 1995 .

[19]  J. Levec,et al.  Catalytic oxidation of aqueous solutions of organics. An effective method for removal of toxic pollutants from waste waters , 1995 .