Tuning the Optoelectronic Properties of ZnO:Al by Addition of Silica for Light Trapping in High‐Efficiency Crystalline Si Solar Cells

Highly transparent electrodes with a well-tuned refractive index are essential for a wide range of optoelectronic devices, such as light emitting diodes and solar cells. Here, it is shown that the transparency of ZnO:Al can be improved and its refractive index can be reduced simultaneously by the addition of SiO2 into the layer. It is found that for low SiO2 concentrations, Si quenches oxygen vacancies and improves the layer transparency. At higher SiO2 concentrations a highly transparent amorphous compound of ZnxSiyO:Al forms, with a refractive index that scales down with the relative Si/Zn ratio. These layers are tested in Si heterojunction solar cells by inserting them between Si and the metallic rear contact of such devices. A consistent improvement is found in the cell short-circuit current density and external quantum efficiency with increasing Si incorporation. Our findings establish a general strategy to tune the optical properties of transparent conductive oxides for improved light management in solar cells.

[1]  Wenyong Wang,et al.  Zn2SnO4 Nanowires as Photoanode for Dye-Sensitized Solar Cells and the Improvement on Open-Circuit Voltage , 2012 .

[2]  Naoteru Matsubara,et al.  Achievement of More Than 25% Conversion Efficiency With Crystalline Silicon Heterojunction Solar Cell , 2014, IEEE Journal of Photovoltaics.

[3]  J. Garnett,et al.  Colours in Metal Glasses, in Metallic Films, and in Metallic Solutions. II , 1906 .

[4]  C. Ballif,et al.  Current Losses at the Front of Silicon Heterojunction Solar Cells , 2012, IEEE Journal of Photovoltaics.

[5]  C. Sandu,et al.  Combinatorial Discovery and Optimization of Amorphous HfO2 – Nb2O5 Mixture with Improved Transparency , 2010 .

[6]  C. Ballif,et al.  Atomic-Layer-Deposited Transparent Electrodes for Silicon Heterojunction Solar Cells , 2014, IEEE Journal of Photovoltaics.

[7]  Karl Leo,et al.  White organic light-emitting diodes: Status and perspective , 2013, 1302.3435.

[8]  C. Ballif,et al.  Record Infrared Internal Quantum Efficiency in Silicon Heterojunction Solar Cells With Dielectric/Metal Rear Reflectors , 2013, IEEE Journal of Photovoltaics.

[9]  C. Ballif,et al.  High-efficiency Silicon Heterojunction Solar Cells: A Review , 2012 .

[10]  S. Siebentritt,et al.  Highly conductive ZnO films with high near infrared transparency , 2015 .

[11]  C. Guillén,et al.  Optical, electrical and structural characteristics of Al:ZnO thin films with various thicknesses deposited by DC sputtering at room temperature and annealed in air or vacuum , 2010 .

[12]  W. Bond.  Measurement of the Refractive Indices of Several Crystals , 1965 .

[13]  Deliang Zhu,et al.  Optical properties of Al-doped ZnO thin films by ellipsometry , 2008 .

[14]  Hartwin Peelaers,et al.  Fundamental limits on optical transparency of transparent conducting oxides: Free-carrier absorption in SnO2 , 2012 .

[15]  M.C.M. van de Sanden,et al.  In situ spectroscopic ellipsometry growth studies on the Al-doped ZnO films deposited by remote plasma-enhanced metalorganic chemical vapor deposition , 2008 .

[16]  F. Zeng,et al.  The electrical, optical and magnetic properties of Si-doped ZnO films , 2012 .

[17]  Jiajun Chen,et al.  Wide bandgap Zn2GeO4 nanowires as photoanode for quantum dot sensitized solar cells , 2013 .

[18]  A. Rougier,et al.  Co-sputtered ZnO:Si thin films as transparent conductive oxides , 2012 .

[19]  C. Labrugère,et al.  Low temperature Si doped ZnO thin films for transparent conducting oxides , 2011 .

[20]  Eduard A. Cartier,et al.  Materials characterization of ZrO2–SiO2 and HfO2–SiO2 binary oxides deposited by chemical solution deposition , 2001 .

[21]  F. Smole,et al.  Parasitic absorption in the rear reflector of a silicon solar cell: Simulation and measurement of the sub-bandgap reflectance for common dielectric/metal reflectors , 2014 .

[22]  M. Pepper,et al.  Highly conducting and optically transparent Si-doped ZnO thin films prepared by spray pyrolysis , 2013 .

[23]  Hsuan-Chung Wu,et al.  Electronic and Optical Properties of Substitutional and Interstitial Si-Doped ZnO , 2012, Materials.

[24]  K. Ellmer.  Past achievements and future challenges in the development of optically transparent electrodes , 2012, Nature Photonics.

[25]  Kazuhito Tsukagoshi,et al.  Stable amorphous In2O3-based thin-film transistors by incorporating SiO2 to suppress oxygen vacancies , 2014 .

[26]  A. Aberle,et al.  Optimisation of ZnO:Al films by change of sputter gas pressure for solar cell application , 2002 .

[27]  Wenyong Wang,et al.  Direct synthesis of vertically aligned ZnO nanowires on FTO substrates using a CVD method and the improvement of photovoltaic performance , 2012, Nanoscale Research Letters.

[28]  I. Malitson.  Interspecimen Comparison of the Refractive Index of Fused Silica , 1965 .

[29]  G. Lucovsky,et al.  Microscopic model for enhanced dielectric constants in low concentration SiO2-rich noncrystalline Zr and Hf silicate alloys , 2000 .

[30]  Bernd Rech,et al.  Recent development on surface-textured ZnO:Al films prepared by sputtering for thin-film solar cell application , 2008 .

[31]  C. Ballif,et al.  >21% Efficient Silicon Heterojunction Solar Cells on n- and p-Type Wafers Compared , 2013, IEEE Journal of Photovoltaics.

[32]  Wei Zhao,et al.  Oxygen "getter" effects on microstructure and carrier transport in low temperature combustion-processed a-InXZnO (X = Ga, Sc, Y, La) transistors. , 2013, Journal of the American Chemical Society.

[33]  Sang Yeol Lee,et al.  Amorphous silicon–indium–zinc oxide semiconductor thin film transistors processed below 150 °C , 2010 .

[34]  F. J. Himpsel,et al.  Microscopic structure of the SiO 2 /Si interface , 1988 .

[35]  Myoung Hee Yun,et al.  Device Architectures for Enhanced Photon Recycling in Thin‐Film Multijunction Solar Cells , 2015 .

[36]  P. Muralt,et al.  Combinatorial High-Vacuum Chemical Vapor Deposition of Textured Hafnium-Doped Lithium Niobate Thin Films on Sapphire , 2011 .

[37]  Christophe Ballif,et al.  Low-Temperature High-Mobility Amorphous IZO for Silicon Heterojunction Solar Cells , 2015, IEEE Journal of Photovoltaics.

[38]  Martin Wegener,et al.  Spectroscopic characterization of highly doped ZnO films grown by atomic-layer deposition for three-dimensional infrared metamaterials [Invited] , 2011 .

[39]  Christophe Ballif,et al.  Infrared light management in high-efficiency silicon heterojunction and rear-passivated solar cells , 2013 .

[40]  M. Stuckelberger,et al.  Self-patterned nanoparticle layers for vertical interconnects: application in tandem solar cells. , 2014, Nano letters.

[41]  C. Ballif,et al.  Organic-inorganic halide perovskite/crystalline silicon four-terminal tandem solar cells. , 2015, Physical chemistry chemical physics : PCCP.

[42]  E. Yablonovitch.  Statistical ray optics , 1982 .

[43]  F. Tepehan,et al.  Optical and structural properties of Si-doped ZnO thin films , 2011 .

[44]  C. Ballif,et al.  Improving metal reflectors by suppressing surface plasmon polaritons: a priori calculation of the internal reflectance of a solar cell , 2013, Light: Science & Applications.